10.0
really awful- Crashes / Fires:
- 2 / 19
- Injuries / Deaths:
- 0 / 0
- Average Mileage:
- 53,082 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
My spark plugs are going bad, I bought three tires. But now I'm having to take it to the shop because it's weird noises coming from the tire it may be the wheel baring or sway bar link and bushing the mechanic say.
- Aiken, SC, USA
The contact owns a 2002 Ford Expedition. The contact stated that while the vehicle was parked, it caught fire. The fire started from under the hood of the vehicle. The contact was able to extinguish the fire with water. An independent mechanic came to the contact's residence and diagnosed that the failure was related to NHTSA Campaign Number: 05V017000 (Vehicle Speed Control) however, the contact did not receive notification of the recall. The mechanic informed the contact that the speed control deactivation switch caused the fire that damaged the hydraulic control unit and the pigtail. The vehicle was towed to the dealer. The dealer confirmed that the failure was related to the recall. However, the dealer denied the recall repair since the recall was open for many years but was left unrepaired. The contact stated that she had owned the vehicle for a couple of months and was not aware there was a recall. The vehicle was not repaired and remained at the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,457.
- Hemet, CA, USA
Cruse control not working and no horn
- Mineral Wells, TX, USA
The contact owned a 2002 Ford Expedition. While the vehicle was parked, the contact smelled a burning odor. The contact found that the master cylinder caught fire. The fire department was not contacted. A fire report was not filed. There were no injuries. The vehicle was towed to crowley Ford Lincoln (225 new britain ave, plainville, ct 06062) where it was deemed destroyed. The dealer did not give a diagnosis, but contacted the manufacturer multiple times to determine what Ford should cover. The manufacturer was made aware of the failure and stated that the VIN was included in NHTSA campaign number: 05V017000 (vehicle speed control). The manufacturer provided case number: Cas12637815 and advised the contact to call his insurance company. The manufacturer stated that they would send an inspector. The approximate failure mileage was 183,000. Updated 09/07/17
- Middletown, CT, USA
The contact owns a 2002 Ford Expedition. The contact stated that while parked for over 20 hours the vehicle caught on fire. The vehicle had not been diagnosed by a mechanic. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure and current mileage was 150,000.
- Las Vegas, NV, USA
In March 2012 mother was pulling into a parking lot in waco. Car suddenly accelerated and ran through the parking lot eventually hitting a parked car. Car was fixed and mother told them to check this issue out. Again on 9/3/12, she was pulling into a parking space the car squealed, suddenly accelerated, did almost a U turn and ran into the wall at walgreens. Thankfully, no pedestrian was walking out of the store or they would have been seriously injured.
- Copeville, TX, USA
The contact owns a 2002 Ford Expedition. The contact stated that the vehicle was parked and shut off when it caught on fire. The contact was able to extinguish the fire and the vehicle was towed to the dealer. The dealer confirmed that the cruise control and master control sensors needed to be replaced as per the instructions of NHTSA recall campaign id number: 05V388000 (vehicle speed control). The contact spoke with the manufacturer and was advised that the vehicle would not be repaired under the recall because the contact was sent notice of the recall and never responded in order to have the vehicle repaired. The contact stated that he never received notification of the recall. The failure and the current mileages were 171,297.
- Brentwood, TN, USA
Small fire extinguished prior to fire department arrival. Fire occurred on a sensor attached to the brake fluid reservoir. Fire appears to be consistent with speed control deactivation switch as previously recalled. No damage outside of vehicle.
- Franklin, TN, USA
The Ford Expedition was parked at walmart and just caught on fire it also burnt two other vehicles before the fire department was able to put it out, the Ford was fully engulfed and the cavalier beside it was also burning and was completely burnt on the passenger side and the Honda in front of it was also damaged.
- Valley, AL, USA
The contact owns a 2002 Ford Expedition. The contact stated that the vehicle was repaired under the recall associated with NHTSA campaign id number 05V388000 (vehicle speed control). After the repairs were completed, the horn and speed control were still inoperable. The manufacturer was notified and advised the contact to take the vehicle back to the dealer. The approximate failure mileage was 31,300 and the current mileage was 31,400. Consumer is unhappy with dealer. Has turned the whole matter over to legal counsel. Updated 11/16/2011
- Atlanta, GA, USA
My Ford Expedition 2002 was recalled for fire hazard due to the cruise control. I had the repair done at mccoy mills Ford in fullerton ca. And a few weeks later my car burst into flames in my driveway while parked. The car was totaled and now I do not have a car and can not buy any thing comparable for the 12,000 the insurance paid. I believe Ford owes me the difference because I followed the rules and had the car "repaired" by them. What should I do now?
- Fullerton, CA, USA
My vehicle was functioning fine. I ran an errand, came home, parked my 2002 Ford Expedition under the parking shed and went into the house. Not over 45 minutes later my younger sister came and told me that my car was sparking and smoking. When I went to check on my truck I could see smoke and flames. I ran into the house to get the fire extinguisher and used it to put the fire out. I am fearful of driving this vehicle again but my insurance company feels that it can be repaired but can they assure me that this car won't experience the same sort of malfunction" what should I do? I want to drive a Ford Expedition but I don't want to drive this one anymore. I had to undo the battery later because sounds of sparks and the smell of burnt wire was still coming from the vehicle. What if this issue creates a chain reaction to my electrical system" I need a reliable car not a scary one. I checked the recall list for my car but am not sure if the recall is the cause for the fire but when I entered my VIN number recall #05S28 came back. It indicated there was a recall regarding the speed control system. I don't know what that means and really don't care to but I want my truck. I don't want that truck fixed or repaired and if it is, give it to somebody else that can drive around in it not have experiencing what I did in it. Please, thankyou
- Houston, TX, USA
I have owned two Ford Expedition, both of which were wrecked when it rained. My concern is that the vehicle becomes very loose in the rear when it rains and that is the problem that has lead to me having my accidents.
- Ellenwood, GA, USA
2002 Ford Expedition, sticking throttle or accelerator causes sudden acceleration and is quite dangerous, has happened several times and almost drove into a building. Almost feels like the cruise control is engaged but is not, this has happened just sitting at a stop light and happened when trying to pull into a parking spot and has happened a few times while driving.
- Goodyear, AZ, USA
The contact owns a 2002 Ford Expedition. While at work his vehicle caught on fire while parked at home. The fire department was able to extinguish the fire. The vehicle was completely destroyed. The cause of the failure was unknown. The failure mileage was 104,000.
- Tampa, FL, USA
The contact owns a 2002 Ford Expedition. While driving less than 60 mph, the vehicle jumped as if the accelerator pedal had suddenly been depressed. The contact also smelled a burning odor. The vehicle was taken to the dealer and they stated that the parts needed for the repair were on backorder. The cruise control switch was disconnected and the dealer stated that the fluid was leaking from the cruise control, which burned components of the speed control sensor and the connector. Both components needed to be replaced. She found NHTSA campaign id number 05V388000 (vehicle speed control), which stated that the manufacturer would disconnect the cruise control due to the possibility of a fire. The VIN was included in the recall; however, Ford refused to assume any liability for the additional failures due to the initial recall. The failure and current mileages were less than 140,000.
- Riverside, CA, USA
Vehicle had no mechanical issues up to the date of the incident. The vehicle was driven on a daily basis to and from work. The vehicle caught fire while parked in the driveway. After researching online what may have caused the sudden fire, we found it was due to a recall for the speed control deactivation switch.
- Naples, FL, USA
The contact owns a 2002 Ford Expedition. The contact stated that the cruise control switch was inoperative. Through online research, he found recalls listed for the same year, make, and model of his vehicle, but was unsure if they pertained specifically to his vehicle. The failure and current mileages were 140,000.
- Moultrie, GA, USA
2002 Ford Expedition spontaneously combusted. Last drove 8 hours prior to fire. Dealer disconnected cruise control switch on 11/30/05 (as per recall) and my documentation from dealer shows this service was done. Have never been notified by dealer of new part availability. So what cause the fire? did have a fuse blow about 6 days prior. This is the fuse that includes control of the shift lock. Truck is totaled.
- Round Rock, TX, USA
- Alhambra, CA, USA