While driving lugs nuts broke, causing the front right wheel to detach from the vehicle. Consumer was traveling at 70 mph when lugs and nuts broke in the front wheel. Taken to dealership and put the same tire and rim. When consumer left dealership, lights failed to work and experienced shaking in front end. Took vehicle to a different dealership, and found out that the front end was so bad. Dealership replaced shims to align front end. The failure of lights was caused by the repair from the previous dealership because when they took the dash board apart, they poked a hole in the heater which burned the wire.

- Gustine, CA, USA

I understand this problem is under investigation as of Sept. 2001. As stated 14 incidents reported. I have a very hard time believing that I am number 15. This is ludicrous. This is a Ford defect, just like the Explorer and should be immediately recalled. I was extremely lucky, as it seems the others were also. I guess the NHTSA only really cares if there are fatalities involved. People saving people, who are they kidding. They probably have the Ford Motor Co. In their pockets. Please note that we leased this vehicle brand new and just recently purchased it.

- Scituate, MA, USA

No summary listed for above vehicle.

- Minneapolis, MN, USA

Caused loss of controll of SUV.

- Sandy, UT, USA

No summary listed for above vehicle.

- Chicago, IL, USA

Cost for repair $366.83 excluding tax. No safety defec tlisted.

- Columbia, MD, USA

The support bolt on the left side has broken and the right side is bent and ready to break. I do have photos. The seat belts are ripping in half at a point where the belt is inside the reel. Both shoulder belts on the 3rd seat have ripped and the left side 2nd seat shoulder belt has ripped aprox. 3/4 of the way through. Ford will not commit to replacement, will only evaluate.

- Auburn Hills, MI, USA

There was no accident involved with this part failure as our mechanic caught the problem before we had an accident. Our mechanic felt since this is the exact same part used in the Explorer and Mountaineer and has since been recalled, this one for the Expedition should be recalled as well. This is the exact same part! Ford was of no help and frankly Ford nor the dealership cared about this problem. No safety defec tmentioned.

- Hartford, SD, USA

No summary listed for above vehicle.

- Rindge, NH, USA

No summary listed for above vehicle.

- Leominster, MA, USA

Vehicle does not handle the way it should, it acts like it's out of alignment at all times. Does not go where consumer steers it, and does not handle well. Vehicle not taken to dealer yet.

- Cross Lanes, WV, USA

Engine would have severe vibration. Its very noticeable when vehicle is idling. Problem is intermittent. Took to dealership, and was informed that vibration was normal.

- West Monroe, LA, USA

No summary listed for above vehicle.

- Middleport, NY, USA

Connector between sway bar and lower control arm broke, causing handling of vehicle to become diffcult.

- Franklin, MI, USA

No summary

- Jordan, NY, USA

No summary

- Jordan, NY, USA

When making first sharp turn going 25 mph the right area makes a loud thump.

- Jordan, NY, USA

Firestone wilderness/at, size P235/75R16, standard equipment on this truck were out of round, and wobbled. Tread also separated under hot weather conditions. Firestone was not contacted. Consumer replaced at own expense.

- San Antonio, TX, USA

The vehicle drifts at highway speed due to flaw in the vehicle's front end design.

- San Angelo, TX, USA

Vehicle requires wheel alignment and tire balancing.

- Alhambra, CA, USA