2018 Audi Q7 piston melting diagnosed by a certified mechanic due to excessive oil consumption due to defective pistons. A class action suit was filed. And a warranty extension extension issued. There is no record of a warranty extension and should be. Please advise

- Manchester, NH, USA

This vehicle developed low oil alerts within 6 weeks of me receiving it with normal city driving. Multiple testing visits and comprehensive consumption testing later, it continued to have the low oil alerts very frequently and various random malfunction alerts like parking brake alert etc. For each complaint I took it to the dealership and did whatever they recommended but no eventual resolution was found. Early October this year, in the middle of traffic multiple alerts came on including drive system malfunction, parking brake malfunction and start stop malfunction. So many that the whole console just lit up and the car started rocking in the middle of traffic and I had to slow down to keep the vehicle in control. The car was rocking visibly and I had difficulty in maneuvering it to a safe location. I contacted the dealership and they gave me an appointment 4 weeks out saying that since the lights were solid and not flashing I could choose to drive the car. However it didn-??t look safe to drive so I didn-??t use it thereafter. They later told me after a diagnostic evaluation that the engine needed to be replaced as the slapping piston rings had scraped the cylinder walls.

- Fairview, PA, USA

Catastrophic engine failure, this occurred 2 weeks after a service appointment where nothing was detected. The car only had 86,000 miles and it is unrepairable. We have now found that this could be due to a design flaw in this model which we were unaware of.

- South Orange, NJ, USA

I am reporting a progressive oil consumption defect that led to a catastrophic engine failure in my 2018 Audi Q7. The vehicle was purchased Certified Pre-Owned (CPO). I reported the excessive oil use to an Audi dealer. The dealer attempted to address the issue by performing an engine cleaning/flush, but the engine failed shortly afterwards. Over time, the vehicle required frequent top-offs between service intervals. Eventually, the engine suffered a mechanical failure, resulting in a broken exhaust valve and internal engine damage while driving on the highway. The Audi dealer provided a repair estimate of approximately $12,000. Audi of America offered 40% assistance to make the repair, but does not recognize the underlying excessive oil consumption issue. Furthermore, the proposed repair only replaces the damaged valve and related components, but does not address the underlying excessive oil consumption that caused the failure. This means the vehicle may still: -??unexpectedly run low on oil, -??lose power while driving, -??suffer additional internal damage, or -??again experience sudden engine failure while driving. These conditions can cause dangerous drivability issues, including loss of acceleration and potential stalling at highway speeds. This appears to be a serious safety-related defect involving lubrication failure, component breakage, and potential loss of power. I am requesting that NHTSA review this issue to determine whether similar failures are occurring in other Audi Q7 vehicles with the 3.0T engine.

- Spring Grove, PA, USA

#1 cylinder lost compression causing car to almost immediately stop while driving 78mph on the interstate. Car was towed back to manufacturer where I bought the car. The car 2018 Audi Q7 has 68,000 miles, all servicing of vehicle was done at dealership where I bought the car. Never any problems with engine except the occasional need for engine oil requiring being topped off.

- Leawood, KS, USA

This is a well known issue and multiple People have reported on this issue to Audi. It-??s is very common in Audi Q7 models from the year 2017 - 2023 where the PCV valve have a defect and the marker on the front passenger and driver side lights as well are out. These are both very costly repairs that are thousands of dollars that truly hurt the consumer. They know that the 3.0 L engine had a severe problem with the PCV valve and crack case and they have not warned customers and it-??s truly hurting the consumer in this economy. Please file this petition and I bet customers flock as I saw a Reddit thread with thousands of people complaining about the same common issue and problem with their Audi Q7. CRANK CASE VALVE/OIL SEPARATOR. LOUD WHISTLE NOISE COMING FROM ENGINE Parts: BOLT, Qty $14, CA TRIM, Qty 1.00, CA REPAIR KIT, Qty 6.00, CA GASKET, Qty 6.00, CA GASKET, Qty 6.00, CA TUBE, Qty 1.00, CA TUBE, Qty 1.00, CA WASHER, Qty 1.00,

- Las Vegas , NV, USA

Water pump failure

- Burnsville, MN, USA

To Whom It May Concern, I am writing to formally report a serious and recurring safety issue involving my 2018 Audi Q7. The vehicle has experienced repeated drive system malfunctions that result in sudden loss of power, reduced acceleration, and warning messages on the dashboard such as -??Drive System: Malfunction-?? and -??Electrical System Failure.-?? These incidents have occurred while the vehicle was in motion, creating a hazardous situation for both the occupants and surrounding drivers. In my case, the vehicle unexpectedly lost power while driving at highway speeds, forcing me to maneuver to the shoulder with diminished control. This sudden malfunction is unpredictable and could easily result in a collision or serious injury, especially in high-speed or high-traffic conditions. Upon researching this issue, I found that numerous other 2018 Audi Q7 owners have reported similar problems. These complaints consistently cite the same symptoms, including sudden deceleration, electrical system errors, and power steering failure. It appears to be a widespread defect that may warrant a recall or further investigation by the NHTSA. I urge your office to investigate this matter promptly to prevent potential injuries or fatalities. I am willing to provide service records, diagnostic codes, photos, or any other documentation that may support this complaint. Thank you for your attention to this serious safety concern. I hope the NHTSA will take appropriate action to ensure the safety of all drivers affected by this defect.

- Charlotte, NC, USA

The engine burns oil. At about 60k miles started to burn about a liter every 10k miles. Once the engine got to about 80K engines it started burning a leter about every 1K miles. The high amount of oil consumption fouled the spark plugs, coils, injectors and sensors. This resulted in a drive system malfunction, caused loss of power in the engine that ultimately ruined the engine with less than 100K miles.

- Marietta, GA, USA

Engine Rebuild/Replace: Cylinder 1 intake valve has broken causing misfire/ oil consumption. Due to piece of valve falling into combustion chamber, damage/scoring on cylinder wall. Recommend replacement of engine

- Granger, IA, USA

For over 24+ months now, the engine has been showing signs of excessive oil consumption. I've had the engine light come on requesting for me to add a quart of oil...on average, every 2,000 miles. I'm concerned with this excessive oil consumption as it is a major safety issue, as the piston rings may fail due to a possible faulty engine design (most likely since this excessive oil consumption is a frequent occurrence with other drivers of this vehicle). When discussed with the dealership, they are aware of the situation (2017-2019 Audi Q7 excessive oil consumption) and they request that I pay for an engine compression test. This amount of oil consumption shouldn't happen.

- Canton, MA, USA

First time on highway since getting it back from the car repair vendor two days prior. Drive system malfunction occurred on the highway drive approx.13 miles from my house. Car lost power and would stall and would barely idle. Stopped in the middle of highway traffic 3 times. Got the car towed to vendor that had serviced my car 2 days prior which involved changing rear brake pads and rotors, 6 supercharged spark plugs and air filter. Estimate of issue was damaged exhaust valves on cylinder 2 & 4. Recommended service was remove the cylinder heads, replace all exhaust valves, clean pistons and combustion chambers $8,032.99.

- Akron, OH, USA

The vehicle developed a misfire on cylinder 1. The dealership ran a 3 hour diagnostic that included using a borescope on all cylinders. One of the valves on cylinder 1 was identified as bad. The dealership indicated the only solution was to replace the engine and suggested trading the vehicle in for a new car.

- Atlanta, GA, USA

Valve three burnt causing engine failure and replacement

- Petoskey , MI, USA

At my 100k mile inspection it was noted that an engine mount is leaking. With a repair cost in the multiple thousands I checked online and have found this to be an extremely common occurrence with possible disastrous implications.

- Vancouver , WA, USA

We were driving down the expressway when the car began to vibrate. We pulled over and had lights on the dash. We had it towed to a dealership where it was diagnosed as a burnt valve and ruined motor. I believe a new Audi engine quote was around $26,000. We took very good care of this car. This is a common issue and will become more common as these engines fail.

- Petoskey, MI, USA

I have received two "cylinder misfire" notifications. The first occured in December 2023 on a remote stretch of freeway. The second occured in June 2024 on a remote stretch of highway. In both cases, I immediately lost power and put myself and cars around me at risk because I had to pull over onto the side of the road to re-start the car. After the second incident, I now have no confidence in taking my car, only 6 years old and with 74K miles on it, out of the city and into the countryside. The symptoms of this issue include frequent oil burn / oil top-offs. My car requires a quart of oil every 200-300 miles. There are no leaks in my driveway. The leaking all seems to be coming from the cylinders. I am taking my Q7 into a mechanic, again, next week and I am concerns the solution will be "new engine" which costs more than the car is worth.

- Lake Oswego, OR, USA

The contact owns a 2018 Audi Q7. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated. In addition, the contact stated that the oil level was topped off every 700 miles. The vehicle was taken to the dealer where it was diagnosed with a failed piston and excessive oil consumption. The contact was informed that the piston needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 75,000.

- Lansdale, PA, USA

Engine Malfunction Piston Rings Oil Consumption Loud brakes

- Cheektowaga , NY, USA

Noticed a lower level of coolant (below the MIN mark) at the coolant reservoir - checked with mechanic and was told there is a slow coolant leak at the one of the water pump seals (which has corroded). Need a water pump replacement. Was told it is a very common occurence with these cars - but was surprised to experience this issue on a car with less than 20K miles driven.

- New York, NY, USA