definitely annoying
Crashes / Fires:
0 / 1
Injuries / Deaths:
0 / 0
Average Mileage:
35,178 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2002 Ford Expedition:

Unsubscribe any time. We don't sell/share your email.

problem #3

Jul 112007

Expedition 8-cyl

  • Automatic transmission
  • 48,000 miles
I am the owner of a 2002 Ford Expedition, eddie bauer edition with less than 60,000 miles. For nearly a year dome lights and windows continue to malfunction after replacing fuses many times. Mechanic indicated that there could possibly be an electrical problems, which will be costly to repair. Has there been a recall for this problem.

- Houston, TX, USA

problem #2

Mar 072005

Expedition 8-cyl

  • Automatic transmission
  • 57,535 miles
Every time it rains hard my vehicle won't start and if it does the wipers and radio will not operate when I put in reverse or drive. I took it to the dealership and they told me that it was the right side windshield seal. I asked them if this was a manufacture defect and they said no that it was the shifting of the glass when I run over bumps. The same thing was happening to a F-250 P/U when I took my vehicle in. They told me that they would have to replace the fuse box, gear module, rear wiper motor. I don't believe bumps would cause this to happen and from the sound of it, it appears to have been happening for a good while because they told me at the service department that there was mold in the gear module. I am afraid that if it rains and I am on the road that my truck might just turn off or my wipers might short out. The estimated cost for all repairs is about $1000.

- San Antonio, TX, USA

problem #1

May 232004

Expedition 4WD 8-cyl

  • Automatic transmission
  • miles
Complete fire distructin of veh. Fire appears to have started under dash in wiring harness and spread to engine compartment as well as interior of unit. Forensic analysis indicates above. Forensic report available on request. Fire started while unit parked in garage and damaged dwelling as well.

- Tampa, FL, USA