Heater coil was replaced five times. The dealer stated that radio was making the part defective. The coil went out again, and the vehicle was down. Manufacturer stated no more replacements.

- Highlands Ranch, CO, USA

Clamp on heater hose is not strong and it broke, causing fluids to leak into electrical system. Vehicle does not run properly. Contacted dealer, and dealer stated there was nothing they could do, and it not covered under warranty. Please add VIN #.

- Conroe, TX, USA

'Ford knows that the heater hose has a bad connection point at the fireall, this results is dripping water on the #4 coil pack nad causes it to burn out. This should be a recall item becaue so many other people with Ford Expedition are incuring the same problem.

- Gainesville, FL, USA

Heater hose system design defect caused hoses to leak causing subsequent damage to heater coil and spark plug, causing the vehicle to run improperly. Had to wait almost a month for parts. Problem not covered by warranty and neither was the rental car. Ford refused responsibility for design defect. The dealership where the vehicle was repaired had 3 other vehicles in the same week with the same problem. Service man reported that the design had to be changed by Ford due to hoses leaking and the newly designed hoses were on backorder.

- Angleton, TX, USA