3.8

definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
32,500 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2003 Chevrolet Silverado 2500:

Unsubscribe any time. We don't sell/share your email.

problem #2

Jan 202005

Silverado 2500 4WD 8-cyl Diesel

  • Automatic transmission
  • 48,000 miles
After hearing grinding noises, I inspected rear brakes and found rear inner brake pads had prematurely worn out. After disassembling rear brakes found pads frozen (stuck) on pad guides (had to force off with hammer) which prevented pads releasing from rotor and caused uneven and premature wear of pads and destroyed rotors. New pads were purchased and upon installation realized even new pads would not slide freely on pad guides. Local Chevy dealer states they are unaware of any known problems. After searching numerous forums on internet and speaking with other Silverado owners found this is a common problem yet manufacturer does not want to take responsibility. To avoid this problem from recurring I had guide notches on pads machined slightly oversize than oem. So far no problems to report. If I can figure this out why cant GM.

- Memphis, MI, USA

Add Complaint
problem #1

Dec 102004

Silverado 2500 8-cyl

  • 17,000 miles
The rear disc brakes wear out prematurely. They wear completely down to the rotors before one is aware that brakes are bad. Contacted the dealer. However, they will not do anything to assist the consumer.

- Houghton, MI, USA

Add Complaint