hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
120,434 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2004 Ford Freestar:

Unsubscribe any time. We don't sell/share your email.

problem #2

Aug 012018


  • 168,867 miles
The contact owns a 2004 Ford Freestar. The contact stated that the back seat near the rear wheel well became detached and the contact smelled an exhaust odor. The contact stated that the vehicle exhibited the same symptoms as listed in NHTSA campaign number: 13V081000 (seats). The vehicle was not taken to a dealer to be diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 168,867.

- Louisville, KY, USA

problem #1

Feb 272010


  • 72,000 miles
The contact owns a 2004 Ford Freestar. While driving approximately 20 mph on wet road conditions, the engine stalled without warning. He was able to coast onto the emergency lane until the vehicle came to a stop. The vehicle was towed to an independent mechanic but the technician recommended that the vehicle be inspected by an authorized dealer. The dealer stated that the catalytic converter needed to be replaced and also advised the contact to replace the transmission. There were no repairs made to the transmission and the failure persisted. The current mileage was unknown and the failure mileage was 72,000.

- Valley Stream, NY, USA