2019 Toyota Highlander
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2019 Highlander are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #T-TT-0578-19 Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #T-TT-0578-19
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #T-SB-0211-17_Rev
TSB: REVISION NOTICE February 5, 2019 Rev2: ? Applicability has been updated to include 2019 model year Highlander and Highlander HV vehicles. ? The Introduction, Warranty Information, and Repair Procedure sections have been updated. Read More »
-
TSB #T-SB-0211-17_Rev
TSB: REVISION NOTICE February 5, 2019 Rev2: ? Applicability has been updated to include 2019 model year Highlander and Highlander HV vehicles. ? The Introduction, Warranty Information, and Repair Procedure sections have been updated. Read More »
-
TSB #T-TT-0636-20 Rev
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #T-TT-0636-20
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #T-SB-0072-18 Rev
TSB: Some 2014 ? 2019 model year Highlander vehicles may exhibit a vibration from the front brakes during light application of the brake pedal at highway speeds. Follow the Repair Procedure in this bulletin to address this condition. Read More »
-
TSB #TSB000923
TSB: Some 2014 ? 2020 model year Toyota vehicles may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ?DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ?DTC P0087 ... Read More »
-
TSB #23TE04
DL: On December 20, 2022, a settlement of claims for certain low pressure fuel pumps was approved by the federal court. Read More »
-
TSB #TTT063620
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Read More »
-
TSB #T-TT-0636-20
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #TSB004522Rev1
TSB: Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #T-SB-0003-20
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0279-17. ? The entire bulletin has been updated. Service Bulletin No. Read More »
-
TSB #T-TT-0685-22
TT: Some 2017-2022 Highlander, and 2017-2020 Sienna vehicles may experience an engine oil leak condition from the No.2 Oil pan. This issue is currently under investigation. Read More »
-
TSB #T-TT-0615-20 Rev
TT: The Toyota Quality group is looking to better understand our customers expectation regarding vehicle drivability. Read More »
-
TSB #T-TT-0615-20 Rev
TT: The Toyota Quality group is looking to better understand our customers expectation regarding vehicle drivability. Read More »
-
TSB #T-TT-0615-20 Rev
TT: The Toyota Quality group is looking to better understand our customers expectation regarding vehicle drivability. Read More »
-
TSB #T-TT-0615-20
TT: The Toyota Quality group is looking to better understand our customers expectation regarding vehicle drivability. Read More »
-
TSB #19TC04 - Region
Region Email: The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #19TC04 - Dealer
Dealer Email: The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #19TC04 -Region L
Region Letter: The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #19TC04 - Dealer
Dealer Package: The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #19TC04 - TI_01.3
Technical Instructions: TECHNICAL INSTRUCTIONS FOR SPECIAL SERVICE CAMPAIGN 19TC04 OIL COOLER PIPE CERTAIN 2017 ? 2019 HIGHLANDER HV Read More »
-
TSB #19TC04 - FAQ - P
Frequently Asked Questions. The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #19TC04 - DD - Pu
Dealer Daily Message: **Dealer Letter and Technical Instructions Available on TIS** Certain 2017 ? 2019 Model Year Highlander HV ? Special Service Campaign 19TC04 Dealer Letter and Technical Instructions now available on TIS. Read More »
-
TSB #Parts HotWire 20
Dealer Message: Parts Hotwire. In an effort to assist dealers in performing campaign 19TC04 on a customer?s first visit, Toyota is deploying stock of part number 04009-40131 (PIPE KIT, OIL COOLER) to all dealers. Read More »
-
TSB #Oil Cooler Pipe
Technical Instructions: TECHNICAL INSTRUCTIONS FOR SPECIAL SERVICE CAMPAIGN 19TC04 OIL COOLER PIPE CERTAIN 2017 ? 2019 HIGHLANDER HV Read More »
-
TSB #T-TT-0523-19_Rev
TT: Some 2017, 2018 and 2019 model year Highlanders are equipped with an engine Stop & Start system. It is important to use part number 28800-31550 when Stop & Start equipped Highlanders need battery replacement. Read More »
-
TSB #T-SB-0134-16-Rev
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
-
TSB #T-SB-0115-22
TSB: Some 2019 ? 2022 model year Avalon, 2018 ? 2023 model year Camry, 2017 ? 2022 model year Highlander, 2017 ? 2020 model year Sienna, and 2016 ? 2023 model year Tacoma vehicles equipped with a 2GR-FKS engine may exhibit a knocking ... Read More »
-
TSB #T-TT-0699-22 Rev
TT: Some Model Year 2018-2021 vehicles equipped with A25A-FKS/FXS or M20A-FKS/FXS engines may display the following message ?Engine Maintenance Required Visit Your Dealer? on the combination meter. Read More »
-
TSB #T-SB-0015-21 Rev
TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2022 model year Toyota vehicles equipped with an FKS engine Read More »
-
TSB #TTT068522
TT: Some 17-22MY Highlander, and 17-20MY Sienna vehicles with engine serial numbers that start with F or G may experience an engine oil leak condition from the No.2 Oil pan. This issue is currently under investigation. Read More »
-
TSB #T-TT-0686-22
TT: The purpose of this Tech Tip is to provide diagnostic tips to prevent misdiagnosis of the following DTC?s and prevent repeat repairs. Read More »
-
TSB #19TC04 - Region
Region Email: The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #19TC04 - Dealer
Dealer Email: The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #19TC04 -Region L
Region Letter: The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #19TC04 - Dealer
Dealer Package: The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #19TC04 - TI_01.3
Technical Instructions: TECHNICAL INSTRUCTIONS FOR SPECIAL SERVICE CAMPAIGN 19TC04 OIL COOLER PIPE CERTAIN 2017 ? 2019 HIGHLANDER HV Read More »
-
TSB #19TC04 - FAQ - P
Frequently Asked Questions. The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. Read More »
-
TSB #Parts HotWire 20
Dealer Message: Parts Hotwire. In an effort to assist dealers in performing campaign 19TC04 on a customer?s first visit, Toyota is deploying stock of part number 04009-40131 (PIPE KIT, OIL COOLER) to all dealers. Read More »
-
TSB #Oil Cooler Pipe
Technical Instructions: TECHNICAL INSTRUCTIONS FOR SPECIAL SERVICE CAMPAIGN 19TC04 OIL COOLER PIPE CERTAIN 2017 ? 2019 HIGHLANDER HV Read More »
-
TSB #T-SB-0148-19
TSB: Some 2017 ? 2019 model year Highlander HV vehicles may exhibit a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ? P0301 ? Cylinder 1 Misfire Detected ? P0302 ? Cylinder 2 Misfire Detected ? P0303 ... Read More »
-
TSB #T-TT-0521-19
TT: The current engine active test ?Control the Injection Mode? is not operating as desired when controlling the direct injectors manually on 2GR-FKS engines. Read More »
-
TSB #TTT069922
TT: Some Model Year 2018-2021 vehicles equipped with A25A-FKS/FXS or M20A-FKS/FXS engines may display the following message ?Engine Maintenance Required Visit Your Dealer? on the combination meter. Read More »
-
TSB #T-TT-0468-17 Rev
TT: HVAC drain tube is found to be blocked/clogged. Read More »
-
TSB #T-SB-0074-20
TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid ... Read More »
-
TSB #T-TT-0628-20
TT: HVAC drain tube is found to be blocked/clogged. Read More »
-
TSB #T-SB-0103-20
TSB: This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for some 2008 ? 2021 model year Toyota vehicles. Read More »
-
TSB #TTT069822
TT: Some 17-22MY Highlander and 17-20MY Sienna vehicles may experience a MIL ON condition with DTC(s) P042000, and/or P043000. This issue could involve deteriorated catalyst material from the bank 1 or bank 2 catalytic converter. Read More »
-
TSB #T-SB-0115-22 Rev
TSB: Some 2019 ? 2022 model year Avalon, 2018 ? 2023 model year Camry, 2017 ? 2022 model year Highlander, and 2017 ? 2020 model year Sienna vehicles equipped with a 2GR-FKS engine may exhibit a knocking noise from the vacuum pump at idle. Read More »
-
TSB #T-SB-0115-22
TSB: Some 2019 ? 2022 model year Avalon, 2018 ? 2023 model year Camry, 2017 ? 2022 model year Highlander, 2017 ? 2020 model year Sienna, and 2016 ? 2023 model year Tacoma vehicles equipped with a 2GR-FKS engine may exhibit a knocking ... Read More »
-
TSB #T-SB-0018-19
TSB: Some 2017 ? 2019 model year Highlander vehicles may exhibit a knocking noise from the fuel tank area at idle, vehicle stationary, with a full tank of gasoline. Follow the Repair Procedure in this bulletin to address this condition. Read More »
-
TSB #23TE01 Dealer Pa
DP: Although the high-pressure fuel pump is covered by Toyota?s New Vehicle Limited Warranty for 5 years or 60,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Read More »
-
TSB #T-TT-0659-21 Rev
TT: Some 2014-2021 model year vehicles equipped with Dynamic Torque Control AWD system may experience a ?Noise? or ?Abnormal Operation? condition from the rear differential front coupling. Read More »
-
TSB #T-TT-0580-19_Rev
TT: Currently under investigation. Please contact TAS if you have a vehicle that exhibits a leak from the Transmission Side Cover with no signs of damage or other conditions unrelated to regardless of miles or months in service. Read More »
-
TSB #T-TT-0580-19
TT: Some 2018-2020 model year UA80/UB80 transmission equipped models may experience a leak from the Transmission Side Cover. This issue is currently under investigation. Vehicles are being sought regardless of months in service or mileage. Read More »
-
TSB #T-SB-0134-16-Rev
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
-
TSB #T-SB-0057-18
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #TTT069822
TT: Some 17-22MY Highlander and 17-20MY Sienna vehicles may experience a MIL ON condition with DTC(s) P042000, and/or P043000. This issue could involve deteriorated catalyst material from the bank 1 or bank 2 catalytic converter. Read More »
-
TSB #TSB004522Rev1
TSB: Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #TSB004522Rev1
TSB: Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #T-SB-0045-22
Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #T-SB-0003-20 Rev
TSB: Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #T-SB-0003-20 Rev
TSB: Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #T-TT-0578-19 Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #T-SB-0074-20
TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid ... Read More »
-
TSB #T-SB-0062-20
TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Read More »
-
TSB #T-TT-0516-18_Rev
TT: The microphone circuit passes through the DCM before reaching the radio/navigation system. To simplify the diagnosis of the microphone, Safety Connect SOS button lights, and DCM (Data Communication Module/telematics transceiver) ... Read More »
-
TSB #T-SB-0119-15_Rev
TT: This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. Read More »
-
TSB #T-SB-0003-20
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0279-17. ? The entire bulletin has been updated. Service Bulletin No. Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
-
TSB #T-TT-0574-19
TT: Some customers may experience poor outgoing Bluetooth sound quality, this can occur for various reasons. Read More »
-
TSB #T-TT-0553-19
TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. Read More »
-
TSB #T-SB-0134-16-Rev
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
-
TSB #T-TT-0549-19
TT: The new 12V Battery Warranty Testers (DSS-5000 & DCA-8000) require certain information to generate a test result and warranty code. Read More »
-
TSB #T-TT-0545-19
TT: Some vehicles may have a U0110 DTC. Read More »
-
TSB #T-SB-0042-19
TSB: Some 2019 model year Highlander and Highlander Hybrid vehicles equipped with JBL audio may exhibit inoperative navigation voice prompts and/or button beeps with the setting ON. Read More »
-
TSB #T-TT-0414-16-Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #T-TT-0484-18-Rev
TT: Some customers may experience echoing on the line calling the vehicle when using Bluetooth Hands Free. This is caused by the phone Hands Free volume being too low. Read More »
-
TSB #T-TT-0523-19
TT: Some 2017, 2018 and 2019 model year Highlanders are equipped with an engine Stop & Start system. It is important to use part number 28800-31550 when Stop & Start equipped Highlanders need battery replacement. Read More »
-
TSB #T-SB-0279-17_Rev
TSB: REVISION NOTICE November 13, 2018 Rev2: ? The entire bulletin has been updated. March 16, 2018 Rev1: ? Applicability has been updated to include 2018 model year vehicles. ? The entire bulletin has been updated. Read More »
-
TSB #T-SB-0113-18
TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body ... Read More »
-
TSB #T-SB-0197-17_Rev
TSB: REVISION NOTICE May 08, 2018 Rev1: * Applicability has been updated to include 2019 model year Toyota vehicles. Any previous printed versions of this bulletin should be discarded. Read More »
-
TSB #T-TT-0687-22
TT: When customers have a concern about a discharged battery, no start, or general battery concern, the DCA-8000 is the only appropriate tool to use for diagnosis Read More »
-
TSB #T-TT-0553-19 Rev
TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. Read More »
-
TSB #T-TT-0523-19_Rev
TT: Some 2017, 2018 and 2019 model year Highlanders are equipped with an engine Stop & Start system. It is important to use part number 28800-31550 when Stop & Start equipped Highlanders need battery replacement. Read More »
-
TSB #T-SB-0003-22
TSB This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. Read More »
-
TSB #T-TT-0600-20 Rev
TT: Some customers may experience echoing on the line calling the vehicle when using Bluetooth Hands Free. This is caused by the phone Hands Free volume being too low. Read More »
-
TSB #T-TT-0517-18_Rev
TT: Voice navigation prompts and feedback beeps are inoperative after starting the engine. This condition only occurs on Platinum grade vehicles. Read More »
-
TSB #T-TT-0663-21
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
-
TSB #T-TT-0537-19_Rev
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
-
TSB #T-TT-0537-19
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
-
TSB #T-TT-0503-18_Rev
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
-
TSB #TSB005823
TSB: The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. Read More »
-
TSB #TSB003220
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
-
TSB #23TE04
DL: On December 20, 2022, a settlement of claims for certain low pressure fuel pumps was approved by the federal court. Read More »
-
TSB #T-SB-0094-21 Rev
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
-
TSB #TSB004522Rev1
TSB: Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #Toyota Safety Re
Toyota Safety Recall and Service Campaign - Technician Certification Requirements Read More »
-
TSB #TSB001221Rev2
TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. Read More »
-
TSB #TSB001221Rev2
TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. Read More »
-
TSB #T-SB-0094-21
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
-
TSB #T-SB-0073-19
TSB: TMNA Accessory Sales and Marketing has developed a Toyota paint protection film (PPF) decal (treated with a specially developed light adhesive) for 2019 ? 2020 model year Toyota vehicles. The decal comes in two sizes (2.8 in. x 8 in. Read More »
-
TSB #T-SB-0113-18
TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body ... Read More »
-
TSB #Expired Quick Re
CRC SPRAY QUICK REFERENCEGUIDE Read More »
-
TSB #T-SB-0073-19 Obs
OBSOLETE NOTICE July 31, 2020: This bulletin is no longer applicable and is now obsolete. Read More »
-
TSB #TSB003220
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
-
TSB #T-SB-0045-22
Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #Toyota PRO19-02
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
-
TSB #Toyota PRO19-02
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
-
TSB #T-TT-0528-19_Rev
TT: Some 2014-2020 model year Highlander and Highlander HV vehicles are equipped with alloy wheels that are clad with a plastic cover. Read More »
-
TSB #T-TT-0528-19
TT: Some Highlander and Sienna clad/chrome wheels might experience bubbling and/or peeling off on the wheel coating (see picture below). Table below shows the wheel part numbers affected by the issue. Read More »
-
TSB #T-SB-0012-21 Rev
TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. Read More »
-
TSB #T-SB-0012-21
TSB: Some 2010 ? 2021 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. Read More »
-
TSB #T-TT-0515-18
TT: When adjusting the Forward Recognition Camera on vehicles with Toyota Safety Sense, it can be difficult to print the repair manual target to the proper size. Read More »
-
TSB #T-TT-0515-18
TT: When adjusting the Forward Recognition Camera on vehicles with Toyota Safety Sense, it can be difficult to print the repair manual target to the proper size. Read More »
-
TSB #T-TT-0663-21
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
-
TSB #T-TT-0537-19_Rev
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
-
TSB #T-TT-0537-19
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
-
TSB #T-TT-0503-18_Rev
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
-
TSB #T-TT-0503-18
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
-
TSB #T-TT-0503-18
TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop ... Read More »
-
TSB #T-SB-0115-22 Rev
TSB: Some 2019 ? 2022 model year Avalon, 2018 ? 2023 model year Camry, 2017 ? 2022 model year Highlander, and 2017 ? 2020 model year Sienna vehicles equipped with a 2GR-FKS engine may exhibit a knocking noise from the vacuum pump at idle. Read More »
-
TSB #TTT063620
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Read More »
-
TSB #T-TT-0636-20 Rev
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #T-TT-0636-20
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #T-TT-0568-19
TT: Some customers may experience a rattle noise from the roof area while driving at highway speeds, on vehicles equipped with Toyota Genuine Accessory Roof Rack Cross Bars. Read More »
-
TSB #TTT073723
TT: A very small percentage of customers experience operational difficulties with some telematics features which they cannot resolve on their own. Read More »
-
TSB #TTT069522
TT: To improve customer support of telematics connected services features, additional resources have been provided in the Service Lane - Knowledge Center. Read More »
-
TSB #TSB003220
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
-
TSB #T-SB-0057-18
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #TSB000923
TSB: Some 2014 ? 2020 model year Toyota vehicles may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ?DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ?DTC P0087 ... Read More »
-
TSB #T-SB-0045-22
Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #T-SB-0032-20 Rev
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the ... Read More »
-
TSB #T-SB-0003-20 Rev
TSB: Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #T-SB-0103-20
TSB: This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for some 2008 ? 2021 model year Toyota vehicles. Read More »
-
TSB #T-TT-0578-19 Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #T-TT-0615-20 Rev
TT: The Toyota Quality group is looking to better understand our customers expectation regarding vehicle drivability. Read More »
-
TSB #T-SB-0074-20
TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid ... Read More »
-
TSB #T-TT-0516-18_Rev
TT: The microphone circuit passes through the DCM before reaching the radio/navigation system. To simplify the diagnosis of the microphone, Safety Connect SOS button lights, and DCM (Data Communication Module/telematics transceiver) ... Read More »
-
TSB #T-TT-0606-20
TT: Due to the challenges caused by the COVID-19 virus threat, some dealers are experiencing reduced traffic into their stores and causing dealer stock to age. Read More »
-
TSB #T-TT-0583-19_Rev
TT: Some customers who have upgraded their iPhone? to iOS13 are experiencing a condition where the Bluetooth connection disconnects and reconnects. Read More »
-
TSB #T-SB-0032-20
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. Read More »
-
TSB #T-TT-0598-20
TT: Some vehicles may experience a ?New software is not compatible with the system.? Pop-up while performing T-SB-0003-20 during the head unit software installation process Read More »
-
TSB #19TC04 - DD - Pu
Dealer Daily Message: **Dealer Letter and Technical Instructions Available on TIS** Certain 2017 ? 2019 Model Year Highlander HV ? Special Service Campaign 19TC04 Dealer Letter and Technical Instructions now available on TIS. Read More »
-
TSB #Parts HotWire 20
Dealer Message: Parts Hotwire. In an effort to assist dealers in performing campaign 19TC04 on a customer?s first visit, Toyota is deploying stock of part number 04009-40131 (PIPE KIT, OIL COOLER) to all dealers. Read More »
-
TSB #Oil Cooler Pipe
Technical Instructions: TECHNICAL INSTRUCTIONS FOR SPECIAL SERVICE CAMPAIGN 19TC04 OIL COOLER PIPE CERTAIN 2017 ? 2019 HIGHLANDER HV Read More »
-
TSB #T-SB-0008-20
TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Read More »
-
TSB #T-TT-0520-19_Rev
TT: In certain cases of leaking air conditioning systems, the root cause of the leak is inadvertently overlooked, causing a repeat repair. Read More »
-
TSB #T-SB-0042-19_Rev
TSB: REVISION NOTICE January 17, 2020 Rev1: ? The Introduction section has been updated. Any previous printed versions of this bulletin should be discarded. Read More »
-
TSB #T-SB-0279-17_Obs
TSB: OBSOLETE NOTICE January 13, 2020: This bulletin is now obsolete. Please see T-SB-0003-20. Read More »
-
TSB #T-SB-0316-17_Rev
TSB: REVISION NOTICE November 14, 2019 Rev2: ? The Applicability has been updated to include 2019 model year Toyota vehicles. ? The Introduction and Repair Procedure sections have been updated. Read More »
-
TSB #Toyota Safety Re
Safety Recall and Service Campaign - Technician Certification Requirements Read More »
-
TSB #T-TT-0574-19
TT: Some customers may experience poor outgoing Bluetooth sound quality, this can occur for various reasons. Read More »
-
TSB #T-TT-0553-19
TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. Read More »
-
TSB #T-SB-0073-19
TSB: TMNA Accessory Sales and Marketing has developed a Toyota paint protection film (PPF) decal (treated with a specially developed light adhesive) for 2019 ? 2020 model year Toyota vehicles. The decal comes in two sizes (2.8 in. x 8 in. Read More »
-
TSB #T-SB-0042-19
TSB: Some 2019 model year Highlander and Highlander Hybrid vehicles equipped with JBL audio may exhibit inoperative navigation voice prompts and/or button beeps with the setting ON. Read More »
-
TSB #T-TT-0414-16-Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #Toyota Safety Re
Safety Recall and Service Campaign - Technician Certification Requirements Read More »
-
TSB #T-TT-0516-18_Rev
TT: The microphone circuit passes through the DCM before reaching the radio/navigation system. To simplify the diagnosis of the microphone, Safety Connect SOS button lights, and DCM (Telematics transceiver) inoperative conditions, refer ... Read More »
-
TSB #T-TT-0520-19
TT: In certain cases of leaking air conditioning systems, the root cause of the leak is inadvertently overlooked, causing a repeat repair. Read More »
-
TSB #T-TT-0517-18
TT: Voice navigation prompts and feedback beeps are inoperative after starting the engine. This condition only occurs on Platinum grade vehicles. Read More »
-
TSB #T-TT-0515-18
TT: When adjusting the Forward Recognition Camera on vehicles with Toyota Safety Sense, it can be difficult to print the repair manual target to the proper size. Read More »
-
TSB #T-TT-0414-16-Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #Safety Recall an
Update on Technician Certification Requirements. Read More »
-
TSB #T-TT-0600-20 Rev
TT: Some customers may experience echoing on the line calling the vehicle when using Bluetooth Hands Free. This is caused by the phone Hands Free volume being too low. Read More »
-
TSB #T-TT-0578-19 Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #T-SB-0112-20 Rev
TSB: Some 2018 ? 2020 model year Sienna (XLE, Limited); 2019 model year Avalon, Avalon Hybrid, Corolla Hatchback, Highlander (Platinum only), Highlander Hybrid (Platinum only), RAV4, and RAV4 Hybrid; and 2020 model year Corolla, Corolla ... Read More »
-
TSB #T-SB-0112-20
TSB: Some 2018 ? 2020 model year Sienna (XLE, Limited); 2019 model year Avalon, Avalon Hybrid, Corolla Hatchback, Highlander (Platinum only), Highlander Hybrid (Platinum only), RAV4, and RAV4 Hybrid; and 2020 model year Corolla, Corolla ... Read More »
-
TSB #T-SB-0062-20 Rev
TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Read More »
-
TSB #T-TT-0600-20
TT: Some customers may experience echoing on the line calling the vehicle when using Bluetooth Hands Free. This is caused by the phone Hands Free volume being too low. Read More »
-
TSB #T-TT-0583-19
TT: Some customers who have upgraded their iPhone? to iOS13 are experiencing a condition where the Bluetooth connection disconnects and reconnects. Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
-
TSB #T-TT-0414-16-Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #T-TT-0516-18_Rev
TT: The microphone circuit passes through the DCM before reaching the radio/navigation system. To simplify the diagnosis of the microphone, Safety Connect SOS button lights, and DCM (Telematics transceiver) inoperative conditions, refer ... Read More »
-
TSB #T-TT-0414-16-Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #TSB004522Rev1
TSB: Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
-
TSB #T-TT-0600-20 Rev
TT: Some customers may experience echoing on the line calling the vehicle when using Bluetooth Hands Free. This is caused by the phone Hands Free volume being too low. Read More »
-
TSB #TSB009421Rev1
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
-
TSB #TSB000320
OBSOLETE NOTICE May 02, 2022: This bulletin is now obsolete. Please see T-SB-0045-22 Read More »
-
TSB #Toyota PRO19-02
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
-
TSB #Toyota PRO21-UFR
UPDATES TO THE 2014-2021 TOYOTA UNIVERSAL FLAT RATE MANUAL Read More »
-
TSB #T-SB-0015-21
TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2021 model year Toyota vehicles equipped with an FKS engine. Read More »
-
TSB #T-SB-0044-16 Obs
OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0012-21. Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
-
TSB #T-TT-0537-19
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
-
TSB #T-SB-0044-16_Rev
TSB: REVISION NOTICE February 7, 2019 Rev2: * Applicability has been updated to include 2010 - 2014 model year Matrix, 2017 - 2019 model year C-HR, 2019 model year Corolla Hatchback, and 2018 - 2019 model year Toyota vehicles. Read More »
-
TSB #Toyota Safety Re
Safety Recall and Service Campaign - Technician Certification Requirements Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The trail period of service is provided upon the vehicle purchase. Read More »
-
TSB #Safety Recall an
Update on Technician Certification Requirements. Read More »
-
TSB #T-PG007-01
Replacement vin plates. Read More »
-
TSB #T-PG002-91
Product general information. Read More »
-
TSB #T-SB-0003-20 Rev
TSB: Some 2016 ? 2018 model year Toyota vehicles equipped with Entune? Audio (version 01013E), Entune? Audio Plus (version 010156 or 01015C), or Entune? Premium Audio (versions 010171, 010170, or 01017D) may exhibit one or more of the ... Read More »
-
TSB #T-TT-0578-19 Rev
TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. Read More »
-
TSB #T-SB-0316-17_Rev
TSB: REVISION NOTICE November 14, 2019 Rev2: ? The Applicability has been updated to include 2019 model year Toyota vehicles. ? The Introduction and Repair Procedure sections have been updated. Read More »
-
TSB #T-SB-0080-19
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
-
TSB #T-TT-0537-19
TT: The blind spot monitor (BSM) sensor angle inspection is used to confirm that the BSM sensor is within the specified angle before performing axis beam adjustment. Read More »
-
TSB #T-SB-0080-19 Rev
TSB: Some 2006 ? 2022 model year Toyota vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. Read More »
-
TSB #T-SB-0080-19
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. Read More »
-
TSB #T-TT-0468-17-Rev
TT: HVAC drain tube is found to be blocked/clogged. Read More »
-
TSB #TTT073723
TT: A very small percentage of customers experience operational difficulties with some telematics features which they cannot resolve on their own. Read More »