really awful
Crashes / Fires:
4 / 0
Injuries / Deaths:
1 / 0
Average Mileage:
53,833 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2002 Hyundai Sonata:

Unsubscribe any time. We don't sell/share your email.

problem #6

May 032013


  • 200,000 miles
The contact owns a 2002 Hyundai Sonata. The contact stated that while braking, the vehicle suddenly accelerated without warning. The contact was unable to maneuver the vehicle when it then crashed and traveled up the side support wires for a telephone pole. The contact was not injured. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure and hired a third-party Agency to further inspect the vehicle to determine the cause of the failure. The manufacturer would not provide a cause for the failure to the contact. The vehicle was not repaired. The failure and current mileage was 200,000.

- Chambersburg , PA, USA

problem #5

May 032013

Sonata 6-cyl

  • miles
Throttle body got stuck wide open there us a pic of this in gettysburg times I got video of the car going wild my car drove into a support line and there was nothing I could do. Hamilton Hyundai - chambersburg, pa had a few mechanics come and they told me to clean the throttle cause it was sticking I have not done so and will not until they admit there an issue I could have been killed.

- Chambersbugr , PA, USA

problem #4

Oct 272009


  • miles
The contact owns a 2002 Hyundai Sonata. When fueling the vehicle, gasoline regurgitates from the fuel tank. Also the check engine warning light was illuminated on the instrument control panel. Sometimes the vehicle will hesitate when attempting to accelerate, as if there was no fuel available. The dealer was notified, and a technician concluded that she would have to pay $900 to repair the vehicle. No repairs were made.. the failure mileage was unknown and the current mileage was 82878.

- Miramar, FL, USA

problem #3

Sep 052007

Sonata 6-cyl

  • Automatic transmission
  • 80,000 miles
On 09/04/07 I bought a used 2002 Hyundai Sonata and on 09/05/07 the car lost 1st and 4th gear it seemed as if the transmission were going out, but when I started reviewing other consumer related issues I noticed over 900 consumers had the same problems with their Hyundai's, but the cause ended up being the output speed sensor. Which in some cases took consumers up to 6 months to locate one. Unfortunately I financed the car as is with no warranty.

- Ontario, CA, USA

problem #2

May 232005

Sonata 4WD 6-cyl

  • Automatic transmission
  • miles
Caller got into car, pulled it out of garage and got out of it. When she got back into vehicle and put it in gear it made a screaming noise and accelerated. She hit the brakes, but they did not work. She tried to stop the car by going up a hill instead vehicle hit a house three doors away. Upon impact, air bags did not deploy. Insurance claimed that dealer said there nothing was wrong with car. Manufacturer has not been contacted yet.

- St Louis, MO, USA

problem #1

Aug 272002

Sonata 6-cyl

  • Automatic transmission
  • 43,000 miles
8/27/02 belt noise and burning rubber smell. The pulley belt was replaced. 1/33/03 recall on automatic transmission would not shift out of first gear. Throttle body assembly was replaced. 9/8/03 car engine raced to 5000-6000 rpms, had to turn off ignition. Service department can find no explanation. 9/16/03 check engine light comes on. While in park, engine races to 5000 rpms. After 3 restarts at the ignition, the idle returns to normal. 9/21/03 check engine light comes on. Wait to take to dealership. 10/7/03 service department says they can find no problem. 10/23/03 check engine light comes on. Service department says there is a leak in the fill vent valve, repair. 12/18/03 recall service done. 5/9/04 check engine light comes on. Ignore, it goes off after two weeks. 8/6/04 check engine light comes on. Ignore, it goes off after two weeks. 11/4/04 while traveling on a highway, vehicle does not respond to braking. Collision occurs, acceleration continues, car spins out of control across two lanes and into a grassy field. I put it in park and shut off the ignition in order to stop the car from continuing into the fencepost. Patrolman said the throttle was open. Insurance company valued the vehicle a total loss. Recall campaign: The consumer could not slow down the vehicle. After impact the consumer stated that the engine was still racing and she was still pressing the brake. The emergency brake had to be pulled to stop the vehicle. The officer on the scene started the vehicle and the engine was still racing. Yhe battery and alternator were replaced.

- North Las Vegas, NV, USA