While driving on the freeway our 2016 Ford Expedition's engine went into "Limp Mode" causing total loss of power. We barely were able to move into the slow lane and place hazard lights on while cars ran up on us slamming on their brakes to avoid a collison with our disabled vehicle. There was less than three feet of shoulder against a concrete barrier for us to stop. The dash showed a large yellow wrench and engine was running extremely rough. After turning engine off and back on we accelerated into on coming traffic to find the nearest exit hoping that the engine would keep running. We were very lucky to not have been killed. When we returned home my son pulled the code "P2112" which is "Throttle Actuator Control System - Stuck Closed". There is a Technical Service Bullentin #TSB 16-0139 that was put out by Ford for their techs to diagnose and repair the issue. So they are aware this is an ongoing safety issue. NHTSA is aware this is an ongoing safety issue.The dealer wants $590 labor plus $258 for the Throttle Body to replace and diagnose the code we have already pulled and supplied them with the TSB bulletin. I wonder how many accidents and/or lives will it cost for the NHTSA and/or Ford to step up and recall these unsafe throttle bodies that are obviously defective.

- Meridian, ID, USA

The throttle body failed, and my car lost power as I was turning into traffic on the road outside of my subdivision. My car went from approximately 45-50 miles an hour to no acceleration. My car would only go forward at the speed at which it idles. It was very dangerous to me and to others because it was a sudden power failure. The problem was reproduced by the local Ford dealer. I don't know if the component has been inspected by anyone. The first time it happened, there was an orange wrench on my dash with "See Owner's Manual" under it. This happened at least three times before we took it to our local Ford dealer. The dealership said they couldn't find anything wrong with my car and that I should "drive it till it broke".

- Fort Mill, SC, USA

Water/condensation build-up in charge air cooler collects in tubing and discharges into intake when quickly accelerating from a stopped position or -??punching it-?? to pass a slower vehicle in traffic. This causes my vehicle to go into limp mode and lose all power which can be extremely dangerous in high traffic conditions.

- Princess Anne, MD, USA

75k Miles, 2016 Expedition Known Throttle body issue. Engaging the "Limp Mode" Happened several times before we could get it into the dealership. Each time was at different speeds and conditions.(** Who by the way told us to just keep driving it until our dealership appointment arrived approx. 2 weeks later) Not thrilled about this issue. We purchased the vehicle as a family hauler and a road tripper. Do not like the idea of having my kids in the car and the potential of this happening in a dangerous area. Ford dealer replaced the unit 10/8/21 we will see if the replacement will be a permanent fix for the vehicle. It does seem like ford is dragging their feet on this and not issuing a recall.

- Wichita Falls, TX, USA

6 months ago, electronic power steering failed (Control module?). Today. Electric throttle body - Code P2111. Driving down the road and lost acceleration (the -??limp-?? condition). Engine is running but no reaction to the gas pedal. Wrench symbol on the dash. I coasted to a spot where I could get out of traffic. Restarted the vehicle and the error went away. When I made it home, I removed the throttle body. Butterfly was a little dirty but much cleaner than the ones shown on YouTube. Opened the gear box and it was clean too. However, several teeth on the plastic gears were worn and/or disfigured. It also seemed like the little electric motor would not let the butterfly shut all the way.

- Georgetown, IN, USA

P2112 error keeps coming up causing sudden lose of power in the vehicle. This has happened while driving on the freeway, causing a panic moment to get to the shoulder, and on city and rural roads. We have to pull over shut the vehicle down and then restart it so that we can continue driving.

- Port Washington, WI, USA

While driving on a city parkway going around 35-40mph. My Expedition suddenly started shuddering and decelerating. The wrench light came on. I pulled over to the side of the road. I looked up in the owner's manual what that meant. It said to contact an authorized repair center. I went to the local Ford dealership. They ran the diagnostic and said it was the throttle body. They also stated it is a known problem with the eco-boost engines. This is a known problem with this engine and needs to be recalled before the loss of power and control happens on a busy highway and someone is injured or killed.

- Collinsville, IL, USA

Vehicle suddenly stopped operating while driving 90 mph. A complete loss of power occurred. The vehicle was immediately put into neutral and allowed to coast so that it could be safely moved to the emergency lane of the interstate. Several attempts were made to restart the vehicle while coasting. Additional attempts were made to restart the vehicle after the vehicle came to a halt. No success. The vehicle would turn over but never start. The vehicle was towed to the nearest Ford dealer. After inspection, Ford determined that the fuel pump had failed unexpectedly.

- Hampton, GA, USA

The vehicle was in motion, on a city street lost power, shut down but didn't cut off no throttle what so ever.. I believe it is the throttle actuator control service code P2112

- Gridley, IL, USA

Power train failure while driving, car stopped moving on highway. Needed to turn car off and restart. Happened again after driving less than a mile. Had car towed to dealer.

- Vail, CO, USA

Throttle body malfunctioned and was replaced at 80000 miles. Replacement throttle body malfunctioned after an additional 24000. It was also replaced. Both replacements were performed by authorized Ford dealers.

- Fulton, MO, USA

While driving the engine goes into "limp mode". this has happened 8 times in the past week at speeds of 50mph or even 15mph driving normal on a highway, country road, and entrance to a parking lot. This is incredibly dangerous because the vehicle has absolutely zero power and driver must place vehicle in neutral and coast to a safe place to pull over. Once pulled over, the vehicle has to be turned completely off and restarted. Afterwards, the vehicle runs very rough and cel is on. The code for the engine light displays the code : 2112 which is the throttle actuator is stuck closed. After doing research, this has been a known issue for years and not being taken of. This could extremely dangerous if someone is going 70mph in traffic, on a bridge, or even 45mph in a construction zone on the interstate.

- Waynesville, OH, USA

Vehicle stopped when in traffic, multiple times. Dealer is replacing the electronic carburetor sensor which electronically connects the gas pedal to the engine. Said they have had to do this on several vehicles lately. My son owns a 2015 F150 and his truck had the exact same problem last week. Must be a widespread problem if several vehicles in our small town have had the same failure.

- Spearfish, SD, USA

While driving on a city street I lost power and control to the engine. Control of the engine is lost when without warning acceleration is lost. The car will slow until about 5 miles an hour speed. The rpms will fluctuate up and down and stepping on the accelerator does nothing. No warning is given, and I almost got into an accident. The diagnostic was completed at a Ford dealership and it turn out to be the throttle body. This seems to be a known issues with Ford cars. This is very dangerous as it can happen at any time. Losing control of acceleration can be deadly depending on the circumstances. Once the vehicle is turned off and started up again the problem goes away until it happens again, once you have it, the problem will be there until it is repaired and hope that the issues never returns.

- Las Vegas, NV, USA

On 11-30-2016 with clear weather at about 3 pm traveling at traffic speed of 70 mph on I610 South loop East harris county tx (city of houston) in the 3rd lane right from the right side shoulder of 4 lanes, a "wrench" icon come on the display and said to contact the dealer. Immediately at the same time the Expedition lost all accelerator power. The pedal went limp. A hazardous, perilous drift across the oncoming 2 right lanes to the shoulder was terrifying. By the grace of god we made it to the shoulder without being hit and/or causing a multi car wreck and probable fatalities. The car motor continued running, but there was no acceleration, no power to move the car. The car was towed to the Ford dealer where the throttle body identified as the failure and was replaced. The original part throttle body replaced was part # bl3Z*9E9268A. The new throttle body is part # bl3Z*9E926. I have had this Ford Expedition for 11 months. I learned many throttle body parts on Ford Explorer have been replaced by searching the internet for information. There was no listings of 2016 Expedition having this life threatening failure. I do hope and pray that no one is hurt or killed before this situation is corrected.

- Pasadena, TX, USA