10.0

really awful
Crashes / Fires:
0 / 1
Injuries / Deaths:
0 / 0
Average Mileage:
66,315 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 1999 Chevrolet Express:

Unsubscribe any time. We don't sell/share your email.

problem #6

Oct 152014

Express

  • 200,000 miles
The contact owns a 1999 Chevrolet Express 3500. While driving approximately 70 mph, the vehicle stalled without warning. The failure recurred on several occasions. The vehicle was taken to five different dealers. The technician diagnosed that the crank shaft sensor, oxygen sensor, fuel filter, distributor, coil spark plug wires, timing gearing chain, and fuses were faulty and needed to be replaced. The vehicle was repaired over five times, however, the failure recurred each time. The manufacturer was made aware of the failure. The approximate failure mileage was 200,000.

- Butler, TN, USA

Add Complaint
problem #5

Jan 082011

Express 8-cyl

  • 49,889 miles
I own a 1999 Chevrolet Express 1500 van with less than 50,000 miles on it. I purchased the van new in 1999. I now have a problem with the oil pressure gauge falling past 80 psi all the time. Even when the van is not running. I have tried two different cluster with the same results. I have not confidence that anyone at GM knows how to fix this issue. No resolution can be found.

- Overland Park, KS, USA

Add Complaint
problem #4

Oct 012008

Express

  • 80,000 miles
The contact owns a 1999 Chevrolet Express 1500. The vehicle was taken to the state inspection station. The technician observed that when the headlights are activated, the brake lights do not work. The vehicle was taken to an independent repair shop and they stated that the failure was related to the electrical lamp switch or 3-way socket. The vehicle has not been repaired. The failure and current mileages were 80,000. Updated 11/17/08 updated 11/21/08, .

- Georgetown , TX, USA

Add Complaint
problem #3

Sep 132004

Express 8-cyl

  • Automatic transmission
  • miles
While applying the brakes brake lights/turn signals and other electrical system parts failed to come on. Consumer replaced the fuse and bulbs on numerous occasions, but problem recurred. Consumer drove vehicle to dealer for inspection, but mechanic could not duplicate the problem.

- Rio Rancho, NM, USA

Add Complaint
problem #2

Jun 112003

Express

  • Automatic transmission
  • 68,000 miles
Wiring harness under fuse block at drivers feet not properly secured by S-clip and wires rub against access hole in sheet metal causing short in turn signal or 4-way flasher circuit causing fire. Vehicle is mark III conversion.

- Crawfordville, FL, USA

Add Complaint
problem #1

Jun 291999

Express

  • Automatic transmission
  • miles
Battery has been changed 3 times within the last year in a half. New batteries, that were replacements, were dying out as quickly as 2 days ago. Electrical juice drained after vehicle has been sitting a while. Problem hasn't been rectified.

- Leveland, TX, USA

Add Complaint