3.9

definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
31,026 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2004 Toyota 4Runner:

Unsubscribe any time. We don't sell/share your email.

problem #3

Apr 222013

4Runner 8-cyl

  • 93,077 miles
Drivers door latch mechanism would not permit driver to exit the vehicle. Door would not unlock, though all electric and manual actions to unlock the door appear to work, latch handle would not move. This condition was normal for the vehicle when new if the door was locked. All other doors in the vehicle would open from the inside if locked. Drivers door latch failed prohibiting driver from exiting the car and was replaced. Replacement latch would permit emergency exit from the vehicle if the lock was activated.

- Richardson, TX, USA

problem #2

Feb 032010

4Runner

  • miles
Front driver side door will not unlock with remote, key, inside latch, etc. Door will make sounds when electrical locks are pushed, so it is not likely the actuator (which has also been a problem in this make and model). Internet research has shown that there is a component within the latch, a spring of some variety, that breaks and/or falls down into the door compartment. Contacted dealer who was very busy and had never heard of such a problem, but we could bring it in and for 85 dollars/hr, they would look at it and see. Well, we are not even able to get the door open. If a crash were to happen, someone could get stuck inside, as currently one has to crawl from driver side to passenger side to exit vehicle. I feel this is a manufacturing defect, especially with the numerous similar complaints online, that should be recalled and fixed at the manufacturer's expense.

- Cullman, AL, USA

problem #1

Dec 012007

4Runner 8-cyl

  • Automatic transmission
  • miles
Seat belt housing is broken, can't use belt. Door locks do not work, person may get locked in vehicle if involved in accident.

- Diamond Bar, CA, USA