For some reason my caravan has started leaking gas from on top of the gas tank. not sure why, but I heard the was a recall but it was over 15 years ago so you people don't list anything older. i've only had the car a couple months, and also having a catalytic converter problem as well..

- Oroville, CA, USA

Several times in past year after filling the gas tank, shortly after driving away from gas station the engine misfires and stalls. This has been a safety hazard when merging into traffic. This problem is widely noted in forums on the internet for Chrysler minivans, for many other model years including the 2005. The best explanation being given (link follows) is that the vapor/liquid separator valve on top of the fuel tank has failed, a part that is not replaceable--the entire fuel tank must be replaced. Some report it happened when their minivan was brand new. https://ricksfreeautorepairadvice.com/engine-stalls-after-filling-tank-chrysler-minivan/

- Tigard, OR, USA

Repeatedly the vehicle will loose power and stalls out after filling the tank with fuel. It will occur within less and 1/8th of mile after pulling out of the gas station. The vehicle has done this repeatedly in inopportune situations, like traveling up a steep hill and at a busy intersection. We are original owners and had never had an accident with it. It has just under 120K miles on it.

- Westford, MA, USA

Car will stall a few minutes after filling the gas tank. It will stall in the middle of driving on the road and will not restart for 20 minutes causing a dangerous situation.

- Spring Valley, NY, USA

Factory fuel pump is cracked, wright on the connection to the fuel line, its a hair line crack,

- Los Angeles, CA, USA

I just acquired this vehicle. I understand gas 6 recalls based in the NHTSA. Doors read model 2004. I called Chrysler Dodge dealer in hemet, California and the service receptionist stated there is nothing to do that are no recalls for this van. Please help. The light engine is on. The power train kicks sometimes (drags) suddenly. And I see the 6 recalls applicable to this model

- Hemet, CA, USA

I have a fuel leak underneath from the top of fuel tank. I believe it is coming from the fuel pump. Leaks when engine is running only. Does not leak when auto is not running.

- Slidell, LA, USA

My van along with many many others shuts off after refueling sputters runs like garbage almost causing me to get into a accident pulling out of a gas station on a rotary today

- Randolph, MA, USA

Have fuel smell at back middle of van, found fuel leaking at middle of fuel tank, replaced fuel line connected to fuel pump output connector. Did not stop fuel leak, found cracked fuel pump at the output area. Leaks as long as the high pressure side of fuel pump is pressurized.

- Canyon Lake, TX, USA

Noticed gasoline smell every time I stop/park car & get out. After few weeks, checked underneath van & saw gas slowly dripping from about middle of gas tank. It was running down the side fromn the top of tank. Stopped drippiong after stopped for few minutes, but found out that while van was running it dripped constantly. Googled this problem & other are having same problem with cracks in fuel pump. This could be a serious problem with a spark/hot exhaust pipe/muffler close by.

- Hagerstown, MD, USA

2205 Dodge Grand Caravan stalls after refueling. Multiple occurences. Happens in motion straight line, while accelerating.

- Spartanburg, SC, USA

The contact owns a 2005 Dodge Grand Caravan. After refueling the vehicle, the engine started and stalled. The oil warning indicator illuminated on the instrument panel. The failure was intermittent. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 105,000.

- Clarksville, TN, USA

Smelled raw gasoline smell outside of vehicle after running vehicle. Occurred on two occasions on Aug 23, 2016. Looked under vehicle on 8/30/16 and saw and felt liquid fuel on fuel tank in vicinity where fuel pump goes into gas tank. Leak occurs when ignition is in the on (running) position. Did online research and found that others have had same problem with fatigue cracks in plastic top of fuel pump, where fuel hose attaches. When key turned on and fuel pump is pressurized, fuel begins to leak through the hairline crack. Dangerous, as muffler and exhaust pipe are located less than one foot from the source of the leak!! took vehicle to repair facility, who determined fuel pump module was leaking as described above. Cost over $500 to have new pump installed, even though the old fuel pump was still working, though leaking.

- Nevada City, CA, USA

Every time I fill up the vehicle with gas, it stalls every time within the first few minutes, last week daughter was merging into traffic when it happened and almost got rear-ended. This has been happening for a while now. Last winter I wasn't able to fill the vehicle, the pump kept shutting down but that went away after the weather warmed up.

- Maple Shade, NJ, USA

Van stalls after fueling. Every time you fill up the van, the van will stall for no reason. It will restart within a minute or 2. it will then have no problems until the next fill up. Reading reports on the web, this is happening on all Dodge and Chrysler vehicles even causing some to stall on train tracks. Never had a problem with the van until I hit around 100K miles. All other reports on the web are identical. Chrysler Dodge should recall before someone dies

- Acworth, GA, USA

2005 Dodge Grand Caravan stalls after refueling. This issue has been happening for about 3 years when the fuel tank gets low and then refilled. Most of the time the stall happens shortly after refilling and I come to a stop light or stop sign. There have been few occasions where the Caravan has stalled while in motion while travel under 20 mph. I can usually restart the Caravan immediately after the stall. The only solution from online forums seems to be to replace the fuel tank and purge the valve and charcoal canister of any raw fuel. Seems like a common problem within similar models.

- Fort Worth, TX, USA

Car will stall a couple of times after filling up tank probably will go away after driving a couple of blocks

- Patterson, CA, USA

Everytime the van is refueled, it will stall on acceleration. This occurs for the first few minutes after refuel and then the van returns to normal operation. The problem is the failure usually occurs when pull out on the road because that is the first point of acceleration.

- Frederick, MD, USA

Last night - for the 4th time now - after filling the tank at the gas station, my car just died. The first 3 times it was when I stopped at the stop sign leaving the gas station parking lot. Last night, it was after I was out on the main road and in heavy traffic. It was stop and go rush hour traffic, so I was thankfully only going approx 15-20 miles an hour. Power steering was lost, brakes were practically non existent. Barely managed to pull off into a parking lot and was able to set the parking brake to finish stopping. Once stopped and in park, was able to start it right back up. Every time this has happened it has been right after fueling up. I never thought much about it the other 3 times, but this time was different, and very dangerous. I was almost hit from behind because I instantly lost power, then I almost hit another car to my left because of the unexpected loss of power steering. I could hardly manage to get into the parking lot and almost hit the curb/sign/another car. Was scared to drive home the rest of the way. Now after reading the other posts here, I'm afraid to ever get gas again!!! this is unacceptable Dodge...you obviously know about this problem and do not care about your customers. Well, this is one customer you will never have again. I'm in the market for a new car, and guess what will not be sitting in my driveway ever again?

- Twin Falls, ID, USA

Filled up with gas, drove about 2 mins, slowed to turn left at intersection with stop light. My minivan then stalled while in the middle of the intersection. This is the third time the car has died after fueling. I replaced my battery and alternator upon recommendation by local auto parts store, but the problem persists. Dodge dealer service technician says "it's a common problem and being investigated" and said I need a new gas tank due to a bad valve and recommended replacing the fuel pump and filter while doing the maintenance, over $1000. I dread getting gas and won't let my wife drive the kids in the van anymore. It's a death trap waiting to happen.

- Virginia Beach, VA, USA