10.0
really awful- Crashes / Fires:
- 1 / 0
- Injuries / Deaths:
- 0 / 0
- Average Mileage:
- 31,155 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
Fuel smell coming from gas cap area replaced the gas cap twice. Continue to have strong fuel smells in garage where car is kept. Started about one month ago.
- Douglasville , GA, USA
Strong gas smell after filling gas tank. This is a known issue on these cars and although it can develop at any time they only warranty the problem for 10 years. This creates a fire hazard. The attached service bulletin was just released by GM today: Special Coverage Adjustment 15682 Primary Tank Module Flange Fuel and Vapor Leaks Reference Number: N150682 Release Date: July 2016 Condition Some 2007 to 2009 model year Cadillac XLR and 2007 to 2013 model year Chevrolet Corvette vehicles may have a condition where a fuel odor is detected, fuel droplets appear below the left-hand fuel tank with fuel gauge level above 1/2, or a malfunction indicator lamp illuminates due to a leak path in the left-hand fuel pump module flange. Special Coverage Adjustment This special coverage covers the condition described above for a period of 10 years or 120,000 miles (193,000 km), whichever occurs first, from the date the vehicle was originally placed in service, regardless of ownership. For vehicles covered by Vehicle Service Contracts, all eligible claims with repair orders on or after July 25, 2016, are covered by this special coverage and must be submitted using the labor operation codes provided with this bulletin. Claims with repair orders prior to July 25, 2016, must be submitted to the Service Contract provider. Correction Dealers are to replace the left hand fuel tank fuel pump module. The repairs will be made at no charge to the customer.
- Bluffton, Sc, SC, USA
Purchased my 2012 Corvette Grand Sport used on 06/08/2023 and the first night parked in my garage noticed a seriously strong fuel smell. Have run down to half tank and parked it again and still have the strong smell. Dropped off at my local Chevrolet dealer for inspection. Research shows this is a common issue with this model year. Chevrolet has issued service bulletin15682 for this apparent issue. Mileage is only 66k but the bulletin has a year cap of 10 years from in service date. I am searching for information as to if this has been revised and if my vehicle is still covered.
- Granbury , TX, USA
We smelled gasoline from time to time since June of 2022 & could not see any leaks. Approximately October 22 2022 we contacted Premier Chevy Buick GMC in Beatrice Nebraska because the smell was really bad. After they inspected our car they said it had a defective fuel pump that had cracked & it was a known common problem with the Corvettes. They advised that General Motors would repair them at no cost because of a 10 year extended coverage. They then called us the next day to tell us that it would not be covered because it missed the coverage date by 2 months. We contacted Chevrolet and we were told that it could possibly be covered under good will. They sent the dealer paperwork & have been in contact a few times. Today we received a call from Chevrolet advising we would not be paid for the repair. This should have been a safety recall because of the danger! We were never told about the possibility of the fuel pumps cracking. When we picked up the car the dealer advised it would also require a wheel alignment too because the rear suspension had been removed to do the repair.
- Fairbury, NE, USA
The car has a strong smell of gas inside the garage and in the compartment of the vehicle after driving
- Simpsonville, SC, USA
I have a very strong gasoline smell coming from, inside and out side my car when it is stationionary. It seems to be worst, when I have more than a half tank of gas. The smell of gas is in my garage and inside my home when parked inside my garage. I made an appointment with the fremont Chevrolet dealer and dropped off my car two weeks ago at the dealer. My service adviser edger sat in my car and said to me he noticed a strong gasoline smell in side my car. Edger told me they would have to do a test to make sure the gas fuel module was the problem. They did a test and edger told me the fuel module was defective and they would fit it because there was a safety bulletin concerning this issue and my vehicle fell under the guidelines to be repaired free of charge. Two weeks later, my car is still at the dealership unprepaired. They told me they are still waiting for the part to come in.
- Union City, CA, USA
I have begun to smell fuel coming from the drivers side wheel well. It has filled the garage while parked and I can smell it coming into the car's interior while driving. I only have 24,000 miles on the car.
- Frisco, TX, USA
Sever gas smell occurs sporadically. When this happens, I can't drive with the top up or place vehicle in my garage. It went to Chevy the first occurrence and they did not inspect, but did say there was no problem. It has since had another 4 occurrences of gas smell. It is not overflow because the tak was less than 1/2 full 3 of 4 times this happened.
- Dallas, TX, USA
After filling the gas tank there is a noticeable smell of gas that's exists. When garage kept the smell fills the entire garage with a gas smell. The gas cap is fully secured and there are no noticeable leaks or puddles on the ground.
- Denver, NC, USA
When tank is 1/2 or full stationary, fuel smells and fuel leaks. Leaves spots in my garage and the smell in garage is disgusting. Fuel smell penetrates in vehicle cabin as well.
- El Mirage, AZ, USA
My 2012 Corvette grand sport has an increasingly strong fresh gasoline smell especially after filling up. When I start to slow down and then come to a complete stop the smell begins to permeate the passenger cabin. After reading online forums it appears to be a recurring safety issue/ hazard with the C6 generation Corvette. I do not know what it could be but to smell fresh gasoline is definitely hazardous.
- Mcallen, TX, USA
Fuel system leak around fuel pump, strong gas smell, fire hazard.
- Dallas, TX, USA
Defective fuel tank. Most owners have reported cracks in the fuel tank that result in gas leakage and strong smell of gasoline when the automobile is parked after fueling. First noticed 3 weeks ago after purchasing gasoline and returning to covered garage for storage. Gasoline can be smelled inside the residence.
- Cedar Hill, TX, USA
Fuel tank leak.
- San Angelo, TX, USA
Fuel smell, replaced fuel cap, that help a little, smell around fuel door, can't keep car in garage afraid to re fuel and drive help
- Gateway Fort Myers, FL, USA
Fuel smell coming from drivers side fuel tank. Notice fuel leak from high spot of tank and fuel residue on side of tank. Numerous owner complaints.
- Toms River, NJ, USA
When I fill the gas tank of my 2012 Corvette there is a strong smell of gas in my garage. I have read on several forums that this is a known problem with these Corvettes having a leak at the top of the gas tank. This leaking gas can get onto the exhaust and cause a fire.
- Maumelle, AR, USA
Stationary vehicle was filling enclosed garage with gas fumes. Source of problem was fractured high pressure 90 degree fitting in fuel pump atop left fuel tank. Entire fuel pump assembly had to be replaced. Photo attached showing fracture in fitting and showing the fuel pump part number. Contacted Chevrolet. No resolution.
- Rancho Mission Viejo, CA, USA
We recently purchased the car (two weeks ago) and the car smells up the garage of heavy gas fumes. We tried replacing the gas cap but it still happens. Seems to be at its strongest after gassing up the car. Gas fumes can also be smelled when the convertible top is down driving on the highway. I am seriously concerned that my garage is going to blow up since the water heater is just a couple of feet from the car or that the car will catch on fire while driving. I have been looking into this and seems many Corvette owners are experiencing the same thing. I'm feeling so discouraged for buying a Corvette, our dream car. Is there an recalls for this serious problem?
- Las Vegas, NV, USA
- Green Bay, WI, USA