Driver Restraint Malfunction warning light turned on while driving and stated dangerous driving conditions and to see a Dealer immediately. The Dealer diagnosis was a faulty airbag wire harness due to rubbing against the metal which caused the airbag light to malfunction. Car had 47500 miles but BMW did not cover this faulty wiring under warranty. Should be a recall on faulty wiring.

- Cary, NC, USA

A portion on the Airbag system was/is disabled due to an issue, known to BMW, with the wiring harness connected to the passenger seat. It is available for inspection if requested. Normal movement of the electric seat in turn pulls a wiring harness that failed by being "chaffed". This flaw results in a "Restraint System Error", passenger side - a significant problem since this harness controls an integral safety system of the vehicle and ultimately disables part of the airbag system until repaired. During inspection at the dealer's service center, the car was connected to a fault reader that reported a wiring harness/module failure due to "chaffing". This chaffing caused a short that triggered the warning light and deactivated a key air bag safety feature. I was told that normal movement of the passenger seat moves the wires and causes the system failure. After consulting with my Service Advisor, the repair was explained as "installation of a new, modified (longer) wiring harness that allows for rerouting of the wires so that the condition is corrected" What alarmed me as a consumer was when I asked if they were sure this would fix the problem, the dealer told me they see it quite often and 99% of the time it is a problem with the original design and routing of the harness. From my perspective, this indicates BMW acknowledges this is a known problem impacting the safe operation of the vehicle. The repair requires removal of the entire center console and replacing and rerouting a newly designed wiring harness. The estimate for repair to the consumer is almost $1300 - making it likely that many consumers would delay this important repair. In my opinion, this engineering flaw should be the subject of a voluntary recall at the least.

- Odenton, MD, USA

Vehicle airbag/seatbelt warning light on 9/2022. Airbag (seatbelt) module replaced. Caused by condensation or leak due to BMW not sealing cupholders and placing KEY SAFETY EQUIPMENT directly under unsealed cupholders. I was told other modules likely damaged but airbags and seatbelt were first to go out. 2023 April/May - steering issues. Windshield wipers run continuously and cannot be turned off. Horn and turn signal also stopped working. Need steering column replaced. BMW said possibly also related to cupholder defect. I am concerned the unsealed cupholders are going to kill someone if airbags deploy unnecessarily or seatbelt/airbags fail. BMW should have not placed KEY safety equipment under unsealed drink holders.

- Louisville , KY, USA

I recently acquired a 2019 BMW X5. When I requested seat belt extenders as your web site suggests, "If you need a roomier belt, contact your vehicle manufacturer to obtain seat belt extenders." my dealer told me that they "cannot get them." I contacted BMW corporate customer services and while the gentleman I have been dealing with is trying and is very courteous, he can't seem to find any information. I regularly transport two people who cannot use the seatbelt and I am concerned for their safety.

- Sturgeon Bay, WI, USA