really awful
Crashes / Fires:
0 / 2
Injuries / Deaths:
0 / 0
Average Mileage:
65,344 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2004 Ford Crown Victoria:

Unsubscribe any time. We don't sell/share your email.

problem #4

Nov 132010

Crown Victoria 8-cyl

  • 104,430 miles
2004 Ford Crown Victoria intake manifold cracked, causing coolant lost and smoking engine. Vehicle emergency stopped and towed. Consumer facing expensive repair costs.

- N Las Vegas, NV, USA

problem #3

Apr 092009

Crown Victoria

  • 107,000 miles
2004 Ford Crown Victoria # 2 cylinder blew out spark plug. Had to have heli-col installed to make repair.

- Sewickley, PA, USA

problem #2

Jul 152005

Crown Victoria 8-cyl

  • Automatic transmission
  • 20,000 miles
Routinely when driving my 2004 Ford crown victory (used as a hackney carriage) automobile exhibits violent, potentially deadly behavior. The loses its operational ability and driving conditions. The latest near-accident situation unfolded as follows: While driving on the highway at a speed of 50 mph the automobile jumped (swerved) from the left lane to the right lane without me having moved the steering wheel. When I retained control of the vehicle and attempted to slow down, the car did not respond, but proceeded to jerk forward at a decreasing speed and vibrate feverishly. The brake pedal appeared to be japed half-way to the floor. The rear-axle bearings produced a lot of noise. On two other occasions (during cold weather) the engine shut-of while I was driving the car. After the car stopped, I was able to start the engine. After, the vehicle continued to jerk violently forward and backward. When steering the car home, the angle of at which I held the steering wheel, did not correspond to the direction that the car would travel in. The vehicle was purchased pre-owned with 4,000 miles on it and these severe incidents began occurring after another 2,000 miles. The vehicle has been at the dealership dozens of time, each time the service technicians said that the car is operating as designed. Twice, warranty service was denied. The vehicle currently has 26,000 miles. Ford is no willing to solve these potentially deadly issues. As a taxi driver, I am in this vehicle for 12 hours a day carrying dozens of people every day. If one of these time I am unable to catch these failures a terrible accident may happen. All these problems lead me to believe that this car as an inherent manufacturing defect, that its manufacturer Ford is not recognizing. This failure to correct their engineering failure is very serious and potentially deadly.

- Newton, MA, USA

problem #1

Mar 282005

Crown Victoria 8-cyl

  • Automatic transmission
  • 29,944 miles
The vehicle was parked and turned off. Fifteen minutes later the consumer was informed that the vehicle was on fire. The fire department responded and put the fire out. The vehicle was totaled. Consumer stated the fire started in the engine compartment. The manufacturer was going to send an engineer to investigate the fire. Witnesses said that while the vehicle was burning they could hear the engine trying to start.

- Hempstead, TX, USA