10.0

really awful
Crashes / Fires:
0 / 2
Injuries / Deaths:
0 / 0
Average Mileage:
62,678 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2007 Chevrolet Silverado 2500:

Unsubscribe any time. We don't sell/share your email.

problem #2

May 072016

Silverado 2500

  • 107,000 miles
The contact owns a 2007 Chevrolet Silverado 2500. When the vehicle was turned off, the air conditioner blower motor remained activated. The contact stated that there was an abnormal smoke odor in the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure. The approximate failure mileage was 107,000.

- Fenton, MO, USA

problem #1

Jun 232009

Silverado 2500

  • 18,355 miles
2007 Chevrolet Silverado Z71, 18,355 miles still under factory warranty. Driving down the road today at 45 mph, A/C on high since it was 90 degree's out and out of no where the cab starts filling up with smoke and a burning plastic smell coming from the passenger side vents and from under the dash on the passenger side. I quickly pulled over shut the truck off, took the keys out of the ignition, popped the hood and noticed the A/C was still on as I was getting out. I looked under the hood seen nothing. I went to the passenger side opened the glove compartment and smoke started rolling. A passer by stopped and luckily had a socket set so I asked to use it to disconnect the battery to get the A/C to shut off. The fire department arrived the same time the gentleman got back from getting his socket set out of his car and the fire department disconnected the battery for me as I was throwing my belongings out of the truck in attempt to save them from a fire. The smoke stopped when the battery was disconnected and the A/C shut off. I contacted the dealer since the truck is still under the factory warranty, they towed it in and said that this is a common problem in 2006-2009 GM fullsize SUV's & trucks. The blower motors burn up. I asked why they haven't been recalled and the service guy said he wasn't sure. They replaced the blower motor, blower resistor and connector. The old parts were literally melted and were actually on fire. If I would not have thought to disconnect the battery the entire truck would have been burned or suffered serious water damage from the fire department. This could be life threatening to people who do not know to unhook the battery or people who panic in situations like this. I pray this does not happen to an elderly person or anyone else for that matter. GM needs to put out a recall regarding these issues. I have researched this issue on the web and found hundreds of these same exact complaints. Does it take a death before GM recalls these parts.

- Noblesville, IN, USA