My vehicle engine cooling fan caught fire one evening while following behind someone to make sure they made it to a parking lot safely due to their own vehicle having problems requiring them to stay under around 20mph. Once we made it to a parking lot, i exited my vehicle to check on the other person, and realized there was smoke starting to come out from under my hood. My husband waited for me to pull the hood release and then proceeded to lift the hood, only to discover my car was on fire, and it was coming directly from the cooling fan. After almost a minute we were able to put the fire out, and discovered the whole electrical area for the fan was melted and destroyed. There was never any type of warning light or any information at all that would have told me a problem was imminent. Im thankful it wasn;t myself alone or with my kids just driving down the highway because it would have taken over the whole vehicle before i would have known it was having any issues at all. The part is still on the vehicle, which has become inoperable and now any attempts to check the vehicle out have realized that another issues with BMW's is also causing problems with my vehicle. It appears an actual recall was never issued for my actual VIN, rather a collection of years and makes. Any further information or remedy that might get me the ability to actually use my vehicle again would be greatly appreciated. I can also include photos and witness statements if needed, . Thank you for your time.

- Freeport, TX, USA

The vehicle, stopped while driving, overheating, no heat/ ac. It's winter, car stopped at night in an unknown location fory safety. Had it inspected by 2 different auto shops and was confirmed of the issue. Warning lights came on right before the car failed.

- Hazel Crest, IL, USA

ON ALL E90 SERIES 3 (2008 BMW 328i), the PCV VALVE FAILS AND IS WELDED INTO THE VALVE COVER, THUS IF IT LEAKS OR GETS CRACKS IN THE ORANGE MEMBRANE, IT WILL CAUSE CAR TO STALL.. I ALMOST CRASHED 2x and this part should be recalled..IT AFFECTS THE FUEL AIR RATIO IN BMW E90, AND THE CAR WILL RUN LEAN AND NOT RECEIVE ENOUGH GAS AS AIR IS LEAKING FROM THE BROKEN MEMBRANE IN THE PVC VALVE. BMW WILL THROW ENGINE CODES WITH LIT CHECK ENGINE LIGHT ON DASH. THIS SHOULD BE A RECALL AS THE WHOLE VALVE COVER HAS TO BE REPLACED TO REPLACE A DEFECTIVE $10 PCV VALVE WHICH IS LUDICROUS...THE DEALER CHARGES thousand dollars and up to replace a ten dollar part. THE CAR HAS ROUGH IDLE AND WILL STALL, CREATING A DANGEROUS DRIVING SITUATION AND FATAL ACCIDENT. PLEASE RECALL to HAVE BMW DEALER FIX ThESE PLASTIC PVC VALVES ON E90S...I HAVE ENCLOSED PIC OF THE VALVE..IT ALSO HAS A SPRING BUT THE PLASTIC ORANGE MEBRANE CRACKS, BREAKS AND LEAKS AIR INSIDE VALVE, CAUSING CHECK ENGINE CODES, ROUGH IDLE AND STALLING OF VEHICLE.. THE VALVE IS LOCATED ON TOP OF VALVE COVER, WELDED INTO VALVE COVER. PLEASE HELP..THANK YOU STATE FLORIDA P.S. HEAT CAUSES THE PCV MEMBRANE TO CRACK MORE~~PIC ENCLOSED OF PCV VALVE ITS WELDED INTO TOP VALVE COVER..NO OTHER CAR HAS A PCV VALVE MOUNTED THIS WAY SO WHOLE VALVE COVER NEEDS TO BE REPLACED~ THANK U

- West Melbourne, FL, USA

2008 BMW 328I. Consumer writes in regard to loss of power and steam coming from the engine. The consumer had the vehicle towed to the nearest BMW to perform a recall. On March 13, 2023 the vehicle was picked up after repairs and the red warning light illuminated and engine was steaming once again.

- Laguna Beach, CA, USA

You guys have aluminum bolts that hold down the cylinder head they corrode or become loose thus pulling up the cylinder head and the head gasket is protruding out the front of the cylinder head causing oil and coolant to leak on to the belt causing the serpentine belt to slip off while it's raining and eventually causing a blown head gasket it's because of the aluminum bolts on the top of the engine that hold the cylinder head down the head gasket protrudes out the sides on the front where the camshaft sensors are and leaks onto the belt plus causing the belt to come off the track and possibly get sucked into the engine it's not something easy to get to or to fix for a person with low income

- Fresno , CA, USA

The contact owned a 2008 BMW 328I. The contact stated while driving at an undetermined speed, there was smoke coming from the vehicle. The contact stated that the vehicle overheated. The check engine warning light was illuminated. The contact stated that the engine was misfiring. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the PCV valve heater was melted. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that the vehicle had since been sold. The manufacturer was not notified of the failure. The failure mileage was approximately 114,000.

- Virginia Beach, VA, USA

The positive battery fuse cable under the glovebox is placed into a plastic space causing melting. This leads to the vehicle going dead and not even emergency lights will work. This recall has been placed on very few BMWs however it is affecting way more then they are saying. You can see in UK where a man was killed for the vehicle going dead in the middle of the road and emergency lights cannot be used to warn other drivers. How has their not been taken car of already. I am extremely disappointed in our system, and in BMW. My mind is completely blown that this is not cared about.

- Stanardsville, VA, USA

Due to the CRANKCASE VENTILATION (PCV) VALVE HEATER problem and BMW claiming they have no remedy for it yet, this has caused my engine to overheat smelling like burning electrical, The Container holding reserve antifreeze has broken off plastic components that may somewhere be in the cooling system. The valve cover gasket that was replaced only 3 years ago is beginning to fail and is leaking oil into the brand new spark plugs and coils. This is unacceptable. They say to stop driving the car if you smell burnt electrical. Heck, I have smoke coming from the engine at times. How are people who only have this 1 car suppose to get places when BMW delays repairing people's vehicles. They are wasting our money! They should have to repair all of the parts that this issue has caused damage to while they have us wait for remedy that seems to never come!

- Acworth, GA, USA

I have had continuous issues with the electrical system in the front drivers side headlight with burnt plastic housing to the main headlight and the plug for the blinker system. Sometimes it will work and most of the time it won't. I cant tell you the amount of times it has stopped working in the middle of using the blinker. Every time I attempt to change it out, the bulb ends up still in good shape after looking it over. I have always inserted a new one but the issue remains. I have had to replace the whole headlight unit because of the melted plastic not holding the plug any longer and the issue remains. The passenger side seatbelt light has been on for the past several years and will not go off. It shows a light stating the airbag is off. Every time I use the AC unit, I end up with a whole lot of AC condensation pouring out each side of my console soaking the floor of the vehicle and smelling horrible the next day. I don't understand how such a supposedly high quality car can have such stupid problems that cant seem to be fixed. I have had this car since 2013 and barely drive it as I have only put approx 9000 miles over the last 9 years.

- Acworth, GA, USA

My car will not start up to show ignition lights-?? blinks fast then shuts off / will not crank / after flashing lights on dash service engine light appears & car has smoking from under hood

- Calhoun, GA, USA

The car was over heating and not starting as well as fuel pump error on my dash. There is an open recall on my vehicle starting March of 2022 it is now June and BMW says they don-??t know when they will have a remedy for this and it could be months but I need my car.

- Fort Wayne, IN, USA

Keep getting the p0015 code changed all sensors that come with code and I keep getting a high pitched noise once car gets hot.

- Madison, IL, USA

The contact owns a 2008 328i. The contact stated while driving 30 MPH, the vehicle was making abnormal sounds. There was no warning light illuminated. The contact stated he smelled a burning odor and parked the vehicle. The contact looked under the hood and did not see any damage. The contact restarted the vehicle to drive home and heard a loud noise coming from the engine and vehicle started overheating. After arriving home, the contact opened the hood and became aware that the hood insulation was missing, and the PCV hose was leaking oil. The vehicle was towed to an independent mechanic and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 102,000.

- Daly City, CA, USA

The contact owns a 2008 BMW 328XI. The contact stated that while driving at 60 MPH on the highway, the engine failed. The contact pulled over to the emergency lane. There were no warning lights illuminated. The contact restarted the vehicle and drove home safely. The vehicle was taken to a dealer where the failure code was not able to be generated and another appointment was made for further testing. The vehicle was not repaired. The contact was also informed that his vehicle could be related to a fuel injection issue. No further information was available. The approximate failure mileage was 147,675.

- Chico, CA, USA

The contact owns a 2008 BMW 328i. The contact stated that he had parked and turned off the vehicle, but about 20 minutes later he saw smoke coming from underneath the hood of the vehicle. The contact stated that as he opened the hood of the vehicle he saw flames of fire and was able to extinguish the fire with a fire extinguisher. The contact stated that he removed the battery from the vehicle. There were no injuries sustained. A police report was not filed. The vehicle was towed to the contact's residence. The dealer was notified of the failure and advised the contact to tow the vehicle to their location for diagnosis. The vehicle was towed to the dealer, however, the dealer informed the contact that they could not diagnose the vehicle as the vehicle had caught fire. The dealer referred the contact to NHTSA. The manufacturer was not notified of the failure. The vehicle was not diagnosed or repaired. The approximate failure mileage was 129,000.

- Los Angeles, CA, USA

Mileage Rollback

- Jackson, NJ, USA

The contact owned a 2008 BMW 328xi. The contact stated while driving 35 mph, she saw smoke exiting the front passenger side of the vehicle. The contact stated that there was no warning light illuminated. The contact parked and exited the vehicle safely and called 911. The contact stated 25 seconds after exiting the vehicle, the vehicle exploded and caught on fire. The fire department arrived and extinguished the fire. A fire report was filed. The contact stated that there was no injury. A police report was not filed. The vehicle was towed to a towing lot. The vehicle was not diagnosed nor repaired. A dealer was not contacted. The manufacturer was not informed of the failure. The failure mileage was approximately 131,000.

- Kingston, NY, USA

My vehicle started shutting down from the radiator where it can only be started manually.

- Suffolk, VA, USA

Engine camshaft(vanos) adjustment units failing. BMW na never sent out a recall when knew of it in 2018( see attached Feb 2018 service bulletin). On 8/27/20, tisha of BMW NJ office claims dealer is responsible but says there is no recall outstanding. I took it to dealer critz of savannah, ga on 8/27 who claim that there was no recall for this manufacturer defect and that BMW are not built to last 12 years. It cost at least $4000 if not more to fix a recall item that BMW issued Feb 2018 for this and never sent to us. In 2018, they recalled this car for other safety issues (see attached) but hid this major defect they knew about in 2/2018. I am attaching a recall that my auto repair gave me that was never ever given to me by dealer nor sent from BMW na. I need your help to have BMW na extend the recall and pay for for this life threatening manufacturer defect. This was hidden from the public and should be investigated immediately. I was told by critz yesterday prior to my planned trip across the us on 9/4 that the engine could drop at any time as the bolts could be loose but there is no way to tell without spending $1,500 with no end in sight. This car is not an out of town car anymore according to david of critz and was never built to last until 2020. I now have no assurance that I am driving safely in this car and have to add several days to my trip.

- Tempe, AZ, USA

While driving and vehicle in motion even during acceleration, with no warnings vehicle just stalls. Engine shuts off and loss of power steering. Power to rest of vehicle still works fine and not interrupted. This has happened on city streets but luckily was able to muscle off the street into safety as car still glided. Unknown to components causing issue as check engine light goes off after being able to restart vehicle. Had vehicle scanned and nothing comes up. All recalls have been performed according to BMW website.

- Phoenix, AZ, USA