10.0

really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
1 / 0
Average Mileage:
14,010 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2004 Ford E-350:

Unsubscribe any time. We don't sell/share your email.

problem #2

Jul 082008

E-350

  • 28,000 miles
2004 E-350 Ford diesel van..in 06 fuel tank delamination Ford replaced tank..08 fuel tank delamination again @ 14000 mi. Cost to me $2200. Dealer said Ford will not admit to a tank problem and could not assure me the delamination problem has been corrected to date..I can't afford $2,200 every 14000 mi. I use only hess diesel fuel. I know I am not alone with this problem, the dealership said they do at least two a month. This is a dangerous condition..the truck loses power and stalls.

- Islip, NY, USA

Add Complaint
problem #1

Sep 242005

E-350 8-cyl

  • Automatic transmission
  • 20 miles
2004 Ford wagon E350 with floor lowered by vantage mobility int. For handicap people. During stop and go driving like traffic jams while pulling a trailer the floor between front seats gets more than hot enough to burn your foot. Sliding door opener has broken 6 times leaving the door free to slide open and shut. I keep a bungy cord to tie it up but interior lights come on and off when using bungy cord. The original latch by Ford was removed to install the door opener. Split drive shaft installed to make room for under vehicle lift by braun Corp has a low roar to it. Bicycle type chain for the sliding door opener at wheelchair lift drags across part of door jamb.(no pulley or sprocket). Paid $48,000 for this new 2004 model in April, 2005 I'm asking for my money back. Please help us.

- Orange, TX, USA

Add Complaint