Brake lines rusted out. Apparently this is an issue for this year and many other model year vehicles. Considering the brakes stop the vehicle, this is a big safety issue, and very expensive to be fixed.

- St. Louis, MO, USA

Brake failure. Exiting parking lot onto city street brakes failed causing collision. Automotive repair: Brake line corroded. Lines to weak to repair. Replace brake lines per GM kit. Remove and replace all metal brake lines front and rear, per brake line kit.

- Chandler, IN, USA

Poor quality brake lines have corroded making the brake system fail hard braking, had line rupture due to corrosion, near collision due to brake failure

- Mountain Top, PA, USA

Rear brake lines burst while I was in motion. I was going down the highway and had to use the gears to slow down. They were corroded through. Same thing happened in 2016 with my fuel pump line corroded through. Was leaking while I was driving. Did not notice for a few days until there was puddles of gas where I park. Over the past few years my cladding has been falling off from rust through on the bottom secure points.

- Belle Vernon, PA, USA

Brake lines rusting out on these autos

- Poland, IN, USA

I purchased the 2006 vehicle used in Dec 2013. In 2014 the transmission went bad. In 2015 I replaced the transmission and brake pads & roaders.2016 replaced the fuel pump because it also went bad, replaced tires (normal wear), bought a new battery because it died. 2017 it needed two hub bearing and both front wheel hub replaced. This is an ongoing problem with this vehicle! I just found out my air bag sensor will need to be removed and replaced. All my money has been flushed down to this vehicle. I don't recommend anyone buying a Chevy truck.

- Omaha, NE, USA

Brakes failed coming to traffic light. Pedal went to floor. Went half way thru before truck stopped. Inspected and found rear brake steel line had rusted thru and had a hole. Brakes should not rust thru in only ten years,

- Manorville, NY, USA

Suddenly and without any warning the brakes failed while attempting to stop for traffic on the highway. The brake pedal went to the floor and it appeared that all braking had been lost. The car was navigated to the shoulder and the parking brake was used to come to a full stop. If the brake pedal was engaged and the parking brake released, the car would begin to move again. This appeared to indicate any redundancy in the system was absent.

- Fuquay Varina, NC, USA

Rusted brake lines

- Indianapolis, TN, USA

The contact owns a 2006 Chevrolet Avalanche. While driving approximately 25 mph and coming to a stop, the brake line detached from the vehicle. The failure recurred twice. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 152,000.

- Waterberry , CT, USA

The contact owns 2006 Chevrolet Avalanche. The contact stated that while driving 35 mph, she attempted to apply the brakes to avoid crashing into another vehicle but the brakes failed. The contact shifted into a lower gear in order to stop the vehicle. The vehicle was towed to the dealer for inspection where they stated that the brake lines needed to be replaced. The vehicle was not repaired. The manufacturer was notified and stated that they would cover the repair costs. The failure mileage was 44,000...updated 01/30/13 updated 2/5/2013

- Doyles Town, PA, USA