Hpfp is going bad engine light comes on long crank start

- Deltona, FL, USA

My BMW is a 2008 BMW 535xi that was manufactured on 02/2008. I have had an issue with cylinder 4 misfiring so I changed all 6 spark plugs and cylinder 4 ignition coil only to have cylinder misfiring still. I took it to a mechanic and they checked and stated that I had a bad ignition coil because my spark plug and ignition coil smelled like fuel. My friend is a tech at a local BMW dealership and told me not to repair it yet because BMW has issued a recall for my vehicle which is a E61 sports wagon. I will provide the document that shows that my vehicle is under the affected vehicles. When at idle my car shakes. This has been going on for about a year I just never had the money to fix it and didn't know what the issues were until now. I don't know the exact date so I will put today's date.

- Lincoln, RI, USA

The contact owns a 2008 BMW 535xi. The contact stated that while driving at various speeds, the engine misfired the vehicle was taken to the local dealer BMW of columbia located at (1900 I70 dr. Sw, columbia mo) who diagnosed that the engine cylinder number 4 misfire was due to defective fuel injectors. The fuel injectors were replaced and the failure was remedied. The manufacturer was also notified of the failure. The failure mileage was 93,450.

- Columbia, MO, USA

I was driving home stopped at a red light, then turned green went to accelerate car took off and lost all power would not move pressing accelerator and 2 semi trucks coming real fast from cross traffic almost killed me light turned red for me and green for semi trailers with no time to exit car.

- Fontana, CA, USA

Vehicle stalls, hesitates when driving. Message on the dash says that the fuel pump is failing, but can be driven with decreased performance and to bring the vehicle to BMW. Brought the car to BMW service and they told me that there was a recall on the fuel pump but my car is not covered because I have 159K miles one the said vehicle. Upon further investigation with the service advisor, (carlos - norwalk BMW), who is polite and helpful, we found that the car had already been serviced for three same problem at least 3 times. First is in 2009 when they replaced the high pressure fuel pump. After folloa year 2010, the same problem occurred. The dealership again replaced the same fuel pump. Then on 2013, having the same problem again, the dealership replaced the injectors but the problem is still occurring. The problem had been ongoing and this time, they will not fix the issue because the vehicle is over the 120K miles. I believe that BMW is responsible for the problem that the vehicle was never properly fix in the first place. At least 3 times of having the same problem (that was documented by BMW), and still not resolved! it is a good car, but can be dangerous and could cause an accident. I will not let my wife drive it anymore until I feel it is safe. Problem is intermittent. At low speed, idling, and at highway speeds which can be really scary. I hope they will take responsibility and actually find and fix the issue.

- Norwalk, CA, USA

Currently having issues with a wastegate rattle on turbos. Rough engine idle. Having multiple misfires, and stuck open fuel injectors. Causing tailpipes to excessively smoke (white color) while going into limp mode could not go past 20mph and surging. Issues happen when stationary and while driving. Had to get vehicle towed home. 'fuel injector recall 16E-A01 'hpfp recall- could not find number 'turbo recall- could not find number

- Whittier, CA, USA

While driving on the highway and local streets the car suddenly loses power and cuts off giving a fuel pump malfunction. I had the high pressure fuel pump replaced and the problem still exists. This has put my whole family in danger because it has happened on the highway at speeds in excess of 50 mph. The car just suddenly shut down.

- West Babylon, NY, USA

BMW clearly states that this vehicle had a recall on the fuel injectors and related components and when the recall was completed it states that a emblem to mark completed is placed under the hood. Although, this is not on my vehicle nor does it show being completed on any type of information. BMW is very secretive about all issues on the vehicles that they manufacturer. In fact, most all BMW dealerships service departments do their very best too make you pay for non issues and will not repair what is really found to be the issue. If needed, I can give you at least two that I am very familiar with about this matter.

- Broken Bow, OK, USA

Mechanical inspection revealed a crack in intake manifold. This defect manifests itself with difficulty starting the engine during cold starts, hesitation when applying the gas pedal for rapid acceleration on highway roads. There is also a rough idle

- Tucker, GA, USA

On Thursday March 30th I dropped the car off with brinsfield auto in greensboro, nc because my check engine light came on. On April 6th I picked it up with completed repairs of a cleaned #5 fuel injector that was diagnosed as running rich but after being cleaned was running correctly and check engine light was no longer an indicator. On April 8th I was driving in gastonia, nc and the car began smoking and shuddering to the point it was not drivable. I pulled into a car dealership that was closed because it was after hours and parked the car. My son and I got out of the car and noticed a very clear odor of gas. There was a couple driving through the dealership lot who stopped and also noticed the odor and agreed it was indeed fuel and I should not drive the car. It was towed back to brinsfield auto where it was discovered that the #5 fuel injector was locked in the open position and shooting straight fuel through the engine and out the exhaust pipe. This could have cause a fire had I not noticed.

- Mcleansvile, NC, USA

My car is stalling while I'm driving. " engine malfunction reduce power " the code is ( P 3090 ).. it's very unsafe. I don't have power to move it to the side of the road safely.. I drive mainly interstates I 75 and I475 to macon Georgia.

- Griffin, GA, USA

The contact owns a 2008 BMW 535I. While driving approximately 60 mph, the fuel pump failed and the engine warning indicator illuminated. The vehicle was pulled over to the shoulder and towed to the dealer where it was diagnosed that the fuel pump needed to be replaced. The vehicle was repaired. The contact stated that both of the vehicle's fuel pumps were replaced, but the failure recurred. The vehicle was taken to the same dealer and the fuel pump was replaced again due to a defective manufacturer's part. The failure mileage was 60,000. Updated 01/25/2017 updated 6/28/18

- Winston-Salem, NC, USA

The contact owns a 2008 BMW 535xi. While driving 50 mph, the vehicle lost power and overheated. In addition "please shut engine off due to overheating " was displayed across the message board. The vehicle was taken to a dealer where it was diagnosed that the fuel pump needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was not notified of the failure. The failure mileage was 60,000.

- North Brunswick, NJ, USA

Check engine light came on and car started shaking violently. It happened as soon as I took a corner and hit the gas and lasted until I turned the car off. Very rough idle.

- Newport Beach, CA, USA

While driving on freeway at 70 mph, the vehicle began to lose power in heavy traffic. I noticed on computer screen engine malfunction-reduced power. So, I manuvered to get to outside shoulder lane, and stopped the vehicle.it was sputtering at the time, and I turned the vehicle off for a few minutes. And then started it again and the problem had cleared itself, so I proceeded to my home. When I got home, I checked on the computer for online information, and saw a recall notice for this vehicle because of high pressure fuel pump failure, safety hazzard. The car was purchased last year from a dealer with only 40,000 miles on it, and at that time the dealer said, "the old owner traded it in on a new vehicle." So, I have no record if this problem was recalled through this 1st owner or not? it acted exactly as the safety complaint explained, the loss of power with engine malfunction. I was fortunate to get off the freeway to a safe place to stop, with lack of power. It was strange to say the least, and the vehicle now has 45,000 miles on the odometer.(I looked up on the site for recalls and put in the VIN number, and the indication came back, no recall on this vehicle. It is ironic that this is the same type of incident that happened to cause major problems, enough to have an abc safety recall special, and I experience the same type of event that many others had. Please advise me of my next procedure to not experience this again. Troubled driver 7/1/2016

- Mesa, AZ, USA

The car has an passenger restraint error that does not go away. The car fuel gage does not work either

- North Potomac, MD, USA

I recently purchased a 2008 BMW 535xi and have had it for about a week or so. It has spent more time in the shop than on the road due to fuel injectors causing misfires and now the high pressure fuel pump has gone out. I recently found out also that this is a common issue with BMW and they are pretending that the fuel pump malfunction in 3 & 5 series isn't their fault. I checked the carfax on the vehicle before buying it and it was serviced regularly at a BMW dealership. After further research I also have found out that the dealership totally ignored the recalls and screwed over the first owner. BMW needs to take full responsibility for selling cars with known defective parts. I have to drop $3800 to fix the problems that the fuel pump has caused. The car won't even start now.

- Charlotte, NC, USA

I was exiting the the freeway and when I was on a banked onramp the engine stopped running while vehicle was in motion. I lost power steering and the ability to release the brake. I nearly lost control of the vehicle as the unexpected loss in power steering caused me to loose grip on the wheel. The engine was in neutral when the engine stalled. Upon restarting the engine (which struggled to start) the "service engine soon telltale" illuminated and the vehicle entered "reduce engine power mode". after scanning the dtc (P3090) I learned the vehicle's high pressure fuel pump failed. I noticed BMW has a recall on the issue. Unfortunately their recall only covers the fuel pump to 120,000 miles and my vehicle has roughly 9,500 miles above the covered threshold. Based on my experience and reading online I feel the pump has some sort of design flaw that BMW has failed to properly address. I wish BMW would hold up to their integrity and continue to replace the fuel pump for the life of the vehicle.

- Grosse Pointe Woods, MI, USA

I started my car and upon starting it began rattling and shaking violently. I took a video of the message that appeared on the dash saying. Engine malfunction reduced power.

- Lowell, MA, USA

I drove to work and the engine light was on that morning. The car drove as normal. I was driving home from work at approximately 6:30 P.M on a busy interstate in the middle lane traveling approx. 65 mph when the car began to shake and lose power. It automatically shifted into neutral and lose power. I had to maneuver to the shoulder in heavy traffic with no power. After turning on my hazard lights, I was able to safely get to the shoulder. The car was towed home. After a few days, we were able to drive it to the repair shop (not BMW) and was initially told that sensors were bad. Replaced them and a few days later, the same engine warning light came on again. This time I was told that it was bad injectors and that the fuel is burning to rich. BMW had previously replaced 2 of the injectors about 2 years ago. The car only had approximately 35K miles at that time and needed injectors replaced. Why they only replaced 2, is incomprehensible. Thankfully, the car was under warranty at that time, unfortunately for me, it is no longer under warranty and now I have to foot the $2K bill to have them replaced. BMW should be held accountable to its owners and replace these injectors since there are so many reported problems. There is obviously an issue with the injectors. These cars are not inexpensive to purchase and it is unfair to be stuck with these high repair bills when there is a know problem and reported by so many BMW owners. First, it was my water pump, and now the fuel injectors. This is my second BMW. I previously owned the 328 and it had lifters replaced after about 8 months. I will not purchase another BMW - probably go with Lexus! shame on BMW for not taking ownership of this problem..

- Hayward, CA, USA