The contact owns a 2005 Malibu maxx. While operating the vehicle, the passenger and driver side turn signals malfunctioned and would not illuminate. The vehicle was taken to lewis Chevrolet of garden city (1903 us 50 bus E., garden city, ks) where it was diagnosed that the headlight bulb sockets had melted and damaged the bulbs. The dealer stated that the bulbs could not be screwed out of the light bulb sockets and the entire headlight bulb assembly needed to be replaced. The vehicle was not repaired. The contact indicated that the failure occurred to both the driver and passenger side assemblies on multiple occasions. The manufacturer was not notified. The VIN was not available. The failure mileage was 160,000.

- Garden City, KS, USA

Ignition staying stuck alowing starter to continue to turn, day time no break lights, night time break lights stay lit up or flash on and off, fuel gauge drops to empty even when full bounces back and forth empty full, service air bag and check engine lights keep coming on even after they have been reset, cruise control will not engage, hard time to take car out of park even with brake depressed, lower gears on transmission will not engage into 3,2,1 speed, driver seat bracket broke in weld causing seat to be unstable, faulty ignition switch and more this car has less than 150 K on it 148 and some change, ,, air bag service light keeps coming on as well as check engine light, this car will not pass any state inspection, and even states with out inspection would advise that the car be recalled

- St.David, ME, USA

The front and rear turn signal bulbs continually burn out. They get so hot that both front orange bulb covers have holes burnt in them and the socket has discolored because of the heat. This began shortly after I purchased the car in 2005 but did not notice the holes until recently.

- Phoenix, AZ, USA

Took car to the Chevrolet dealership, for NHTSA id: 14V252000/GM safety recall: 13036, to correct the issues in the body control module which impacted the brake apply sensor. Now rear top brake lights no longer illuminate when the brake pedal is being pushed. Front low-beam headlights goes on and off while driving. Replaced both low-beam lights on 12/6/2014. Front low beam headlights still goes off and on intermittently. Also upon visual inspection, the turn signal blinkers have melted the yellow plastic inside the headlight. Brought back to the same Chevrolet dealership on 1/2/2015, for vehicle recall NHTSA id: 14V224000/GM safety recall 14152 to have the shift cable assembly and mounting bracket installed. I notified the dealership that I was having issues with the electrical system tied to the exterior lighting system. They could not provide me the reason for the fault.

- Philadelphia, PA, USA

The contact owns a 2005 Chevrolet Malibu maxx. The contact stated that the amber lights burned out and melted the plastic shield. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 124,370. Updated 10/10/14 the consumer stated the lights were not burned out. The plastic cove over the running lights melted and the right turn signal failed. The technician advised all light S needed to be replaced but, would not assist with the repairs due to the age of the vehicle. Updated 05/18/2015

- Laurel, DE, USA

I purchased this vehicle used and have had an electrical problem with the passenger headlights.going on and off.I have replaced the wire harness 7 times in 2 years.is their a recall on these cars for the headlight issues.if so I need to be notified asap before their is a fire in my car.I am a handicap mother that needs her car.

- Seaford, DE, USA

A 2005 Chevrolet Malibu maxx ls. 156964 mileage. The steering wheel emitted a clucking and a creaking noise while making a turn. A clapping repeated noise somewhere in the wheels has appeared also. Blinkers burned out too often and the plastics that cover them are melt down. If it stays more than 10 minutes stopped after driving a while, the temperature gauge start rising to the overheat point, but if you turn on the air conditioning it comes back to the medium reading measurement gauge.

- Katy, TX, USA

I purchased this vehicle yesterday and upon inspection last night I realized that the orange plastic dome that fits over the lamp for the passenger side blinker is unattached, when my father looked further into it he became aware that the wires are melted and so is the part of the orange piece that attaches, upon further research it seems that this is a problem that many owners of this model have encountered, is there a recall or something on this to have it replaced?

- Albion, MI, USA

The driver side headlight orange glass in side of head lamp it has a hole melted the top of the orange lens. Has a hole on top what can you do to fix that problem, it's seams to be only on the driver side of the car. It's on a 2005 Malibu maxx. Can you replace it under a factory warranty for us thanks. That's has to be a defective part on them cars please let me know what you can do for me thanks again.

- Spring Lake Park, MN, USA

I purchased my Chevy Malibu maxx January of just last year and I had to replace my front left head light thinking nothing of just normal maintenance and this was right around August of last year and it is now March of 2013 and I just had to do it again but this go round it seemed more like a short because it stopped working one night driving home from work which I drive a very busy highway at night and that next morning it was working just fine so me being the normal american person I think nothing of it but the following day it goes out fully and when I went to go change the light this time I noticed it had actually burned through the amber color cover of the bulb and also burned the socket up in the vehicle. But now get this about the same time last year my aux fuse began to blow over and over not thinking anything about it but now after reading all of these different situations I kinda wonder if the two situations could have anything to do with one another.

- Lehigh Acres, FL, USA

The contact owns a 2005 Chevrolet Malibu maxx. The contact stated that while parked, he noticed that a hole was melted into the amber turn signal headlight lens, exposing the housing unit. The manufacturer was made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 65,000. Updated 04/30/13 the consumer stated the amber lenses on the left and front turn signals showed black burn marks; signs of overheating or lack of ventilation from heat generated by the lamps

- Canadian Lakes, MI, USA

Turn signals burning so hot they explode, and melt not only housing for bulb, but also the socket in order to replace bulb is melted too. There needs to be a recall on this as I have found over 200 other complaints of people having the same issue!

- Hartford, WI, USA

Both the front turn signal amber bulb housing keeps melting to the bulb and also the light sockets, oem and after market ones.

- Evansdale , IA, USA

My 2005 Malibu maxx indicated that a turn signal bulb was out and when I went to replace the bulb I noticed, not only that the bulb itself was significantly burned at the socket, but also that the blinker plastic was substantially melted. I checked the other side of the car and even though that bulb is still functioning, the plastic blinker housing is starting to melt on that side as well. Clearly the bulbs are burning way to hot to be melting the plastic housing and I would assume since the bulb itself was burned that this is a larger issue of both potential fire risk and now water damage since the blinker housing is compromised.

- Madison, WI, USA

My cars headlights are dim at night and take a while to get brighter even though I have had the bulb replaced and the lighting components checked out. The windows won't roll down from any side of the car, a recurrence from two years ago. Also my doors won't unlock from the auto-unlock button that sits on the drivers side, this has been an issue for the past 2 years of my Chevrolet car ownership.

- Virginia Beach, VA, USA

2005 Chevy Malibu maxx front headlight turn signal bulb melted the housing surrounding the bulb with correct bulb replacement. Bulb keeps burning out and am concerned that this melting will result in safety issues or further damages to the headlight housing.

- West Salem, OH, USA

The contact owns a 2005 Chevrolet Malibu maxx. The contact stated that the front driver and passenger side turn signals failed. The contact stated that the lenses were melted on both sides. The contact replaced the lenses three times in the last nine months. The contact stated that the connection for the light bulbs were burned out but the light itself continued working. The fuse for the light bulb had not failed. The failure mileage was 84,000 and the current mileage was 100,000.

- Cumberland , MD, USA

I have owned my 2005 Malibu maxx for just over a year and have had to replace the front turn signal sockets, both driver and passenger sides, three times now due to melted sockets and amber covers melting down to the bulbs. Even though they are vented they do not stay cool enough to prevent severe electrical damage to the components. In replacing these components I have to wait a week until the parts are shipped out and am forced to drive with faulty equipment. I am unable to just replace the bulbs and have to constantly change the bulbs out before they melt to the sockets. This is a huge hazard as they can go out on me in the middle of driving in rush hour traffic putting me at a greater risk of injury. Please force GM to issue an actual recall on this issue and not just skate free on the service bulletin that has been issued. Thank you,

- Ashland, NE, USA

The contact owns a 2005 Chevrolet Malibu maxx. The contact stated that the turn signals failed intermittently. Neither the dealer nor the manufacturer was notified of the failure. The contact replaced the bulbs however, the failure continued to recur. The current mileage was 138,000 and the failure mileage was 108,000.

- Sheridan, AR, USA

TL- the contact owns a 2005 Chevrolet Malibu maxx. While parked, the contact noticed that the front passenger side headlight was burned out. The contact replaced the bulb but the headlight burned out a second time. The contact later noticed that the turn signal light wires were melted into the bulb socket. The vehicle was taken to an independent mechanic for diagnostic testing where the mechanic advised the contact that the head lamp assembly would have to be replaced. The vehicle was not repaired. The approximate failure mileage was 89,000. Kmj

- Dallas, TX, USA