4.0

definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
29,400 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2004 Chevrolet Malibu:

Unsubscribe any time. We don't sell/share your email.

problem #2

Apr 262009

Malibu 4-cyl

  • 23,800 miles
The contact owns a 2004 Chevrolet Malibu. While driving 35 mph the steering wheel began pulling to the right. The dealer inspected the vehicle and stated that the steering rack had excessive play and needed to be replaced. The failure also caused the driver and passenger side front tires to become worn which needed to be replaced. The repair cost was $657 since there were no related recalls or valid warranties. The wiring in the horn was also defective and it was repaired at the owners expense for $200. The manufacturer was not notified. The failure and current mileages were 23,800. Updated 11/15/10 updated 11/24/10

- Bronx, NY, USA

Add Complaint
problem #1

Mar 152006

Malibu 6-cyl

  • Automatic transmission
  • 35,000 miles
I own a 2004 Malibu sedan lt (80K) and a 2004 Malibu maxx lt (50K). Both cars have the clunking noise in the rack and pinion. I am issuing this complaint because I was told by the dealer that chevorlet has no repair to eliminate the noise. I consider any part of my steering a very safety sensitive issue. If it were only one car I would not be as concerned. But I believe it should be corrected (on GM's nickel of course) asap!

- Cedar, MN, USA

Add Complaint