2016 Ram ProMaster 3500
TSBs (Technical Service Bulletins)
Please note: The TSB information displayed below are summaries. We do not have access to the full versions. To get full information about a particular TSB, write down the TSB title & date, & either contact your local dealer or click on the links below.
The TSB numbers are the NHTSA numbers, which are different from the manufacturer-assigned TSB numbers — the NHTSA doesn't keep track of those. It's a very screwed up situation that's almost completely unhelpful to you as the consumer. Use the issue date or the title when asking your dealer for more information about a TSB.
ENGINE AND ENGINE COOLING
NHTSA ID #10138863
Summary: Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block Interfac
NHTSA ID #10139989
Summary: Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob.jackson@fcagroup
NHTSA ID #10121657
Summary: Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable provided they are not cut, torn or melted. The gaskets are not required by warranty to be replaced like they are on Pentastar Classic (
NHTSA ID #10121927
Summary: NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
NHTSA ID #10139936
Summary: 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the
NHTSA ID #10138855
Summary: Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottl
NHTSA ID #10139978
Summary: Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
NHTSA ID #10139985
Summary: Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
NHTSA ID #10139992
Summary: Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
NHTSA ID #10138856
Summary: Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected d
VEHICLE SPEED CONTROL:CRUISE CONTROL
NHTSA ID #10139956
Summary: Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar Sensor in Front of Vehicle or DTC C1266 ACC Sensor Blinded, please verify that there is no blockage in front of the sensor. Blockage
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
NHTSA ID #10121669
Summary: MY16 RA3 & RA4 Replacement Radios All MY16 RA3 and RA4 replacement radios must be ordered through the exchange process at United Radio. DO NOT order a NEW radio from Mopar. Go back and order a "Z" level part number. (example: Z8249986A$)
NHTSA ID #10129008
Summary: 82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc