The rear hardtop panel on my 2022 Ford Bronco has developed serious cracking and surface separation after only three years of light, garage-kept use. The fiberglass is fracturing near the seams, exposing the underlying material. Water is now visibly collecting in the openings, which will lead to internal moisture intrusion, mold, and eventually corrosion of structural components underneath the hardtop mounting area. This poses a serious long-term safety concern, especially in the event of rear impacts or rollover situations. A Ford dealer inspected the issue and submitted a warranty claim, which was denied. The Ford representative acknowledged the damage but said they could not act without a recall or broader investigation. No warning lights or messages appeared; the issue is external and has progressed gradually. The damage began well before my bumper-to-bumper coverage expired, but has recently worsened. Ford-??s own General Service Bulletin GSB 23-7174 lists rear hardtop panel cracking and edge delamination as warrantable conditions. My panel clearly fits those descriptions. Still, I was quoted nearly $10,000 for a full replacement, which is unreasonable. This is not an isolated case. Many 2021-?"2022 Bronco owners have posted identical problems online. Ford is clearly aware of this issue-?"which is why they issued that bulletin-?"but is denying claims unless pressured through complaints. I believe this is a materials or manufacturing defect and ask NHTSA to investigate this clear and ongoing failure.

- Montgomery, TX, USA

The hard top of my 2022 bronco has started to crack and Ford will not view it as a defect even when provided with pictures I know other bronco owners that also have this defect. The back of my hardtop has never been removed and that-??s where a lot of the cracks present

- Simi Valley , CA, USA

The vehicle currently has three active recalls with each not having a remedy as of to date although one I was notified of 7 months ago. I have already had to have a faulty fuel pump repair within the first month or so of onset of purchase where vehicle just lost power and died on side of the road and had to be towed. Then had to fight the dealership and write complaint to Ford after having defective camshaft which took multiple attempts and documentation for FORD and the dealership to repair properly. Vehicle would shift between 2wd/4wd/AWD randomly while driving. Then I had been notified about a windshield wiper motor recall that just dropped of out the system before attempting repair. So never had that update ran or problem addressed. Now I have three other major safety recalls. Definitely a LEMON. Need Ford to stand behind their vehicle. I pay way too much not be safe. None of these failure or problems provided any prior warming indicators.

- Knippa, TX, USA

Random cracks to my hard top with no damage

- Corpus Christi , TX, USA

The rear backup camera intermittently is black or has the last backup image being shown. I took my Bronco into the Ford dealer where nothing could be found wrong after having my Bronco for two days. I was told if the backup camera malfunctioned happened again to take video and pictures of what happened, then bring into the dealer that day if the dealer was open so they could see if they issue remained. I did and was told by another service representative the service department couldn't take a look at the vehicle today a Friday and to bring it in Monday. When I got back my Bronco and restarted the rear camera was functioning correctly. I do have pictures and video of the last image remaining when I placed my Bronco in reverse. One image on the left side of the IMG_5347.jpeg attached shows the image of the reverse image prior to the current backup image. The right side of the picture shows the actual image in reverse. The image IMG_5348.jpeg shows the mileage and the vehicle in reverse. The pdf documents the Ford dealer service department could not find the issue that happen prior to 09/04/2024 service date. I have a video of trying to use the backup camera with the previous image shown in left side of the screen showing what happens. It doesn't happen all the time. If you turnoff vehicle and restart the issue goes away.

- Conroe, TX, USA

The vehicle-??s back-up camera completely malfunctions about 20% - 30% of the time making it completely impossible to see anything behind the vehicle when backing up. Sometimes, when the vehicle is put into reverse, the display screen will be completely dark, other times the image freezes on a load up image or screen and there is no display of what is behind the vehicle, and worst of all, other times the display will lock on the first image from the rear facing camera and not show real-time video of what is behind the vehicle, making the driver think it is safe to back up when it may not be. The vehicle has been brought to two different Ford dealerships three different times over the last two years regarding this problem. The first time I was told the problem had been addressed. The problem continued to occur. The second time, I was told the issue could not be addressed at that time. I was told that Ford Corp was aware of the problem but they did not have a fix available at that time. I was told that Ford Corp was working on software enhancements that would be available sometime in the future that would address the issue. The problem continued to occur. The third time I was advised the problem could not be addressed at that time and -??Ford is working on additional software enhancements which are expected to be delivered over-the-air (OTA) by late Q4 2024-?? and -??Software will update automatically if vehicle connectivity is enabled in the vehicle-??s settings.-?? The problem continues to occur, so much so that I have several recorded videos of the problem occurring.

- Anaheim, CA, USA

We were returning home from a trip. We pulled into a gas station to get gas. As we pulled up to the gas pump, we smelled smoke and then saw smoke and fire. We immediately turned the Bronco off and jumped out. Shortly after, the whole engine compartment area was on fire. Luckily, there was a tow truck in the parking lot and was able to drag it away from the gas pumps. I had gotten an oil change prior to our trip. There were no warning signals, lights, or indication of temperature or oil problems. I had intermittently smelled gas while driving during our trip, but my wife said she did not smell gas on the passenger side.

- Conroe, TX, USA

UNKNOWN grinding sound when at idle or in/out of gear ( manual transmission) sounds like transfer case. Other owners of 2021-2023 broncos regardless of trim levels have heard this sound with their broncos as well (manual trans)

- Grants Pass, OR, USA

My vehicle was parked but left running. I went around to obtain my daughter from the rear passenger. While holding her I leaned in to the passenger front and pressed the button to turn off the vehicle when it suddenly began to roll in reverse. It's unknown to me what could have caused the incident but something failed/malfunctioned. Something within possibly the gear shifter glitched when power was cut off?

- Dearborn Heights, MI, USA

Ford recall 23C05 states that the Accessory Protocol Interface Module software update is still incomplete. This was issued in March of 2023 with an expected remedy by the end of 2023. One month later, I still have not received a resolution to this issue. I cannot use this vehicle for my business because of an open recall. I feel that Ford has an obligation to resolve this matter in a timely manner and that time has past.

- Myrtle Beach, SC, USA

Issues started at 9000 miles Doors/windows shaking badly, worse over street imperfections. Cannot roll windows down half way as the shaking is to point of breaking, glass has potential to shatter endangering driver and passenger Noise in rear of vehicle, possible the roof panel or liftgate Issues were Inspected by 2 Ford dealers on 3 separate occasions Temporary adjustment made to doors/windows until the fix is in - 2023 Rear noise ongoing.

- Yonkers, NY, USA

Drivers side window extreme rattle when partially open, risk of window shatter while driving vehicle over bumpy terrain at moderate speeds 30-50 mph.

- New Boston, MI, USA

The transmission has a grinding or scraping noise when clutch is not engaged. No warning lamps or messages. It has been below 50 degrees, but even after the day warms, the noise is still there. I have not taken it to the dealer yet as there are many reports from other people with the same issue and all have been told it is "normal" when it gets cold. This does not make sense. I have had manual transmissions in the past and have never heard this type of noise when it was cold.

- Little Rock, AR, USA

The hard top convertible is leaking in multiple areas. Primary location is behind the second-row drive side between trunk area and back seat. Other area is between the two front seats in the center. The gaskets have been replaced one time already and its back at local Ford dealership a second time for same problem. Dates for repairs include 8/9/23 and 9/11/23.

- Wilmington, NC, USA

The whole truck shut off, dashboard, stereo, engine, while driving and in gear. Had to drift over safely to a stop to restart the engine. The safety of my children and myself were in danger due to this catastrophic failure. No warning lights, no previous problems.

- Fort Worth, TX, USA

The soft top on the 2022 four door Bronco does not properly latch. I know earlier years and some 2022s were recalled for this but mine has not been recalled and it needs to be addressed. Also the back up camera and 360 cameras do not work

- Glen Burnie , MD, USA

Frequently, due to a software glitch recognized by Ford, the steering wheel controls fail to change the audio preset. When this happens, the driver must take their eyes off the road to adjust the radio station, which can be distracting. The problem will persist until the vehicle is restarted, and is often only noticed while driving.

- Lamoine, ME, USA

transmission makes horrible noises

- Palmdale, CA, USA

Vehicle deemed by dealer as "unsafe to drive"... I sent you complaint about a month or more back with no response....the 2021, 2022, 2023s all are being received brand new with noise starting shortly after....several hundred of us brand new 7 speed manual transmission Bronco owners are experiencing this..... Dealers are telling us drive them.... Mine got to the point the gears began locking up, grinding and the engine randomly high reving which could all of cause me to get into an accident. A recall needs made on these. Someone is going to get hurt trying to make a turn in traffic and Lossing power to get nailed by oncoming traffic. Mine now sits with the dealer and parts are back ordered till March... TSB 22-2371 which ford released for this has been unsuccessful on every documented repair. Noise returns. New transmission noise also returns. Do something and get these vehicles recalled so ford address the true safety concern that's being ignored. Mine is a great example of what's going to happen to everyone's

- Westlake, OH, USA

Soft top leaks when it rains. Contacted local Ford Dealership and they have advised a design flaw from Ford, that they cannnot fix. Contacted Ford Motor Co. to advise of problem. They claim they are unaware of such issue and no fix at this time.

- Roseburg, OR, USA