Fuel sending unit cracks which lets raw fuel pool directly under backseat.

- Seminole, FL, USA

The fuel sending unit is poorly manufactured and cracks and leaks raw fuel directly under the back seat.

- Seminole, FL, USA

The fuel tank gasket failed. When fuel car to full the gas seeps out and puddles on top of access area under rear passenger seats and fills car with gas fumes. Only seeps out when you fill car to full

- Martinez, CA, USA

When the fuel tank is topped off the vehicle stalls 2-6 times until the excess fuel is burned off. This has happened on the road, in parking lots, intersections, etc. It causes total loss of power & power steering. Additionally, I usually have to shift to Park, Neutral, Reverse, Drive, Reverse, and then drive again in order to get the transmission to lock back in forward gearing. Causing me to have to additionally pull over, or stop, when/wherever the incident occurs.

- Pleasant Prairie, WI, USA

Car keeps stalling after I fill it up while driving and sometimes while in park

- Warner Robins, GA, USA

Gas tank hairline crack on fuel pump and bad gaskets.

- Manteca, CA, USA

Every time I fill my gas tank up the car oil light comes on and it stalls. Sometimes it does this 2 or 3 times then it runs ok until its time to fill car up again, then the same thing happens.

- Dover, DE, USA

When refueling my Chrysler 300C back to full capacity it will immediately stall out and shut off completely. The car will start right up again no problem, and continue to stall out while driving in traffic multiple times following until it burns off enough fuel to stop. I also have been smelling raw gasoline inside and outside the vehicle and the problem varies. The odor is highly potent coming from the passenger side rear. Never witnessed any fluid leaking underneath the car or noticeably in fuel tank gauge until this morning, it was leaking out from the trim panel underneath the rear passenger side.

- Richmond, KY, USA

After I refuel my car, it always smells like gas inside the cab. I recently looked to see where it is coming from, and found it on the passenger side back seat. The transfer pump has a puddle of gasoline on the back side of it. I did some research and found that other people who have this make and model car are also experiencing the same issue.

- Laguna Vista, TX, USA

Every time the vehicle is filled with gas, the engine stalls out no matter where it is being driven. Hyw or street/city road.

- Vandenberg Afb, CA, USA

Gasoline smell inside cabin traced to the gas pump/sending unit located below the floor mat directly beneath the rear passenger-side seat. A 1/2" deep puddle of gas forms at the rear of the unit which reappears after being soaked up.

- San Diego, CA, USA

Takata recall. My 2005 Chrysler 300C 5.7 started smelling like gas every time I filled up the tank.time past till I decided to take a look why it smelled like gas.furst thing to check was the fuel pupms.finding thst the passenger side had a budle of gas ontop of the fuel pump housing.I replaced the rubber gasket but that didnt help at all.so now I need to replace the fuer pump because it looks like it might have a crack somewhere.

- Glendale, AZ, USA

This car has a problem every time its time to fill gas tank car is running fine once I'm done with the filling up and I am leaving the gasoline station the car stalls with no warning or anything it has happen every time I fuel up one time I came to a red light when it was time to go on green it shut off on me and did not want to turn on after like the 5th try. I have tried calling Chrysler dealers but said my VIN number is not on the recall cars.

- Long Beach, CA, USA

On my car when the gas tank is auto filled all the way, until it clicks, then it stalls out while driving and is very hard to restart since the vehicle has to come to a complete stop before you can attempt to restart.this has happened at least 10 times. The last time was while attempting to make a left hand turn onto route 29, within minutes of having left the gas station, and I lost control of my steering due to the fact that the car was not running any more. I was lucky I wasn't hit by another car when coasting it partly off the road. Since then, I have learned, as long as I don't fill the tank all the way full the stall outs don't happen.

- Clarksville, MD, USA

The contact owns a 2005 Chrysler 300C. Immediately after the contact refueled the vehicle, it stalled several times before eventually operating normally. The contact indicated that the failure occurred regardless of the amount of fuel inside the fuel tank. The failure was not diagnosed or repaired. The manufacturer and local dealer were not notified of the failure. The failure mileage was 140,000.

- Kilgore, TX, USA

Car shuts off after filling, was just every once in a while starting 2 years ago, but now it shuts off after every fill up, and when it shuts off then there is no power steering. Will shut off as soon as I leave the gas station, and will continue every time I slow down, for approx.10 miles. After being rear ended in traffic at a stop light, due to I started to move and the car shut off, but the person behind me didn't realize my car quit and lightly hit me. I have learned that I can no longer fill up at any gas station, I have to fill up where I know I can just drive without slowing down for about 10 miles. The car will still shudder like it isn't getting gas, but have been able to keep it from shutting off totally and trying to avoid being rear ended again. I worry what damage is being done to the rest of my car when it shudders like that though. I see that there is a lot of other 2005 300C owners having this same problem, but no recall has happened yet. Hope the recall happens before someone gets killed due to this malfunction.

- Jackson, GA, USA

I am experiencing stall outs after fueling my car up.I entered the highway and the car stalled out while traffic is burling on top of me and I immediately put the vehicle in neutral and restarted the vehicle which didn't start right away and nearly created an rear end collision of my vehicle.after it started the car stalled again and started jerking before it stalled again..this is definitely a heart stopping experience and I am unaware if Chrysler has a recall about this terrifying situation..I've purchased this vehicle new 10/2004 and never experienced this problem until the spring of 2017..my vehicle now has 167,000 plus miles and I'm very concerned about this existing fuel problem which can cause a major accident which I have almost became a victim..

- Gwynn Oak, MD, USA

This isn't the first time the car just shuts down when U fill the gas tank all the way up. I filled the tank and proceeded to drive and merge on to highway and without any lights or warning the car just shuts off on the highway while doing 65. I lost power and the vehicle is had to control. It took a second to start back up in the middle of the highway. This only happens when I fill the tank all the way up. It's an issue with the gas tank or a valve getting stuck open/closed in the tank. I filled the tank again and just waited at the gas station to see if it would happen again and it did. I waited about 2 minutes and the car shut off while sitting at the gas station.. I left the gas station as soon as I turned out of the gas station the vehicle shut off 2 more times. I have to either fill my tank to 3/4's a tank or purposely burn gas when on full to not have this happen again.

- Laurel, MD, USA

This car will stall at completely random intervals. It has done it at speed, on acceleration, on deceleration, at stops. Occasionally the cruise control will not function correctly. The car will also spit, sputter and buck at speeds above 35mph. When this happens, there is a total loss of power steering, brakes, etc. In order to restart the car, it requires being placed into neutral or park, and trying at least 3 times before engine will run again. The car will usually continue to stall 3-10 times. On returning to "drive" the car will usually stay stationary for another 5-10 seconds before surging forward. Reverse does not have this effect. Car has been checked by several mechanics, who can pull no codes, and don't seem to have any clue what is causing the intermittent issue. It is very dangerous situation, as there is no warning the car is about to stall, and there is no pattern to when it will stall. In googling the issue, I was able to find the Chrysler campaign X53 extended warranty on "some" 2006 300cs, but when I called the Chrysler dealer to check my VIN, I was told my car is not covered under this known defective gas tank. The message boards have many instances of people describing this exact issue for this exact car. This a seriously life threatening issue.

- Brandon, WI, USA

Engine stalls after fill up. Usually stalls 3 times at low speeds. Could be dangerous if it stalled when merging into traffic.

- Mansfield, OH, USA