A month after I purchased the car with approximately 40k miles, I took the car in for an oil change at the dealership and was told there was a major leak in the left fuel tank and at the crossover tube. This leaking fuel is leaking onto the exhaust. It would cost at least $4,000 to repair. I can not afford this. It is too dangerous to drive. I have no other car. Supposedly, my vin number is 200 numbers away from being included in the recall for the same issue and that you have 43 pages of complaints about. Did I mention that the crossover tube is a backordered part because so many are needed because when you pull the current one out, it breaks and a new one is needed?

- Euless, TX, USA

Fuel tank leaking/fumes. Appeara to be crossover tube connection connecting the 2 tanks.

- South Lyon, MI, USA

In 2011 Chevrolet acknowledged an issue with the fuel system as the the attached letter states. I was not the owner of the vehicle in 2011 and since the issue was not elevated to an official recall it did not show up on the car fax report and I thus was unaware of this potential safety hazard. My car has now developed all the symptoms of the fuel tank leak with fumes in the car and gas dripping on the garage floor when parked. Although my car only has 30,000 miles the end date for GM to provide repair was August 11, 2011. The significant risk to passengers, the car, and my home when the car is parked in the attached garage is unacceptable as caused by a faulty engineered fuel modification in this model year. The fuel leak is both a safety and environmental risk and should warrant a recall and GM to mitigate the costs. Their liability for a faulty engineered system should not have a time limit.

- Pacific, MO, USA

Purchased the vehicle in 2015. That same purchased date I filled the vehicle with fuel. The following day my garage was totally covered with gas fumes. No tech could find the problem. On Feb 22 2023 while filling up, gas was pouring out the bottom left side. This is very dangerous. Come to find out that many others have had the same problem. There is a manufacturer defect of the gas tank housing tube. I cannot drive the vehicle because it-??s to dangerous and to costly to repair.

- San Tan Valley, AZ, USA

Drivers side fuel tank/system leak Leaking fuel in this area can/will result in a catastrophic fire which could lead to injury or death The problem just occurred but is a common problem for this generation Z06 Corvette The odd thing is no warning light, check engine light or messages displayed, just the smell of fuel and 18 inch puddle on the floor beneath the drivers side fuel tank. The fuel level according to the gauge is 1/2 tank.

- Rehoboth, MA, USA

I have owned this vehicle the last 6 years. When the amount of fuel is over one-half tank, there is an abnormal odor of fuel. When pulling into the garage, there's fuel leaking if over one-half tank. Once the engine is cut off the fuel leak ceases. To control the issue, I keep the fuel level at less than one-half tank. A certified local mechanic determined the fuel tank and crossover tube cross connector needed to be replaced. The vehicle has not been repaired. The mechanic stated the failure was related to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The approximate failure mileage was 26,500, when i bought the car. The mechanic stated that GM did issue a service bulletin around 2010 stating that GM would make repairs if the failure occurred within 10 years/100,000 miles. The local GM dealer will not repair my vehicle since it is out of time frame window. It's not fair to those who bought the car after the 10-year cutoff point. or do not drive these vehicles very much.

- Rocky Point, NC, USA

Left side fuel tank developed a leak- this is a problem known to GM- they offered warranty repairs for ten years-I purchased the vehicle after this additional warranty had expired- my complaint is this is a known defective part which I would replace at my expense however GM has discontinued this part- I feel that while GM will no longer cover the cost of parts and labor the replacement parts should be available

- Irwin, PA, USA

The vehicle has a fuel leak. I just purchased this vehicle a few weeks ago, it's 16 years old and has only 36,000 miles on it. It smelled terribly of fuel when I purchased it. I had the vehicle looked at and it has a fuel leak where the quick connectors connect to the fuel tanks. Anyhow, there's a special coverage adjustment which extended the warranty to 10 yrs/100,000 miles. I'm obviously outside of those parameters, but I feel that since the manufacturer admitted fault and stated that my particular VIN is affected, they should be held accountable for fixing a safety issue with my vehicle. How they got away with issuing a special coverage adjustment for such an issue rather than a simple recall is beyond me.

- Clarksville, TN, USA

leaking left fuel tank

- Roaring Spring, PA, USA

Have been in contact with 2 employees from GM, called and left voicemails and sent emails. No reply after it was requested that I take the Corvette to my local dealership for diagnosis. The ECL motor is not working property, causing the steering wheel to lock up and fuel supply to shut off. Sent attachment with diagnosis; however, no reply. GM indicated that this was previously fixed, but it obviously was not. My assertion is that there should not be a expiration date on safety recalls, and the ECL motor is not working properly creating a very dangerous situation. This happens every time that I drive the car. There have been several instances of me starting the car, pulling into traffic, and then the car shuts down. It has been very scary as I pull the key and wait 10 seconds to restart the car. Sometimes I have to do it twice. It is my contention that GM should be responsible for fixing this problem that was previously identified by GM as an issue/concern.

- Napa, CA, USA

Gas smell coming from rear of car after driving. No visible leaks, but leaking fuel vapor.

- Seguin, TX, USA

Gasoline leak from a crossover pipe connection connecting the two gas tanks. Drippig raw fwel onto a hot exhaust system and transmission. Commom problem on tnis year and model. Repair was covered for first 10 years and 100,000 miles by manufacturer. Still and issue with cars not repaired.

- Gilbert, AZ, USA

The fuel tank leaks when the engine is running. In 2010, this condition resulted in an additional warranty for the issue that expired in 2014, but I have a lower mileage car (less than 18,000 miles) so the issue did not occur until now. The problem emerged suddenly after fully refilling the fuel tank recently.

- Bellefonte, PA, USA

The contact called on behalf of an owner of a 2004 Chevrolet Corvette. The contact stated that the vehicle was taken to an independent mechanic due to a fuel leak. The mechanic determined that the plastic opening of the fuel tank, which connected a primary tank to the secondary tank hose, was fractured and fuel was leaking. The vehicle needed a new fuel tank and crossover components. The vehicle was not repaired. The vehicle was not taken to the dealer for diagnostic testing. The manufacturer was not notified of the failure. The approximate failure mileage was 39,000.

- Volcano, HI, USA

I bought a 2004 Corvette used with 67K miles on it. The dealership had only filled the tank to less than half full.,after my first fill up gas poured out from underneath, behind drivers side tire. I paid $ 16,500 for the car, so I took it back to dealer and they said they would repair. After about 10 days I went to dealer and noticed the car had not even moved. He said they did not know how to fix it and they had another dealership in another state that they would need to take it to. I left with the car unrepaired.is there anything I can do ? I believe it is a recall on the crossover tube and the recall has expired. Close to a $1500 to $1800 repair

- Marietta, GA, USA

There is a known leak in the left fuel tank. My vehicle has symptoms but was never fixed. Vehicle is 15 years old but only 76,000 miles.

- Deland, FL, USA

One day I noticed that my garage had a strong gas smell. Over time, I realized that if my gas tank was approx. Below 1/3 full it did not smell. Chevrolet informed me it was covered for 100,000 miles/10 years whichever comes first. However, I never knew a recall could have a time limit because obviously this is a safety issue. I wrote Chevrolet a certified letter describing my problem with no response. This is a common problem which is confirmed by looking at your site.

- Jacksonville, FL, USA

Gasoline vapors are leaking from fuel vent and transfer lines, creating an explosion hazard. The problem is more of an issue when parked allowing a spark to ignite the fuel vapors.

- Kings Mtn, NC, USA

Strong fuel smell after filling the gas tank. Goes away once tank is less than 1/2 full as read by the gauge.

- Puyallup, WA, USA

After filling the gas tank strong gas smell coming from fill area but no visible fuel leak the gas smell does not go away after days and many miles driven.

- Round Rock, TX, USA