2017 Mini Clubman
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2017 Clubman are official communications between Mini & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #M310115
A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle Read More »
-
TSB #M610220
CHECK CONTROL MESSAGES FOR BRAKE SUSPENSION AND AIR BAG SYSTEM MALFUNCTION: Multiple check control messages (CCM) can display for brake suspension and air bag system malfunction. Read More »
-
TSB #M320116
"EPS INTERMITTENT ASSIST FAILURE, FC 4823FA. The steering assistance fails after several, consecutive parking maneuvers or sustained hold at the end stop. EPS assistance starts functioning again after a few minutes. Read More »
-
TSB #M320114
The power assisted steering is unavailable at start up. No communication with the Electric Power Steering (EPS). Multiple possible fault codes. Cause: Electric Power Steering (EPS). Read More »
-
TSB #M610115
This Service Information bulletin supersedes SI M61 01 15 dated February 2015. SUBJECT Noise from Steering Column Switch Center when Turning. The customer states that there is a grating or scraping noise when the steering wheel is turned. Read More »
-
TSB #M320114
Power-assisted Steering Intermittently Not Available at Engine Startup This Service Information Bulletin (Revision 1) replaces SI M32 01 14 dated October 2016. The power assisted steering is unavailable at start up/drive readiness. Read More »
-
TSB #M320114
The power assisted steering is unavailable at start up. No communication with the Electric Power Steering (EPS). Multiple possible fault codes. Cause: Electric Power Steering (EPS). Read More »
-
TSB #M220117
Creaking Noise When Cornering: A creaking noise is heard from the front end of the vehicle while cornering (predominantly left turns) Read More »
-
TSB #M610220
CHECK CONTROL MESSAGES FOR BRAKE SUSPENSION AND AIR BAG SYSTEM MALFUNCTION: Multiple check control messages (CCM) can display for brake suspension and air bag system malfunction. Read More »
-
TSB #M310115
GROANING/SQUEAKING NOISE FROM THE FRONT OF THE VEHICLE. A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle. Read More »
-
TSB #M310115
GROANING/SQUEAKING NOISE FROM THE FRONT OF THE VEHICLE. A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle. Read More »
-
TSB #M310117
FRONT SUSPENSION RIDE HEIGHT HAS DROPPED. INFORMATION Please refer to the Electronic Parts Catalog (EPC), using the VIN to locate the part numbers. Read More »
-
TSB #M511016
"SERVICE ACTION: CHECKING AND REWORKING PVC SEAM ON STRUT TOWER. A PVC seam of the front strut spring tower may not be providing the necessary corrosion protection. Improper application of seam sealer. Read More »
-
TSB #M310115
Groaning/squeaking noise from the front of the vehicle. A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle. Read More »
-
TSB #M310315
CRACKING NOISE IN THE AREA OF THE FRONT AXLE SUPPORT/WISHBONE This Service Information bulletin supersedes SI 31 03 15 dated February 2016. Read More »
-
TSB #M310115
A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle. Read More »
-
TSB #M660220
KAFAS (CAMERA-BASED DRIVER ASSISTANCE SYSTEMS) LIMITATIONS: KAFAS camera-based assistance system (without radar) is not operating up to customer expectations. Read More »
-
TSB #M610220
CHECK CONTROL MESSAGES FOR BRAKE SUSPENSION AND AIR BAG SYSTEM MALFUNCTION: Multiple check control messages (CCM) can display for brake suspension and air bag system malfunction. Read More »
-
TSB #M340116
DRIVING STABILIZATION CONTROL FAILURE: ABS/DSC INSTRUMENT LAMPS LIT. ABS/DSC lamps lit in instrument cluster. Read More »
-
TSB #M340216
DRIVING STABILIZATION CONTROL FAILURE: ABS/DSC INSTRUMENT LAMPS LIT- DIAGNOSIS. 1. DSC's fault codes stored from two different wheel speed sensors (both front or both rear): 4809B0 - wheel speed sensor - front left - drive off recognition ... Read More »
-
TSB #M220317
CREAKING NOISE FROM THE LOWER ENGINE AREA: This Service Information Bulletin (Revision 1) replaces SI M22 03 17 dated January 2018. Read More »
-
TSB #M610220
CHECK CONTROL MESSAGES FOR BRAKE SUSPENSION AND AIR BAG SYSTEM MALFUNCTION: Multiple check control messages (CCM) can display for brake suspension and air bag system malfunction. Read More »
-
TSB #M620119
CENTRAL INSTRUMENT PANEL LED SURROUND RING DOES NOT ILLUMINATE WHEN IGNITION IS TURNED ON: This Service Information Bulletin (Revision 2) replaces SI M62 01 19 dated January 2019. Read More »
-
TSB #M220317
CREAKING NOISE FROM THE LOWER ENGINE AREA: During load reversal or taking off from a stop there is a creaking or droning noise heard from the lower engine area. Read More »
-
TSB #M160119
ENGINE STALLS AFTER STARTING OR WILL NOT START. The engine stalls right after starting (when stationary). Read More »
-
TSB #M110119
ENGINE VIBRATIONS OR NOISE. One of the following complaints may be reported: The engine runs erratically; The engine causes vibrations when running; Grinding noise from the engine compartment when engine is running. Read More »
-
TSB #M120317
"?Primarily when vehicle is at altitudes higher than 1500m above sea level, and engine is at operating temperature, the idle is sporadically elevated (up to approx. 1200 rpm). MIL indicator is illuminated. Read More »
-
TSB #M120117
MIL IS ON WITH FAULT CF0486 STORED IN THE EGS MODULE. The Service Engine Soon (MIL) light is on. The following fault is stored in the AISIN EGS module: z CF0486: EGS,PT-CAN2: Line fault/electrical fault It is possible the following Check ... Read More »
-
TSB #M120117
? MIL IS ON WITH FAULT CF0486 STORED IN THE EGS MODULE . The Service Engine Soon (MIL) light is on. The following fault is stored in the AISIN EGS module: ? CF0486: EGS,PT-CAN2: Line fault/electrical fault It is possible the following ... Read More »
-
TSB #M310315
SI M11 03 15 February 2016 Engine Technical Service This Service Information bulletin supersedes SI M11 03 15 dated April 2015. SUBJECT B38 Engine: Mixture Faults Stored in DME and Cylinder Head Cover Leaking Engine Oil. Read More »
-
TSB #M360115
SI M11 03 15 February 2016 Engine Technical Service This Service Information bulletin supersedes SI M11 03 15 dated April 2015. SUBJECT B38 Engine: Mixture Faults Stored in DME and Cylinder Head Cover Leaking Engine Oil. Read More »
-
TSB #M510216
SI M11 03 15 February 2016 Engine Technical Service This Service Information bulletin supersedes SI M11 03 15 dated April 2015. SUBJECT B38 Engine: Mixture Faults Stored in DME and Cylinder Head Cover Leaking Engine Oil. Read More »
-
TSB #M121315
?SUBJECT Service Action: Program Control Units (DME) . A Check Control Message could intermittently be displayed indicating a Start/Stop Function failure. Vehicle may not restart after stopping. Read More »
-
TSB #SIM640122
Mist formation on the windscreen inner surface may occur at departure or after MSA (automaticstart/stop). Acoustic abnormality in the area of the recirculated air flap (recirculation flap closing and opening several times). Read More »
-
TSB #M010520
B46M ENVIRONMENTAL AIR CATALYST SENSOR - LTD WTY EXT TO 15 YEARS/150,000 MILES: Component/Issue-Specific Limited Warranty Extension For the eligible vehicles, MINI USA, a division of BMW of North America, LLC ("MINI USA") is extending the ... Read More »
-
TSB #M130120
TANK VENTILATION AND MIXTURE CONTROL FAULTS STORED IN THE DME: The Engine Malfunction Warning is illuminated and one or more of the following faults are stored in the DME. Read More »
-
TSB #M640116
WATER INGRESS IN FOOTWELL AREA FROM A/C CONDENSATE DRAIN: This Service Information Bulletin (Revision 1) replaces SI M64 01 16 dated September 2016. Read More »
-
TSB #M110120
MALFUNCTION INDICATOR LAMP IS ILLUMINATED WITH A CRANKSHAFT ADAPTION FAULT: When diagnosing an illuminated malfunction indicator lamp (MIL) and/or a different issue the following fault may also be stored in the Digital Motor Electronics ... Read More »
-
TSB #M130118
DME FAULT CODE 1B8004 ENVIRONMENTAL AIR CATALYST(EAC) SENSOR: The Malfunction Indicator Lamp (MIL) light is on and the following fault code is stored in the DME: 1B8004 - EAC Sensor: Temperature - Engine coolant temperature radiator ... Read More »
-
TSB #M130119
LIN BUS COMMUNICATION FAULT FOR ENVIRONMENTAL AIR CATALYST (EAC) SENSOR FC1B8302. The malfunction indicator lamp light is on (MIL) with the following fault code stored in the DME. Read More »
-
TSB #M130119
LIN BUS COMMUNICATION FAULT FOR ENVIRONMENTAL AIR CATALYST (EAC) SENSOR FC1B8302. The malfunction indicator lamp light is on (MIL) with the following fault code stored in the DME. Read More »
-
TSB #M110117
The Service Engine Soon (MIL) light is on with the following fault stored in the Digital Motor Electronics (DME). In the situation being described the fault is only stored during the cold winter months along with the use of winter fuel. Read More »
-
TSB #M220217
KNOCKING NOISE FROM THE ENGINE COMPARTMENT. There is a knocking noise coming from the engine compartment or the engine shakes during: z Engine start z When driving off from a stop z When applying brakes CAUSE Damage to the right side ... Read More »
-
TSB #SIM010415
MINI Engine oil: repair order invoicing procedure - For covered repairs, effective with repair/claim dates on or after August 1, 2017 Warranties will only reimburse in exact quantities - the 1/10 liter "billing part numbers" for the ... Read More »
-
TSB #M220117
CREAKING NOISE WHEN CORNERING. A creaking noise is heard from the front end of the vehicle while cornering (predominantly left turns) under the following conditions: Driving In 1st or 2nd gear; While coasting or accelerating; with an ... Read More »
-
TSB #M110117
"? FAULT 118002 - MIXTURE TOO RICH SETS DURING WINTER WITH COLD AMBIENT TEMPERATURES What's New: ? In the Warranty Information section: defect code, labor operations and additional information are updated . Read More »
-
TSB #M640116
Water Ingress In Footwell Area From A/C Condensate Drain This Service Information bulletin supersedes SI M64 01 16 dated March 2016.. Damp front foot-well carpet after long period of air conditioning use. Read More »
-
TSB #M111016
"THERMOSTAT FAULTS (B-ENGINES). The Service Engine Soon light is on. A Check Control message for ""Engine overheated"" and or ""Exercise caution!"" may also display. Read More »
-
TSB #M640221
Different air temperatures are felt from left to right out of the front fresh air grilles (air vents). Read More »
-
TSB #M120219
DIAGNOSTIC HINT: CATALYTIC CONVERTER INSPECTION AFTER LOSS OF CRANKSHAFT SIGNAL: In certain situations when the crankshaft position signal is lost while driving the malfunction indicator lamp (MIL) and an engine malfunction check control ... Read More »
-
TSB #M160220
NOISES FROM THE FUEL TANK AT IDLE: While driving slowly with low RPM or while idling, a faint knocking or fluttering noise can be heard from inside the fuel tank when the tank is full. Read More »
-
TSB #M130120
TANK VENTILATION AND MIXTURE CONTROL FAULTS STORED IN THE DME: The Engine Malfunction Warning is illuminated and one or more of the following faults are stored in the DME. Read More »
-
TSB #SIB640217
The high-pressure fuel pumps (HDP: left and right) component-specific limited warranty extension to 10 Read More »
-
TSB #M230121
When the vehicle is on a lift and wheels are manually spun, a clanking noise is heard from the transmission area. Read More »
-
TSB #M130120
TANK VENTILATION AND MIXTURE CONTROL FAULTS STORED IN THE DME: The Engine Malfunction Warning is illuminated and one or more of the following faults are stored in the DME. Read More »
-
TSB #M240119
EGS FAULTS STORED AFTER AISIN TRANSMISSION REPLACEMENT. Due to hardware changes in the AISIN GA6F21AW or GA8F22AW transmissions. Read More »
-
TSB #M120217
?SERVICE ACTION: PROGRAM CONTROL UNITS (DME). Due to an error in the OBD diagnostics of the DME software, a marginal catalytic convertor or post catalyst oxygen sensor may not be detected as faulty. Read More »
-
TSB #M120117
? MIL IS ON WITH FAULT CF0486 STORED IN THE EGS MODULE . The Service Engine Soon (MIL) light is on. The following fault is stored in the AISIN EGS module: ? CF0486: EGS,PT-CAN2: Line fault/electrical fault It is possible the following ... Read More »
-
TSB #M120615
"ENGINE POWER REDUCTION WITH "CLUTCH DAMAGED"" FAULTS STORED This Service Information bulletin supersedes SI M12 06 15 dated July 2015. Read More »
-
TSB #M121315
?SUBJECT Service Action: Program Control Units (DME) . A Check Control Message could intermittently be displayed indicating a Start/Stop Function failure. Vehicle may not restart after stopping. Read More »
-
TSB #M610607
MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Read More »
-
TSB #M610223
The buttons on the gear selector switch (GWS) do not work, or the function indicator lighting has failed. Read More »
-
TSB #M840322
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via Voice over LTE (VoLTE) function. Read More »
-
TSB #M630122
Ambient lighting changes color after the vehicle goes to sleep. Read More »
-
TSB #M360119
New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. Read More »
-
TSB #M640221
Different air temperatures are felt from left to right out of the front fresh air grilles (air vents). Read More »
-
TSB #M620318
BLACK SPOT IN THE CENTRAL INFORMATION DISPLAY: A small black spot remains on the Central Information Display's (CID) illuminated screen which does not go away after a key cycle or sleep mode. Read More »
-
TSB #M660220
KAFAS (CAMERA-BASED DRIVER ASSISTANCE SYSTEMS) LIMITATIONS: KAFAS camera-based assistance system (without radar) is not operating up to customer expectations. Read More »
-
TSB #M610220
CHECK CONTROL MESSAGES FOR BRAKE SUSPENSION AND AIR BAG SYSTEM MALFUNCTION: Multiple check control messages (CCM) can display for brake suspension and air bag system malfunction. Read More »
-
TSB #M620119
CENTRAL INSTRUMENT PANEL LED SURROUND RING DOES NOT ILLUMINATE WHEN IGNITION IS TURNED ON: This Service Information Bulletin (Revision 2) replaces SI M62 01 19 dated January 2019. Read More »
-
TSB #M840818
CONNECTEDDRIVE/MINI ASSIST SYSTEM DIAGNOSIS INFORMATION: ConnectedDrive/BMW Assist features are partially or completely inoperative. Read More »
-
TSB #M110120
MALFUNCTION INDICATOR LAMP IS ILLUMINATED WITH A CRANKSHAFT ADAPTION FAULT: When diagnosing an illuminated malfunction indicator lamp (MIL) and/or a different issue the following fault may also be stored in the Digital Motor Electronics ... Read More »
-
TSB #M320114
Power-assisted Steering Intermittently Not Available at Engine Startup This Service Information Bulletin (Revision 1) replaces SI M32 01 14 dated October 2016. The power assisted steering is unavailable at start up/drive readiness. Read More »
-
TSB #M130118
DME FAULT CODE 1B8004 ENVIRONMENTAL AIR CATALYST(EAC) SENSOR: The Malfunction Indicator Lamp (MIL) light is on and the following fault code is stored in the DME: 1B8004 - EAC Sensor: Temperature - Engine coolant temperature radiator ... Read More »
-
TSB #M110117
The Service Engine Soon (MIL) light is on with the following fault stored in the Digital Motor Electronics (DME). In the situation being described the fault is only stored during the cold winter months along with the use of winter fuel. Read More »
-
TSB #M840319
BLUETOOTH CONNECTION IS LOST DURING A PHONE CALL. During an active call the call audio autonomously switching from the vehicle hands-free system to the phone. The Bluetooth connection returns after a vehicle sleep cycle (20 minutes). Read More »
-
TSB #M840918
TELEMATICS CONTROL UNIT ACTIVATION VIA DCSNET FOR MINI ASSIST. Read More »
-
TSB #M840119
SAMSUNG SMARTPHONE WITH ANDROID 8 NO USB AUDIO PLAYBACK OR CHARGING FUNCTION. The Samsung Smartphone running Android 8.x does not support USB audio playback and/or charging of the device via the USB port. Read More »
-
TSB #M840219
PHONE CALL AUDIO AUTONOMOUSLY SWITCHES FROM VEHICLE TO PHONE. During an active phone call the call audio autonomously switches from the vehicle hands-free system to the phone. Read More »
-
TSB #M650418
AIRBAG INDICATOR LIGHT REMAINS ON AFTER SEAT OCCUPANCY MAT REPLACEMENT. The airbag indicator light illuminates after replacing the CIS (Capacitive Interior Sensing) mat. Read More »
-
TSB #M510218
SPLIT REAR DOOR ONLY OPENS ON ONE SIDE. When the key button is pressed to open the rear split doors. Read More »
-
TSB #M610318
THE DISPLAY GOES BLACK, THE ENGINE CAN BE SWITCHED OFF ONLY VIA THE EMERGENCY-OFF.. * On board computer and navigation system goes black or resets. Read More »
-
TSB #M620117
ERRONEOUS SERVICE INCLUSIVE CBS DISPLAY. After pre-delivery check or after instrument cluster exchange, MINI Service Inclusive is displayed although the vehicle does not feature the optional Service Inclusive coverage. Read More »
-
TSB #M660117
? COMFORT ACCESS LOCKING REQUIRES MULTIPLE BUTTON PRESSES . Locking vehicle with CA button requires two presses, with up to 3 second delay between presses. Body Domain Controller (BDC) software Read More »
-
TSB #M270116
F54 ALL4: FAULT CODE 440317 STORED IN THE LMV. The following Check Control Message (CCM) is displayed in the instrument cluster: CCM 350: Driving stabilization. Drive at a moderate speed. Read More »
-
TSB #M111016
"THERMOSTAT FAULTS (B-ENGINES). The Service Engine Soon light is on. A Check Control message for ""Engine overheated"" and or ""Exercise caution!"" may also display. Read More »
-
TSB #M620515
The Clock in the Instrument Cluster Loses time This Service Information Bulletin supersedes SI M62 05 15 dated June 2016. Read More »
-
TSB #M840114
Bluetooth Connection Failures This Service Information bulletin supersedes SI M84 01 14 dated February 2016.. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Read More »
-
TSB #M121315
?SUBJECT Service Action: Program Control Units (DME) . A Check Control Message could intermittently be displayed indicating a Start/Stop Function failure. Vehicle may not restart after stopping. Read More »
-
TSB #M340120
SERVICE ACTION - PROGRAM THE BODY DOMAIN CONTROL (BDC) UNIT: Aftermarket scan tools cannot read fault codes in the Dynamic Stability Control (DSC) unit via the On Board Diagnostic (OBD) socket. Read More »
-
TSB #M620216
PERCEIVED SCRATCH IN INSTRUMENT CLUSTER. INFORMATION Replacing the instrument cluster for this issue will NOT be covered or reimbursed under MINI limited warranties. [ Copyright (c)2016 BMW of North America, Inc. Read More »
-
TSB #M620515
The Clock in the Instrument Cluster Loses time This Service Information Bulletin supersedes SI M62 05 15 dated June 2016. Read More »
-
TSB #M620515
The Clock in the Instrument Cluster Loses time . The time displayed in the instrument cluster (KOMBI) may lose a few minutes each week and the clock needs to be adjusted periodically. Read More »
-
TSB #M540119
SUNROOF WILL NOT OPEN: The sunroof does not move and the vehicle has no faults stored related to the sunroof. A software error in the FZD (Roof function center). Read More »
-
TSB #M650217
?Technical Service ERRONEOUS CID MENU ENTRY- 'IMPORT JOURNEY'. ?Import Journey (USB)? submenu item in the Stored Journeys menu of the Navigation system is not working. Read More »
-
TSB #M650416
The voice input system (SVS) has not been activated. The audio head unit has a coding error. Read More »
-
TSB #M660116
"""Comfort Access Restricted"" Check Control Message is Displayed. ""Comfort Access Restricted"" CCM (Check Control Message) is permanently displayed.. The CCM ID: D0h. The comfort access is functioning correctly. Read More »
-
TSB #M840114
This Service Information bulletin supersedes SI M84 01 14 dated November 2014. SUBJECT Bluetooth Connection Failures. There are various connectivity failures with the following devices: z Apple iPhones z Samsung S6 and the S6 Edge. Read More »
-
TSB #M610223
The buttons on the gear selector switch (GWS) do not work, or the function indicator lighting has failed. Read More »
-
TSB #M630122
Ambient lighting changes color after the vehicle goes to sleep. Read More »
-
TSB #M630117
SERVICE COVER FOR THE REAR LIGHT IS LOOSE. Mounting position of service cover is too low and clearance dimensions between the cover and door are too tight. Read More »
-
TSB #M511416
"? INTERIOR REARVIEW MIRROR MOVES OUT OF POSITION . The ""manually-dimming"" interior rearview mirror does not hold its set position when traveling over rough roads and/or with ""low ambient"" interior temperatures. Read More »
-
TSB #M60116
?Front Windshield Wiper Noises. Customer complains wipers are noisy or chattering during wiper operation. Read More »
-
TSB #M610116
Front Windshield Wiper Noises. Customer complains wipers are noisy or chattering during wiper operation. CAUSE Wiper arms out of adjustment and/or windshield cowl misaligned. Read More »
-
TSB #M610116
SI M61 01 16 General Electrical Systems August 2016 Technical Service Front Windshield Wiper Noises This Service Information bulletin supersedes SI M61 01 16 dated April 2016.. Read More »
-
TSB #M540119
SUNROOF WILL NOT OPEN: The sunroof does not move and the vehicle has no faults stored related to the sunroof. A software error in the FZD (Roof function center). Read More »
-
TSB #M540219
RATTLE NOISE FROM SUNROOF WHILE DRIVING: A rattle noise is present from the sunroof while driving only with the sunroof glass in the closed position. Read More »
-
TSB #M510616
SQUEAKING NOISE FROM POWER FOLDING EXTERIOR REARVIEW MIRRORS. A squeaking noise can be heard when folding the exterior rear view mirrors in or out. Tolerances in the exterior rear view mirrors Read More »
-
TSB #M610116
SI M61 01 16 General Electrical Systems August 2016 Technical Service Front Windshield Wiper Noises This Service Information bulletin supersedes SI M61 01 16 dated April 2016.. Read More »
-
TSB #M650117
AIR BAG WARNING LAMP CC MESSAGE 'RESTRAINT SYSTEM' This Service Information bulletin replaces SI M65 01 17 dated February 2017. Read More »
-
TSB #M650418
AIRBAG INDICATOR LIGHT REMAINS ON AFTER SEAT OCCUPANCY MAT REPLACEMENT. The airbag indicator light illuminates after replacing the CIS (Capacitive Interior Sensing) mat. Read More »
-
TSB #M650418
AIRBAG INDICATOR LIGHT REMAINS ON AFTER SEAT OCCUPANCY MAT REPLACEMENT. Read More »
-
TSB #M720120
SAFETY BELT WARNING GONG SOUNDS AFTER UNBUCKLING WHILE VEHICLE IS STATIONARY. After a vehicle has been programmed to an I-level greater than 19-11-5xx and lower than I-level 20-03-530; the safety belt (aka seat belt) acoustic warning ... Read More »
-
TSB #M640116
Customer complains of a musty odor or damp front footwell carpet. Read More »
-
TSB #M511616
Cavity protection applied to underside of the hood is leaking out onto the wheel arch trim and grille. Read More »
-
TSB #M340120
SERVICE ACTION - PROGRAM THE BODY DOMAIN CONTROL (BDC) UNIT: Aftermarket scan tools cannot read fault codes in the Dynamic Stability Control (DSC) unit via the On Board Diagnostic (OBD) socket. Read More »
-
TSB #M511216
SERVICE ACTION: RUBBER STRIP ON REAR SIDE WINDOW TRIM IS CRACKED. The rubber strip on the rear side window trim may crack. In some cases a gap may be evident on the rubber trim strip. Read More »
-
TSB #M640220
CONDENSATION FROM AIR CONDITIONING LEAKS INTO PASSENGER FOOTWELL: Condensation from the air conditioning systems evaporator drips, below the instrument panel, into the passenger's footwell. Read More »
-
TSB #SIM610321
The Check Control message "Door open" appears in the instrument cluster (Kombi) even though all vehicle doors are securely closed and locked. Read More »
-
TSB #M410221
SERVICE ACTION 0041080200: MINI F54 RIGHT FRONT DOOR: Due to a fault in the press shop, there may be a crack in the inner door panel of the front right door in the area of the window frame. Read More »
-
TSB #M510120
FRONT DOORS DO NOT LATCH IN COLD WEATHER: At ambient temperatures below freezing one or both front doors may not open when attempting to enter. In some cases after opening they may not correctly latch. Read More »
-
TSB #M510319
RATTLE FROM FRONT DOOR: A rattle noise is present from the door while driving most commonly when driving over rough roads. Read More »
-
TSB #M510218
SPLIT REAR DOOR ONLY OPENS ON ONE SIDE. When the key button is pressed to open the rear split doors. Read More »
-
TSB #M410116
EDGE CORROSION IN THE DOOR JAMB AREA. Corrosion on inner door panels at the following holes and cavity openings: Door brake (1). Door wiring harness pass-thru (2). Read More »
-
TSB #M510319
RATTLE FROM FRONT DOOR: A rattle noise is present from the door while driving most commonly when driving over rough roads. Read More »
-
TSB #M510916
?TAILGATE UNINTENTIONALLY OPENS. Customer inquires about tailgate opening process, mentioning: * Trunk/tailgate may open when vehicle is locked. * Trunk/tailgate may open while the vehicle is in motion. Read More »
-
TSB #M510317
LEFT SPLIT DOOR WON'T UNLATCH. Left split door (tailgate) is not able to be opened. When activating remote control unlock, second button push does not unlatch left split door. Read More »
-
TSB #M510120
FRONT DOORS DO NOT LATCH IN COLD WEATHER: At ambient temperatures below freezing one or both front doors may not open when attempting to enter. In some cases after opening they may not correctly latch. Read More »
-
TSB #M510218
SPLIT REAR DOOR ONLY OPENS ON ONE SIDE. When the key button is pressed to open the rear split doors. Read More »
-
TSB #M660217
(SMART OPENER) CONTACTLESS TAILGATE NOT ABLE TO BE DEACTIVATED. Customer desires to have contactless tailgate opening and closing (Smart Opener) deactivated. Function not included in software released. Read More »
-
TSB #M360115
CHECK CONTROL MESSAGE: TIRE PRESSURE MONITOR (RDCI) FAILURE. A Check Control Message states Tire Pressure Monitor (RDCi) has failed CAUSE Hardware failure in the remote control unit (FBD3 antenna). Read More »
-
TSB #M230121
When the vehicle is on a lift and wheels are manually spun, a clanking noise is heard from the transmission area. Read More »
-
TSB #M360119
New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. Read More »
-
TSB #M520119
NOISE DURING FORWARD / BACK SEAT ADJUSTMENT OVER THE ENTIRE LENGTH OF TRAVEL: A loud screeching noise can be heard from the front driver's or passenger's seat during forward/back seat adjustment. Read More »
-
TSB #M520218
?SEAT HEATING DOES NOT GET SUFFICIENTLY WARM. The seat heating in the sports seat may not heat up sufficiently Software error in the climate control panel (IHKA) Read More »
-
TSB #M520119
NOISE DURING FORWARD/BACK SEAT ADJUSTMENT OVER THE ENTIRE LENGTH OF TRAVEL: A loud screeching noise can be heard from the front driver's or passenger's seat during forward/back seat adjustment. Read More »
-
TSB #M520218
?SEAT HEATING DOES NOT GET SUFFICIENTLY WARM. The seat heating in the sports seat may not heat up sufficiently Software error in the climate control panel (IHKA) Read More »
-
TSB #M340120
SERVICE ACTION - PROGRAM THE BODY DOMAIN CONTROL (BDC) UNIT: Aftermarket scan tools cannot read fault codes in the Dynamic Stability Control (DSC) unit via the On Board Diagnostic (OBD) socket. Read More »
-
TSB #M660216
Collision warning and Pedestrian Warning Failed. While driving, a Check Control Message (CCM) is displayed advising of the following: Front collision warning failed Pedestrian detection failed The following fault code is stored in the ... Read More »
-
TSB #M360119
New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. Read More »
-
TSB #M310115
A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle Read More »
-
TSB #M520119
NOISE DURING FORWARD / BACK SEAT ADJUSTMENT OVER THE ENTIRE LENGTH OF TRAVEL: A loud screeching noise can be heard from the front driver's or passenger's seat during forward/back seat adjustment. Read More »
-
TSB #M640120
BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Read More »
-
TSB #M620318
BLACK SPOT IN THE CENTRAL INFORMATION DISPLAY: A small black spot remains on the Central Information Display's (CID) illuminated screen which does not go away after a key cycle or sleep mode. Read More »
-
TSB #M660220
KAFAS (CAMERA-BASED DRIVER ASSISTANCE SYSTEMS) LIMITATIONS: KAFAS camera-based assistance system (without radar) is not operating up to customer expectations. Read More »
-
TSB #M220317
CREAKING NOISE FROM THE LOWER ENGINE AREA: This Service Information Bulletin (Revision 1) replaces SI M22 03 17 dated January 2018. Read More »
-
TSB #M110120
MALFUNCTION INDICATOR LAMP IS ILLUMINATED WITH A CRANKSHAFT ADAPTION FAULT: When diagnosing an illuminated malfunction indicator lamp (MIL) and/or a different issue the following fault may also be stored in the Digital Motor Electronics ... Read More »
-
TSB #M650219
SECURITY IMPROVEMENTS FOR HEAD UNITS. Security patches for non-safety critical vulnerabilities in MINI head units Entry Nav Entry Media NBT and NBT EVO. Read More »
-
TSB #M130119
LIN BUS COMMUNICATION FAULT FOR ENVIRONMENTAL AIR CATALYST (EAC) SENSOR FC1B8302. The malfunction indicator lamp light is on (MIL) with the following fault code stored in the DME. Read More »
-
TSB #M650219
SECURITY IMPROVEMENTS FOR HEAD UNITS. Security patches for non-safety critical vulnerabilities in MINI head units Entry Nav Entry Media NBT and NBT EVO. Read More »
-
TSB #M120219
DIAGNOSTIC HINT: CATALYTIC CONVERTER INSPECTION AFTER LOSS OF CRANKSHAFT SIGNAL: In certain situations when the crankshaft position signal is lost while driving the malfunction indicator lamp (MIL) and an engine malfunction check control ... Read More »
-
TSB #M540318
RATTLE NOISE FROM SUNSHADE WHILE DRIVING. With either of the sunshades fully opened, there is a rattle noise present when driving over rough road surfaces The sunshade is contacting the roof liner trim. Read More »
-
TSB #M840818
?CONNECTEDDRIVE/MINI ASSIST SYSTEM DIAGNOSIS INFORMATION. ConnectedDrive/MINI Assist features are partially or completely inoperative. Read More »
-
TSB #M640217
AIR CONDITIONING COOLING IS INSUFFICIENT. * With option code SA 530 air conditioning or SA 534 Automatic air conditioning Produced from 2/1/2016 through 9/30/2016. * A/C system contains little or no A/C refrigerant. Read More »
-
TSB #M650717
"NAVIGATION PRO (NBT EVO) MAP UPDATE NOT POSSIBLE, NAVIGATION DOES NOT START. A. Navigation system will not start at all or the ""Navigation system starts"" message is permanently displayed. B. Read More »
-
TSB #SIM010317
Mini - Dangerous goods (DG) part return program - The warranty department together with labelmaster has established a process for shipping claim-related "return requested" parts which asre classified as "Dangerous Goods" ... Read More »
-
TSB #M510217
ONSOLE STORAGE COMPARTMENT LID DOES NOT OPEN EASILY. Center console storage compartment lid requires too much force to open as demonstrated in accompanying video. tinyurl.com/mkphrma A. Sticky release mechanism. And/or B. Read More »
-
TSB #M650516
SPORADIC FAILURE OF DIFFERENT AUDIO CHANNELS. Intermittently, different speakers may be inoperative during an entire drive cycle until the vehicle enters sleep mode and the vehicle is restarted. Read More »
-
TSB #M650417
LIST OF AVAILABLE FM RADIO STATIONS TEMPORARILY NOT AVAILABLE. As of 11/2015, all Entry-NAV/Media head units supplied in new vehicles were upgraded for improved noise characteristics and quality. Read More »
-
TSB #M650317
. INFORMATION Inform the customer that the introduction of these expanded frequencies by the wireless mobile providers may be influencing reception quality. Read More »
-
TSB #M320116
"EPS INTERMITTENT ASSIST FAILURE, FC 4823FA. The steering assistance fails after several, consecutive parking maneuvers or sustained hold at the end stop. EPS assistance starts functioning again after a few minutes. Read More »
-
TSB #M640214
Foul Odor when Switching On A/C. The customer reports a foul smell (musty, rotten, and vinegary) when the A/C is first turned on that lasts about five minutes. Micro-filter position too low in the IHKA housing. Read More »
-
TSB #M110916
VANOS AND VANOS CENTRAL BOLT IDENTIFICATION. INFORMATION Replacing the VANOS gear central bolts or the VANOS gear will require a component inspection when the engine assembly has been previously replaced in one of the vehicles listed above. Read More »
-
TSB #M640216
Air Conditioning Refrigerant R1234yf Introduction. INFORMATION Several precautions need to be observed when working on automotive air conditioning systems: Always wear eye protection and gloves while handling refrigerant or servicing air ... Read More »
-
TSB #M840114
Bluetooth Connection Failures This Service Information bulletin supersedes SI M84 01 14 dated February 2016.. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Read More »
-
TSB #M650119
Safety Systems HEAD UNIT NBT EVO (HU-H2) PROGRAMMING ABORT. During programming several aborts can occur in the head unit NBT EVO (HU-H2). Read More »
-
TSB #M620318
BLACK SPOT IN THE CENTRAL INFORMATION DISPLAY. A small black spot remains on the Central Information Displays (CID) illuminated screen which does not go away after a key cycle or sleep mode. Read More »
-
TSB #M610318
THE DISPLAY GOES BLACK, THE ENGINE CAN BE SWITCHED OFF ONLY VIA THE EMERGENCY-OFF.. * On board computer and navigation system goes black or resets. Read More »
-
TSB #M840818
?CONNECTEDDRIVE/MINI ASSIST SYSTEM DIAGNOSIS INFORMATION. ConnectedDrive/MINI Assist features are partially or completely inoperative. Read More »
-
TSB #M650516
SPORADIC FAILURE OF DIFFERENT AUDIO CHANNELS. Intermittently, different speakers may be inoperative during an entire drive cycle until the vehicle enters sleep mode and the vehicle is restarted. Read More »
-
TSB #M840114
Bluetooth Connection Failures This Service Information bulletin supersedes SI M84 01 14 dated February 2016.. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Read More »
-
TSB #M610115
This Service Information bulletin supersedes SI M61 01 15 dated February 2015. SUBJECT Noise from Steering Column Switch Center when Turning. The customer states that there is a grating or scraping noise when the steering wheel is turned. Read More »
-
TSB #M650216
False Alarms of the Anti-Theft Alarm System. The alarm (DWA) siren continues to activate after locking vehicle A device is connected to the On-Board Diagnostics (OBD) port of the vehicle. Read More »
-
TSB #M650116
XM Satellite Radio Reception. INFORMATION Currently Satellite Radio is provided by SiriusXM for MINI customers. SiriusXM is the only company currently broadcasting Satellite Radio in North America. Read More »
-
TSB #M650516
SPORADIC FAILURE OF DIFFERENT AUDIO CHANNELS. Intermittently, different speakers may be inoperative during an entire drive cycle until the vehicle enters sleep mode and the vehicle is restarted. Read More »
-
TSB #M650316
NBT and Entry Head Unit Software Update for Improved Satellite Radio Reception. Poor Satellite Radio reception CAUSE After this software update there is a slight improvement in Satellite Radio reception for these vehicles when receiving ... Read More »
-
TSB #M650516
Sporadic Failure of Different Audio Channels. Intermittently, different speakers may be inoperative during an entire drive cycle until the vehicle enters sleep mode and the vehicle is restarted. Read More »
-
TSB #M651315
Hissing noise from speakers when radio volume is turned down. There is an audible hissing noise from the speakers when there is no active audio source. This noise is most apparent with the engine and climate system fan turned off. Read More »
-
TSB #M650116
SI M65 01 16 February 2016 Audio, Navigation, Monitors, Alarms, SRS Technical Service SUBJECT XM Satellite Radio Reception. Currently Satellite Radio is provided by SiriusXM for MINI customers. Read More »
-
TSB #M840114
This Service Information bulletin supersedes SI M84 01 14 dated November 2014. SUBJECT Bluetooth Connection Failures. There are various connectivity failures with the following devices: z Apple iPhones z Samsung S6 and the S6 Edge. Read More »
-
TSB #M651015
The Headunit High (HU-H), also called NBT came in vehicles with option 609. This uses map North America NEXT. The Headunit High 2 (HU-H2), also called NBT-EVO, superseded the NBT HU and came in vehicles with option code 609. Read More »
-
TSB #M650217
?Technical Service ERRONEOUS CID MENU ENTRY- 'IMPORT JOURNEY'. ?Import Journey (USB)? submenu item in the Stored Journeys menu of the Navigation system is not working. Read More »
-
TSB #M310115
A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle Read More »
-
TSB #M640120
BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Read More »
-
TSB #M620318
BLACK SPOT IN THE CENTRAL INFORMATION DISPLAY: A small black spot remains on the Central Information Display's (CID) illuminated screen which does not go away after a key cycle or sleep mode. Read More »
-
TSB #M660220
KAFAS (CAMERA-BASED DRIVER ASSISTANCE SYSTEMS) LIMITATIONS: KAFAS camera-based assistance system (without radar) is not operating up to customer expectations. Read More »
-
TSB #M220317
CREAKING NOISE FROM THE LOWER ENGINE AREA: This Service Information Bulletin (Revision 1) replaces SI M22 03 17 dated January 2018. Read More »
-
TSB #M510120
FRONT DOORS DO NOT LATCH IN COLD WEATHER: At ambient temperatures below freezing one or both front doors may not open when attempting to enter. In some cases after opening they may not correctly latch. Read More »
-
TSB #M620119
CENTRAL INSTRUMENT PANEL LED SURROUND RING DOES NOT ILLUMINATE WHEN IGNITION IS TURNED ON: This Service Information Bulletin (Revision 2) replaces SI M62 01 19 dated January 2019. Read More »
-
TSB #M540219
RATTLE NOISE FROM SUNROOF WHILE DRIVING: A rattle noise is present from the sunroof while driving only with the sunroof glass in the closed position. Read More »
-
TSB #M120219
DIAGNOSTIC HINT: CATALYTIC CONVERTER INSPECTION AFTER LOSS OF CRANKSHAFT SIGNAL: In certain situations when the crankshaft position signal is lost while driving the malfunction indicator lamp (MIL) and an engine malfunction check control ... Read More »
-
TSB #M840319
BLUETOOTH CONNECTION IS LOST DURING A PHONE CALL. During an active call the call audio autonomously switching from the vehicle hands-free system to the phone. The Bluetooth connection returns after a vehicle sleep cycle (20 minutes). Read More »
-
TSB #M650418
AIRBAG INDICATOR LIGHT REMAINS ON AFTER SEAT OCCUPANCY MAT REPLACEMENT. The airbag indicator light illuminates after replacing the CIS (Capacitive Interior Sensing) mat. Read More »
-
TSB #M650516
SPORADIC FAILURE OF DIFFERENT AUDIO CHANNELS. Intermittently, different speakers may be inoperative during an entire drive cycle until the vehicle enters sleep mode and the vehicle is restarted. Read More »
-
TSB #M270116
F54 ALL4: FAULT CODE 440317 STORED IN THE LMV. The following Check Control Message (CCM) is displayed in the instrument cluster: CCM 350: Driving stabilization. Drive at a moderate speed. Read More »
-
TSB #M310315
CRACKING NOISE IN THE AREA OF THE FRONT AXLE SUPPORT/WISHBONE This Service Information bulletin supersedes SI 31 03 15 dated February 2016. Read More »
-
TSB #M511016
"SERVICE ACTION: CHECKING AND REWORKING PVC SEAM ON STRUT TOWER. A PVC seam of the front strut spring tower may not be providing the necessary corrosion protection. Improper application of seam sealer. Read More »
-
TSB #M310315
SI M11 03 15 February 2016 Engine Technical Service This Service Information bulletin supersedes SI M11 03 15 dated April 2015. SUBJECT B38 Engine: Mixture Faults Stored in DME and Cylinder Head Cover Leaking Engine Oil. Read More »
-
TSB #M360115
SI M11 03 15 February 2016 Engine Technical Service This Service Information bulletin supersedes SI M11 03 15 dated April 2015. SUBJECT B38 Engine: Mixture Faults Stored in DME and Cylinder Head Cover Leaking Engine Oil. Read More »
-
TSB #M510216
SI M11 03 15 February 2016 Engine Technical Service This Service Information bulletin supersedes SI M11 03 15 dated April 2015. SUBJECT B38 Engine: Mixture Faults Stored in DME and Cylinder Head Cover Leaking Engine Oil. Read More »
-
TSB #M650116
SI M65 01 16 February 2016 Audio, Navigation, Monitors, Alarms, SRS Technical Service SUBJECT XM Satellite Radio Reception. Currently Satellite Radio is provided by SiriusXM for MINI customers. Read More »
-
TSB #M640221
Different air temperatures are felt from left to right out of the front fresh air grilles (air vent). Read More »
-
TSB #M640120
BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Read More »
-
TSB #M640220
CONDENSATION FROM AIR CONDITIONING LEAKS INTO PASSENGER FOOTWELL: Condensation from the air conditioning systems evaporator drips, below the instrument panel, into the passenger's footwell. Read More »
-
TSB #M640120
BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Read More »
-
TSB #M640220
CONDENSATION FROM AIR CONDITIONING LEAKS INTO PASSENGER FOOTWELL: Condensation from the air conditioning systems evaporator drips, below the instrument panel, into the passenger's footwell. Read More »
-
TSB #M640117
FOUL, MUSTY ODOR FROM HVAC: WET FOOTWELL CARPET This Service Information bulletin supersedes SI M64 01 16 dated September 2016 and SI M64 02 14 dated August 2016 are being combined to prevent duplication of effort and streamline the ... Read More »
-
TSB #M640216
Air Conditioning Refrigerant R1234yf Introduction. INFORMATION Several precautions need to be observed when working on automotive air conditioning systems: Always wear eye protection and gloves while handling refrigerant or servicing air ... Read More »
-
TSB #M640116
Water Ingress In Footwell Area From A/C Condensate Drain. Customer complains of musty odor and/or damp front footwell carpet. Read More »
-
TSB #M640216
"Air Conditioning Refrigerant R1234yf Introduction. INFORMATION Highlights of R-1234yf Meets SAE J2888_201301 ""This SAE Standard covers fittings, couplers, and hoses intended for connecting service hoses from mobile air- conditioning ... Read More »