Tacada recall I bought my car had 121000 miles all a sudden I have no right tail light no dash lights an no passengers front orange light ther is no power going to fuse box under hood I called the dealership they stated my VIN had been fixed for that recal and it has not

- Belton, SC, USA

GM must not know this this has to do with the electrical wire harness inside of the engine block for the lights. For some reason the power is over writing the fuses and not blowing and causing small engine fires that could get out of control. I caught mine in enough time and put it out. A guy has to do with the right side and the left side in the fuse box being two separate entities of wires which is 7 + 7 equals 14 to control two different sizes. I was just wondering why and GM needs to know what's the sense of having a fuse box if the wires are going to override the fuse. And possibly catch fire or will catch fire it just a matter of an accident waiting to happen. I've been on youtube and found out this is a common thing to happen for Chevy Aveo will there be a 2004 through 2008. I'm letting you know about this concern because I do not want anybody to die from a car fire because GM.maybe not know about this that it's a big issue an accident waiting to happen. Sincerely [xxx] if someone needs to reach me my phone number is +[xxx]. thank you N.T.S.B for looking into this. Just really concerned because if the fire would have got out of hand I have my grandchildren in the car god forbid something were to happen to them. Information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Hopkinsville, KY, USA

Interior dash and console lights in-operative as well as the right tail light. Jesus christ, after seeing all of the people complaining about this our beloved no good for nothing governmental agencies should make GM responsible for the cost of repair for this obvious manufacturers or engineering defect. Or at least send out detailed instructions to the owners on how to fix this problem so they can take it to their mechanic of choice to get it fixed. The dealers obviously don't want to do anything about it. And they charge too much any how. Sincerely, george S.

- Lakeland, FL, USA

The contact owns a 2005 Chevrolet Aveo. While driving approximately 60 mph, the vehicle experienced a complete loss of power. The failure occurred without warning. The vehicle was towed to the contact's residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 128,000.

- Eagle Rock, MO, USA

When I went out to start the vehicle I had no dash board lights. Every other light system worked but I could not see the speedometer or the tachometer. All the fuses were intact. I then bought new bulbs for the entire gage cluster and they still are not functioning. I have looked up this problem on multiple forums and this is a very common issue without a solution other than "rigging" this system! this is unacceptable practice to allow this to go on without some sort of recall or replacement part available!

- Waynesville, MO, USA

The contact owns a 2005 Chevrolet Aveo. The contact stated that the headlights failed. The contact inspected the vehicle and found that the wiring harness connectors shorted due to overheating, which burned and melted the wires. The dealer advised that NHTSA campaign number: 14V261000 (exterior lighting) would only repair the drl module and it would not replace any additional failure caused by the recall. The contact also stated that the engine valve cover gasket was defective and caused the engine fluid to leak. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 80,000.

- Garry , IN, USA

I bought this car for in 2011 with 25,000 miles, first 6 months was great. But then the inside panel lights were going on and off. Door locks weren't working and I noticed a burn mark on my panel under steering wheels and took to a shop and he said wires were a mess under the dash. He fixed the door locks for me and 200 and something dollars still no panel lights. I tried to fix this problem but no one wants to touch the mess. I got a recall for the daytime running lights which I never had a problem with, so when I brought it in for that told them about the problem and nothing was done.

- Howard Beach, NY, USA

The contact owns a 2005 Chevrolet Aveo. The contact stated that the hazard lights, the tail lights, the marker lights and the instrument panel lights failed. The vehicle was serviced under NHTSA campaign number: 14V261000 (exterior lighting) however, the failures persisted. The vehicle was taken to an independent mechanic, who diagnosed that the S101 splice box burned out and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 80,000.

- Douglas, WY, USA

Within the first year of buying my Aveo I had to replace headlights 10X I kept taking the car in to get checked and they said it was fine, then one time they said just needed a better fuse (the changed it) worked for about a year then signal lights kept going out, then tail lights. Thought there was short took car in few times they said nothing wrong. Tired of taking the car in, I am a very busy person. So we have been dealing with this problem for about 6-7 years now the dash lights have completely gone out now and won't come back on, leaving us with 1 headlight, 1 tail light and only occasional rear signals. And always smells light wires burning. In Sept of 2014 we received a letter recalling the car for lighting problems and still nothing about getting fixed!!! this is only one of many complaints for this car.

- Ravenna, MI, USA

My 05 Aveo, is included in the GM recall#A140093/NHTSA recall#14V261(headlamp switch & drl). I have been experiencing issues with all of my external lights (my gauge cluster and shifter lights have been out). I was replacing every external bulb every few weeks to keep the lights on. That is not working. I am down to one headlight (driver side) working ' as far as running lights go. I have no taillights (brakelights work). I commute approx. 40miles each direction for work-all freeway. I made an appt w/Chevy, took the day off work so the car could be there all day.as I arrived to my appt the service writer told me there is not a remedy from GM yet so I will need to cover the cost. Eventually we went into the building to complete my write up, at that point I was told they were backed up on recalls so they may not get to my vehicle despite the appt. I reiterated the issue, he said okay, told me he would be in contact with me. At 3:30 he called, told me they hadn't had a chance to look at my vehicle but would get to it tomorrow. I took another day off work & left the car with them.next day, I called at 11am & I'm told they have yet to touch my vehicle & there are about 20 cars in front of me so they won't get to it today either.I could not leave the car another day, I told him I would pick it up. I immediately called GM explained the situation, their response was 'what do you want us to do about it'. I told them the car was unsafe and illegal to drive in this condition I needed it fixed. They told me they would contact another dealership and have them contact me. About 20mins later the dealership contacted me, gave me the same run around as the first dealership.this recall is 7months old, it took GM 10yrs to acknowledge it. This is unacceptable, I bought this car in good faith the basic functionality of the car would work and it does not and GM is not correcting the issue.

- Rancho Cucamonga, CA, USA

The contact owns a 2005 Chevrolet Aveo. The contact stated that burning wires fumes emitted inside the vehicle. The contact mentioned that the key released from the ignition while the vehicle was on and the radio failed to operate intermittently. In addition, the headlight malfunctioned. The vehicle was not diagnosed or repaired. The manufacturer was notified of failure. The approximate failure mileage was 95,000.

- Chocowinity, NC, USA

The contact owns a 2005 Chevrolet Aveo. The contact stated that the fuse burned and caused all of the windows to malfunction. The contact replaced the fuse, but the failure recurred. The vehicle was not diagnosed or repaired. The VIN was unavailable. The manufacturer was not notified of the failure. The approximate failure mileage was 86,000.

- Minot , ND, USA

The contact owns a 2005 Chevrolet Aveo. The contact stated that the interior and exterior lighting failed. In addition, the contact noticed that the center console and the day time running light module was melted. An independent mechanic was made aware of the failure and informed the contact that the vehicle was not safe to drive. The vehicle was not repaired. The manufacturer was notified of the failure. The manufacturer informed the contact that NHTSA campaign id number: 14V261000 (exterior lighting) remedy was being investigated. The approximate failure mileage was 90,000.

- Wellington, OH, USA

The contact owns a 2005 Chevrolet Aveo. The contact stated that the interior and exterior lighting failed to illuminate. In addition, the contact noticed that the center console in the instrument panel and the day time running light module was melted. An independent mechanic was made aware of the failure and informed the contact that the vehicle was not safe to drive. The vehicle was not repaired. The manufacturer was notified of the failure. The manufacturer informed the contact that NHTSA campaign id number: 14V261000 (exterior lighting) remedy was being investigated. The approximate failure mileage was 90,000.

- Wellington, OH, USA

The contact owns a 2005 Chevrolet Aveo. The contact stated that the headlight lights, the parking lights, and daytime lights failed to illuminate. The failure recurred several times. The vehicle was taken to the dealer. The technician diagnose that the main fuse box and wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 75,000. Updated 9/18/14 updated 02/05/2015

- Vernon Hills, IL, USA

The contact owns a 2005 Chevrolet Aveo. The contact stated that the instrument panel, interior and exterior lights were all inoperable. Also, the contact mentioned that the right signal light failed to function while the head lights were on. The vehicle had not been repaired. The manufacturer was made aware of the problem. The contact was made aware of a notification for recall NHTSA campaign number 14V261000 (exterior lighting). However, the VIN was not included. The approximate failure mileage was 75,000.

- Miami, FL, USA

Something under the dash burned out spewing white smoke into the passenger compartment of the car. Since that time Aveos. Wondering if GM Daewoo may have been using multiple substandard electrical components, the ignition keys are always hot after driving. Is there any potential for the ignitions going out/shorting out on these vehicles? would hate to park my car in the garage and cause my house to burn down.

- Edgeley, ND, USA

Running lights don't work half the time, clock doesn't stay on, mileage od scrambles, front end always had a shimmy.

- Kahoka, MO, USA

Multiple problems, started with daytime lights going out, clock going out and coming on with correct time, dealer replaced clock and said daytime lights related and should be fixed, it was not. Next all the instrument panel lights went out, repaired by dealer again at my costs. Next the tail lights and brake lights went out. Each time it was the wiring in the fuse box under the hood. All repaired at my expense. The dealer acted like they had no idea of the multitude of electrical problems with the Aveo but I think they've known, just read some of the blogs-this is a very common problem. It's frightening to drive this car just waiting for a fire. From May 2013 to present I continue to have these problems. The daytime lights and now the clock again going out. The whole fuse box needs replaced as far as I'm concerned but the dealership keeps giving me the runaround--- no more Chevy or GM for me.

- Earlysville, VA, USA

While I am driving I often smell burning plastic I could not tell where it was coming from. I called GM and the representative told me that it was coming from my dash behind my steering wheel. I also have noticed that after I have driven anywhere my key, after I have taken it out of the ignition, is really hot. The longer I drive the hotter my key becomes. When I called GM about this problem the representative told me that she can not tell my why my key got hot. When I asked her about the recall on my car that I had seen on the news she told me that it is not an official recall and she can not do anything about it. They also informed me that I can take it into a dealership to get it looked at but it would have to be out of pocket. I have talked to GM multiple times and they have told me only that the recall would be VIN specific, I don't understand how it is VIN specific if I am telling them that my car is not right. I really would just like my car looked at for the parts that are supposed to be recalled before something bad happens to me or my passengers. I also believe that since this is a known issue I should not have to take it to a dealership to get looked at and pay hundreds of dollars out of my pocket.

- Ogden , UT, USA