3.4

definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
38,486 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2003 Chevrolet Express:

Unsubscribe any time. We don't sell/share your email.

problem #3

Sep 012011

Express 8-cyl

  • Automatic transmission
  • 64,000 miles
The contact owns a 2003 Chevrolet Express 1500. The contact stated that after refueling, he noticed an overpowering fuel odor. The contact further inspected the vehicle and found that the fuel tank was leaking and rusted. The vehicle was inspected by the dealer and they advised the contact that the gasoline filler tube needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and they offered no assistance. The failure mileage was approximately 64,000. Updated 02/13/12

- East Pointe, MI, USA

Add Complaint
problem #2

Dec 262011

Express 8-cyl

  • miles
2003 Chevrolet Express fuel filler pipe leak: Gas filler tube rusted through and gasoline leaked every time I refueled. Corrosion holes caused fuel to leak and creating a fire hazard. This van has a left side rear cargo door. This is a similar complaint as: ODI id number : 10413214

- Saline, MI, USA

Add Complaint
problem #1

Jun 102011

Express 8-cyl

  • 51,459 miles
Gas leaking from fuel filler pipe onto inside of wheel well and ground. Examination reveals design of pipe assembly (metal pipe inside corrugated plastic tube), traps condensation and water around metal pipe guaranteeing rust and leaks. May be worse in high humidity regions but same assembly is open to water splashed up from road. This may only occur on cargo vans with left hand door option. Updated 08/11/11

- Arlington, VA, USA

Add Complaint