the service engine light continues to turn on. the timing belt continues to fail and has already been replaced once. the camshaft on both sides have been replaced. the solenoids have also been replaced and the diagnostics codes still pop up (p0022) (p0021) are just some that i can remember. the engine does not have enough power on the driver side and throws the timing belt off which causes the loud rattle coming from the engine. when reaching the speed of 40-45 mph the truck begins to shake. recently in november 2023, when fueling up with gas, the truck began to shake and not respond. when accelerating, the truck takes off very slowly and the gears dont kick in on time. when the gas light comes on, the truck begins to function well. but as soon as i put gas again. it feels like the truck is going to fall apart. the driver door gets stuck when trying to open from the inside. the back door on the left does not open from the outside. the gear handle can be moved up and down while the truck is not turned on. please help!!

- Lynwood, CA, USA

The car will sometimes not start or when running the engine will die. It appears not to get fuel

- Kemah, TX, USA

The contact owns a 2006 Ford Expedition. While driving various speeds, the vehicle stalled without warning. The contact stated that the "fail safe mode" indicator displayed. Hertrich Ford in milford, Delaware was made aware of the failure and replaced the throttle body and the driver's side fuel module. The manufacturer was made aware of the failure and referred the contact to NHTSA. The failure mileage was approximately 160,000.

- Milford, DE, USA

While driving carbon builds up in vehicle

- Mobile, AL, USA

While driving at 45 mph on 2 lane road the truck acted as if it had run out of gas. I shifted into neutral and coasted to a parking lot at a store on the other side of the road. Thankfully there was not opposing traffic or I would have stopped in my lane and blocked traffic.

- Halifax, PA, USA

It takes forever to dribble gas into the tank at the filling station; the back pressure in the filler pipe cuts out the pump so bad it takes over 20 minutes to fill the large tank; this is unacceptable in bad weather and more than annoying on a tight schedule as it encourages speeding to make up for lost time!

- Milton, PA, USA

Engine went in to fail safe mode and stalled while coasting to pull off. Put in neutral shut off key and then restarted. No more problem..until a year later. Fail safe then stall. Restarted and check engine light on. After 10 miles fail safe and stall. Restarted check engine light on took to dealer. Diagnosed as throttle body $650 repair. Obviously; I am not the first victim! shame on you Ford for not stepping up and taking care of your customers and replacing the throttle bodies. To consumers..fail safe doesn't mean safe to keep driving, it is designed to keep the engine running just long enough to maintain power steering and brakes while you pull over. Good luck!

- Glen Allen , VA, USA

Car just died on highway just shut off would not restart. After looking at it the fpdm was corroded and bad. This has been a interrmtint problem and has almost caused accidents when car stalls when driving at intersections and such aluminum and steel dont work well under a car and corrode very badly.

- Lebanon, CT, USA

3rd time problems with spark plugs and fuel injector....was told by dealer that this year model the injectors are bad for sticking....leaving the owner to pay for repair cost and the expense of changing Ford faulty spark plugs.

- Roseboro, NC, USA