This is the 3rd year in a row that i have to have the frame welded due to corrosion. I finally did an internet search and found this to be a severe problem for owners of Chevy Silverados. In my opinion, a truck frame should last longer than 100K miles. Why did the U.S. hold Toyota accountable when their truck frames rotted out a few years ago, but won't hold GM to the same standard? The dealership said there is nothing they can do about it, i'm hoping out government can. There are too many of these trucks driving around with frames on the verge of cracking or rear shocks falling off. Thank you

- Erie, PA, USA

This GM vehicle presents a safety risk to the public. The frame of the 2011 Chevrolet Silverado 1500 has prematutely rusted and corroded. GM fully understands and acknowledges this public safety risk only through a "Technical Service Bullitin" (service bulletin number 19-NA-255) which states that GM is aware of the lack of application of protective coating on this year and model. This "technical" concern urgently must be upgraded to a recall. The truck in its entirety and the public are at risk. The premature frame corrosion caused by the failure to apply protective coating which GM acknowledges, can, and presumably has, result in DEATH. The structural integrity of the entire vehicle should not be categorized as a safety bulletin. An incident due to faulty manufacturing resulting in death, is by definition a recall. Above mentioned vehicle does not meet minimum safety standards or poses an unreasonable safety risk due to defects that could harm consumers, hinder performance, or cause legal issues for the manufacturer.

- Flint, MI, USA

The frame is rusted and flaking to pieces. Have replaced tailgate latches twice due to rust.

- Mansfield, OH, USA

Frame is severely rusted through. Needs to replaced, truck has been garage kept. With less the 100,000 miles on it.

- Reading, PA, USA

This vehicle has a frame that is rusted far beyond what you would normally expect. The same problem is listed in other complaints here and elsewhere online. The passenger side running board fell off because the frame it was attached to was so badly rusted.

- Reisterstown , MD, USA

On August 24, 2023 I took my 2011 Silverado WT extended cab 4X4 to a local independent service facility for a required annual safety inspection. It has failed an annual vehicle safety inspection due to frame rust through. I am scheduled with the repair shop to repair this new rust section September 12, 2023. This is the second year in a row that it has failed due to frame rust through after having been repaired last year. The truck has 141,846 mile on it and should not be experiencing a frame issue requiring welding repairs. If I lived in a state that did not require annual safety inspections this could easily become a major safety hazard resulting in a crash with severe personal injury or death. GM should be notified and held accountable to provide necessary repairs and or compensation very similar to the Toyota Tacoma frame recall a few years back.

- North East, PA, USA

Truck has excessive rust and holes on frame, back wheel wells completely rotted out and bed is completely rusted out. Had to get covers for the wheel wells because it failed inspection due to the fact if someone bumped it they could be cut by the jagged edges. Have had over $6000 worth of frame work done in approximately 2021 and needs more. I will find receipts and send pictures. Chevy needs to be held responsible. Currently at dealer for airbag recall and inspection. There is no way it will pass. Huge safety issue and this is certainly not the only truck like this. How can Chevrolet get away with this" Toyota did right by frame issues. Why is Chevrolet not being held responsible" I've been to Mavis, Pocono Metal Craft and numerous other garages who all say the truck is so rusted it's worthless. When brought to the dealer where purchased, I was told there was nothing they could do. But when looking on line there is a recall put out in 2020 regarding Chevrolet frames and spraying the frame to prevent further damage. I was told it's due to the winters and what is sprayed on the road. That's not why this happened to thousands and thousands of people. I took great care of this truck.

- Tannersville , PA, USA

GM has a defective wax coating on the vehicle frames of nearly a dozen models of their vehicles, spanning at least 2011-19, which they knew can lead to premature rust and corrosion, causing the frames to fail much earlier than expected. The evidence I have gathered includes the detailed internal service bulletin where GM describes the defect, as well as texts and e-mails with GM, and a transcript of my conversation with the Chevrolet dealership. All of which suggests GM knew about this defect and is actively working to keep it from being communicated to owners, some of which would still be covered by the six-year frame warranty. All that evidence is included as part of the attached pdf document. In it's bulletin GM instructs dealers to fix this issue under warranty only if customers brought it up to the dealer, and then, only if it was brought up during the vehicle frame warranty period. However, for those customers that trusted their dealership to take care of their vehicle and to notify them of any major safety issues like premature corrosion or rust on the frames likely to cause failure, those dealerships remained silent, despite being aware this was an issue with these models and model years. I suspect those dealerships remained silent because GM-??s internal service bulletin clearly states that the bulletin only applies to customers who comment about rust or corrosion on their frame. I fortunately found out about this issue from a third party before my frame failed on the road. I've reached out to GM expressing my concerns I continue to get bounced between the dealer and GM, each saying the other is responsible. GM also failed to even acknowledge my greater concerns about the safety risk this creates. I've written a more detailed account of this story and have shared it out with several national news outlets in hope that someone will investigate further and determine if this issue has merit. Just hoping I can start sleeping again at night.

- Madison, WI, USA

The contact owns a 2011 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the brakes. The contact stated that the dashboard was also cracked. There was a dollar-sized hole in the dashboard. There were no warning lights illuminated. The vehicle was taken to the local dealer where they informed the contact there was a hairline fracture on the dashboard. The vehicle was not repaired. The air bag was previously replaced. The manufacturer was notified of the failure but no additional assistance was provided. The failure mileage was approximately 28,000.

- Leicester, MA, USA

Can poke through frame with a screw driver- frame is severely compromised. Afraid truck will buckle or if hit lightly will collapse. Truck has been well maintained with only 100,000 miles. Power train and parts all in excellent condition.

- Harpers Ferry, WV, USA

Rust through the frame. It appears that this is directly related to TSB PI0564K. The rust proofing failure of the vehicle has lead to rust causing holes in the frame of the truck. I have followed the Owners Manuel regarding cleaning of the frame during winter time. There is additional rust on the body rocker panels that are not structural. Repairs will be extensive in scope and cost.

- New Strawn, KS, USA

Frame is rusted out with only 102,000 original miles. Drivers side frame- can poke holes with a hand held screw driver going completely through frame. Frame is compromised. Personal note- mechanic by profession (18 years experience) in household has NEVER seen 10 year old vehicle no matter the care with rust this bad. This is a safety risk if an accident were to happen.

- Harpers Ferry, WV, USA

Frame is completely rusted on both sides, big holes. I use the truck for light duty use not a daily driver. Bought used with some known rust on the wheel wells. Had no idea rust would be this bad on frame. Have only had the truck for 3 years. Still owe on it and it seems unfit to drive.

- Grafton, IL, USA

My brother was putting a trailer onto my hitch and noticed that it was unstable. The factory hitch was rusted out thru the metal. Him being a mechanic he decided to put the truck up on the rack. My FRAME IS RUSTED COMPLETELY THRU!!! BECAUSE they did not rust proof it right to start. I could have been killed along with my GRANDSON whom I have custody of. No one knew my truck frame was rusted out. It's a beautifully kept truck in great condition. I was not aware of this issue of them not recalling a rustproofing error!!!! Omg. A 20k truck is worthless now. Who has to die to fix this!! There is no reason a truck frame should rust through in 10 years!!

- Export, PA, USA

The contact owns a 2011 Chevrolet Silverado 1500. The contact noticed that the front and rear driver-??s side floor mat was wet. In addition, the entire rear seats were also wet. The contact stated that water was entering the vehicle. The contact contacted the dealer and was informed to take the vehicle in to be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 135,000. The VIN was not provided.

- Plant City, FL, USA

Dash is cracking - portion close to the windshield- just like someone breaking a piece peanut brittle off - getting worse

- Montara, CA, USA

Dashboard is falling apart could cause shrapnel if airbags deploy

- Meriden, KS, USA

Dash has crack on both passenger and driver side

- Irvington, AL, USA

All 4 doors are rusting on the bottom edge (round seam). Cracks on dash on passenger and driver side starting from air bag and cracking outward. Oil pressure runs low and uses 1 quart of oil every 1500 - 2000 miles

- Chippewa Falls, WI, USA

Multiple areas on dashboard panels are cracking and breaking.

- La Marque, TX, USA