The contact owns a 2006 BMW 325I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated while driving 40 MPH, there was a significant amount of smoke coming out of the exhaust pipe and coming from underneath the hood of the vehicle. The check engine warning light was illuminated. The contact drove to the local dealer, where it was diagnosed that the PCV valve heater fuses had failed. The dealer charged a fee for the repair because the recall remedy was not available. The dealer installed an inline fuse and wiring that connected the PCV valve to the PCV valve heater. The contact stated that he received a second notice advising that the recall remedy was available, and the vehicle was taken back to the dealer, where the recall repair was performed. The vehicle was repaired. The contact later contacted the manufacturer for reimbursement, but the manufacturer referred the contact back to the dealer for assistance. The contact stated that he followed up with the dealer, who advised him that the failure was not related to the recall. The contact was not reimbursed. The failure mileage was approximately 132,000.

- Dallas, TX, USA

The contact owns a 2006 BMW 325I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

- North Las Vegas, NV, USA

The contact owns a 2006 BMW 325I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that upon starting the vehicle, he smelled a burning odor. There was no warning light illuminated. The contact stated that he was unable to duplicate the failure using an OBD reader. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 76,000. VIN tool confirms parts not available.

- San Jose, CA, USA

The contact owns a 2006 BMW 325I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) and requested to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.

- Cambridge, MD, USA

The contact owns a 2006 BMW 325I. The contact stated while starting the vehicle, there was an abnormal smoke odor coming from the instrument panel. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was not notified. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.

- York, SC, USA

The contact owns a 2006 BMW 325I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

- Lexington, MA, USA

The contact owns a 2006 BMW 325XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

- Williamsport, PA, USA

The contact owns a 2006 BMW 325XIT. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

- Ridgewood, NY, USA

The contact owns a 2006 BMW 325i. The contact stated while driving 40 MPH, he smelled a burning plastic odor. There were no warning lights illuminated. The contact continued to drive the vehicle. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted and referred the contact to the manufacturer. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact that the vehicle was safe to drive. The failure mileage was approximately 122,000. VIN tool confirms parts not available.

- Camby, IN, USA

White smoke coming though ac ducts. When taken to shop they said it was coolant leak in heater core. Replacement would cost me $3000-$4000.

- Union City, CA, USA

I have a 2006 325I sedan with 55,856 miles on it. I took it in for a routine service on 4-18-2013. It has been maintained by only BMW dealerships in its lifetime with all required maintenance done on schedule. They called to notify me that upon inspection they had found the head bolt broken behind the oil filter housing, the oil filter housing gasket leaking and the drive belt tensioner leaking. I had not been experiencing any outward S+S of this problem. They quoted me $3400 to repair this. I was shocked that a car in such great condition would have such a problem at this mileage. I asked why this would happen and essentially was told it is unusual but does happen. They advised a repair in the future. I went home and researched this and found it has been a common problem in this model and that subsequently BMW has changed the type of bolt they use. So I thought I would call the customer service line to follow up on any assistance from BMW. Long story short they took the complaint but because I have a low mileage vehicle that has been outside of warranty for 3+ years they would offer no help. You know shame on BMW this is my 4th BMW and very likely my last due to this. This should be a recall, this should not be happening no matter how long it took to get to the 50,000 mile + range where this problem shows itself.

- Oakland, CA, USA

Engine bolts have sheered off at three different mileages: 71,369, 115,162 and 134,835. All times they have created oil leaks and possible engine overheating. Also the sheered bolts could of gotten lodged in the drive belt causing loss of steering (although luckily did not happen). All sheered bolts cost upwards of $1000 per repair to replace.

- Macungie, PA, USA

Water pump and thermostat both quit working at the same time. Causing absolutely no warning on the vehicle until it started overheating and smoking while driving on the highway. Could of caused a serious accident. Needed to immediately pull to shoulder. Note: Car has no oil temperature gauge.

- Macungie, PA, USA

The contact owns a 2006 BMW 325I. The contact stated that the vehicle was leaking oil through the head gasket. In addition, the sun roof cloth detached from the vehicle. The contact also stated that the steptronic transmission gears would not engage in ds or manual, only drive. The vehicle was taken to the dealer who advised the contact that there were no recalls for the failure. The vehicle was not repaired. The manufacturer was notified of the failure who offered no assistance. The failure mileage was 63,000.

- Guaynabo, PR, USA

Broken head bolts and blown head.

- Provo, UT, USA

The head bolts are cracked/broken at approximately 70,000 miles.

- Lookout Mountain, GA, USA

Bolts for engine block valve cover broke off. Oil started leaking and exhaust smoking. Normal driving, with no auto modifications and regular maintenance. Contacted BMW North America, but received no answer.

- Coconut Creek, FL, USA

The contact owns a 2006 BMW 325xi. The contact stated that when starting that the vehicle would exhibit an abnormally loud noise and vibrate when first started. The vehicle was towed to an independent mechanic where they advised her that all four motor mounts were fractured and the vehicle needed to be taken to an authorized dealer. The vehicle was taken to the dealer where they confirmed that the motor mounts were fractured. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 83,400. The VIN was unavailable.

- Howell, MI, USA

Noticed aluminum headbolt had broken off and caused an oil leak close to the front of the head on the oil filter side of the block, causing a burning oil smell as oil found its way to the burning hot exhaust manifold, thankfully, it did not catch on fire but I feel that it easily could while driving and could cause a serious accident should I or someone else panicked as it would have happened, BMW has acknowledged this issue in tsb's and already rectified the issue in the 2007 models of the exact same cars. If BMW does not rectify this issue, my 5th BMW will be my last and I will take my hard earned money to Audi, I find it heartbreaking that a company that used to have such a Focus on quality is refusing to acknowledge such failure and to right the situation over a 3$ bolt that has not only the potential to cause harm to many but also to alienate what have been long time customers and true fans of the brand.

- San Antonio, TX, USA

Heads of head bolts broke off. Normal slow, short commute driving. Exhaust smoking.

- Krotz Springs, LA, USA