2.5

hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
59,000 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2003 Chevrolet Malibu:

Unsubscribe any time. We don't sell/share your email.

problem #1

Jun 112007

Malibu 6-cyl

  • 59,000 miles
I have had several issues with my car over the years. The first was when the fuel pump failed and my car stalled in traffic in 2006 and repair was $600. The intake manifold gaskets failed about 10 months later that was repaired at the dealer for $1200. I have replaced the engine twice ($600 each time) because of the head gaskets and too much oil inside the engine. Now I have a strong odor of gasoline inside my car when I start it up that lasts for about 15-20 minutes each day. I've replaced the ignition switch twice now and the gear shift does not lock properly. Now anti theft security light comes on often and I have to wait approximately 11 minutes to reset it before I can leave my location. The hood latch recently broke and now the wire must be replaced from the inside to the exterior of the car.

- Detroit, MI, USA

Add Complaint