10.0

really awful
Crashes / Fires:
0 / 1
Injuries / Deaths:
0 / 0
Average Mileage:
92,214 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2003 BMW 540:

Unsubscribe any time. We don't sell/share your email.

problem #5

Mar 012012

540

  • 31,068 miles
BMW E39 540I possible defective blower motor resistor (climate control fan resistor) with heatsink.. affects "auto" fan.. very noticeable in the long run.. known problem.. many do not last past 50,000km.. see www.bimmerfest.com/forums/showthread.php?T=143393 for replacement..

- Cambridge, FL, USA

problem #4

Nov 212011

540 8-cyl

  • 108,000 miles
Car shut down while driving appx 35mph without warning, nearly crash due to loss of steering assist and instrument. Dealer replaced both dme and battery which was suspicious since two unrelated component failed at same time? extremely dangerous when it happened in traffic, endangering both my passengers and other drivers nearby. Recall to the dme and battery should be issued. Repair cost $2500.

- Greenwich, CT, USA

problem #3

Aug 092011

540 6-cyl Diesel

  • 125,000 miles
My 2003 BMW 530I sedan caught fire due to an electrical fault while parked in new haven, Connecticut. The fire department and police were called. Case #[xxx] was assigned by officer [xxx] of the new haven pd. The car, too badly damaged to repair, was hauled away for eventual scrapping. I was close to the car when the fire started. Flames were erupting from the dash, where the climate control switches are located. I tried smothering the flames with a sweater. This did not interrupt the progress of the fire. There was no personal injury or property damage other than to the car and its contents. Items situated in the front seat area were not recovered, due to the intensity of the fire. The apparent cause of the fire was an electrical fault. In 2010 new country BMW in hartford twice replaced the climate control fan final stage resistor, once in April and again in October, at no charge for the second replacement. In the days before the fire the climate control was again acting erratically, and the evidence indicates the final stage resistor was failing once again. BMW North America inspected the car and confirmed that the fire was caused by an electrical fault in the area behind the dash where the final stage resistor is located. Information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Simsbury, CT, USA

problem #2

Jan 312012

540 8-cyl

  • 107,000 miles
While driving, the car suddenly shut down and lost all power. Had to pull over to the side of the road quickly to avoid an accident; had this been at high speed, the situation might have been worse. Subsequently when trying to start, the car shows a myriad of warning lights and faults. A fuse for the main computer (dme) had blown, due to a wiring short between the electronic thermostat and the main computer. Replacing the fuse is not a permanent fix, as it blows shortly after each time the car is started, rendering the car undriveable. This fix to replace shorted wiring is in the thousands of dollars. The car had been meticulously maintained and had never suffered any related issue before. There is a poor connection, faulty wiring, design flaw, or the like in this system.

- Yorba Linda, CA, USA

problem #1

Jul 102010

540 6-cyl

  • 90,000 miles
Intermittent engine shut-down. Engine shuts off while vehicle is in motion at any speed. "engine failsafe" warning light comes on. Vehicle must be stopped, key turned off and re-started. This is a serious safety issue that BMW is aware of and has issued a related tsb. $2000 plus repair bill for a new "engine wiring harness". BMW should be recalling these vehicles.

- Appleton, WI, USA