10.0

really awful
Crashes / Fires:
0 / 1
Injuries / Deaths:
0 / 0
Average Mileage:
0 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 1997 Ford Aerostar:

Unsubscribe any time. We don't sell/share your email.

problem #2

Jun 152005

Aerostar 6-cyl

  • Automatic transmission
  • miles
My 1997 Ford aero star van produced a puff of smoke from the steering column near the ignition switch. I took it to my mechanic whom checked the recall notices and found one resulting in an electrical overload short circuit and overheating in the steering column electrical components. When the key was turned off it subsides. Since this occurrence the instrument panel has not worked and blew all fuses, the fuel pump does not turn on with the key after multiple attempts it engages some times. The Ford dealer did the recall work but did not fix or examine the steering column or the components that burned or over heated as a result of the overload. [xxx] updated 07/19/2012 information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6)

- Tacoma, WA, USA

Add Complaint
problem #1

Nov 231998

Aerostar

  • miles
Smoke occasionally appears coming out from around the dash panel by the heating and A/C controls. Smells like electrical components burning or burning wire insulation. Smoke goes away after 5-10 minutes. Doesn't seem to matter if heat, A/C or just the fan is on. Is an intermittent problem. Dealer states they could not find the problem or duplicate gripe.

- Virginia Beach, VA, USA

Add Complaint