2005 Ford Escape. Consumer writes seeking reimbursement for vehicle repairs. The consumer stated the computer control module caused the coils to fail. The consumer stated the there was a tsb for the failure and believed this should be a recall. The vehicle had to be pushed out of the highway and into a parking lot.

- Duvall, WA, USA

The contact owns a 2005 Ford Escape. While driving at various speeds, the engine stalled. The vehicle was taken to a dealer, who diagnosed that the PCM needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 123,000.

- Mesquite, TX, USA

The contact owns a 2005 Ford Escape. The contact stated that the vehicle stalled without warning. The vehicle was towed to a dealer, who diagnosed that the PCM needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was not available.

- Toledo, OH, USA

Letter from senator casey on behalf of constituent re concerns about her 2005 Ford Escape the consumer began having problems with the vehicle. When she took the vehicle to her mechanic, he hooked it up to the computer and it gave him a reading that the cylinder was not firing, but he thought there was more involved. After further examination, it was discovered the PCM was damaged. The PCM was sent to another establishment for repair. The technician at the establishment informed the consumers mechanic that Ford recommended that all six coils and six spark plugs be replaced. The PCM was returned to the consumers mechanic. The vehicle needed to be reprogrammed at the dealership, but the consumer was unable to get an appointment right away. The mechanic called the consumer and informed her, that instead of the original circuit B misfiring, circuit C was misfiring. The PCM had to be sent back to be rebuilt again. All of the coils and spark plugs had to be replaced again. After the vehicle was reprogrammed again, circuits C, D and E were misfiring. The coils and spark plugs had to be replaced for a third time. The consumer stated the problem is due to faulty engineering. The PCM was placed behind the engine compartment where a lot of heat was generated from the engine and it interfered with the frequency of the PCM.

- Williamsport, PA, USA

Email from senator on behalf of constituent re concerns with her 2005 Ford Escape automobile (design of the powertrain control module computer). The consumer stated while driving, all the lights on the dashboard illuminated. When she arrived at the repair shop, the mechanic performed a diagnostics test where it was determined that a cylinder was not firing. After further examination, it was discovered the power control module was damaged.

- Williamsport, PA, USA

New 2005 Ford Escape has numerous issues that are not being addressed by multiple dealer shops: - intermittent stalling, similar to problem causing recall of 2001 - 2003 Escapes. Car will suddenly lose power, resulting in loss of power sterring and brakes. Dealer cannot reproduce, so will do nothing about it. - gasoline smell and loud knocking from engine in hot temperatures. - extremely low gas mileage, almost 50% below advertised mileage. These complaints appear in other reports as well, so this is not isolated. Ford is doing its best not to address any of these issues and telling people to just deal with it.

- Sherwood, OR, USA

Car seized to run on street. Transmission failed at 170 miles.

- Darien, CT, USA