The contact owns a 2018 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V197000 (Seat Belts); however, the part to do the recall repair was not yet available. The contact stated that while refueling the vehicle, the contact heard an abnormal firecracker-like sound coming from the vehicle. The contact later noticed that the front driver's side seat belt had retracted and was locked. The vehicle was taken to an independent mechanic, where the contact was informed that the seat belt pretensioner had deployed, causing the seat belt to be locked. The vehicle was taken to the dealer, where the same assessment was made; however, the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the manufacturer was made aware of the failure and advised the contact to continue driving the vehicle even though the front driver's side seat belt was inoperable. The failure mileage was approximately 121,992.

- Huffman, TX, USA

My vehicle is having the exact same issue addressed in Recall 24S06. Although Ford-??s system indicates that my VIN is not included in the recall due to its manufacturing date, my vehicle is exhibiting the same safety defect that the recall resolves. My vehicle was manufactured 2 months prior to the date of manufacture that was included in the recall. My Vehicle is the same year, make and model of the vehicles included. Specifically: The Airbag light is on and received a message that says: The restrains control module has detected a fault with the passenger seatbelt retractor pretensioner circuit, causing drivability and safety concerns.

- Jackson, TN, USA

The contact owns a 2018 Ford Expedition. The contact stated that while her husband was driving at 20 MPH, the front driver's side seat belt exploded, making a loud popping sound, and the seat belt tightened and pulled the driver back into the seat. Additionally, the automatic emergency braking system engaged, causing the vehicle to stop. No warning light was illuminated. The contact's husband stated that the cabin was filled with smoke and an electrical burning odor was noticed. The driver pulled over, but the seat belt had significantly retracted and was able to be unbuckled after several attempts. The contact-??s husband sustained a seat belt mark on the left shoulder, but no medical attention was received. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The contact was informed of that the VIN was included in NHTSA Campaign Number: 25V197000 (Seat Belts); however, the contact stated that the recall notification had not been received and the part to do the recall repair was not yet available. The failure mileage was approximately 26,600.

- Apollo Beach, FL, USA

Went to leave for work and as I started my vehicle and pulled my seat belt to put it on and the seat belt pretensioner went off.

- Las Vegas , NV, USA

Cam phaser and timing chain assembly is beginning to fail. Ford has a CSB out on this problem but is unwilling to repair or replace components. Transmission has had to be replaced be cause of failure at 100000 miles. I-??ve had to replace the water pump twice on my Expedition. Driver side seat belt no longer retracts.

- Basye, VA, USA

Driver side seat belt air bag popped while driving down the road and now the seat belt will not retract. shows that this is a known issue in my year model but this is not a recall for my specific vin.

- Axtell, TX, USA

The seatbelts on the outside 2nd row seats will not fit bigger people because only the lap belt portion of the assembly is too short. This seat belt inflated over the verticals portion of the belt so it cannot use an extender. The solution is to lengthen the lap portion of the seatbelt. Twice, this vehicle had to be driven with persons in that seat without a seatbelt because it would not fit. Investigation reveals these seatbelts are made for teens, however they should fit anyone riding in the seat. We asked Ford customer service to help solve this problem, however they quickly cancelled our case. I called and re-opened the case. # cas-21718846-M4J6B6. The vehicle was in motion while the two persons were unable to use the seatbelts. Note: The lap portion of the seatbelt is not inflatable, and is too short, while the inflatable portion is the verticals part and is plenty long and would fit anyone. The lap portion needs to be lengthened.

- Kent, WA, USA

Takata recall. On 4/29/19 the 2nd row middle seat belt was replaced after having been in the shop 2X for diagnosis. It would not release out to buckle. It kept snagging on itself inside. On 6/11/19 the vehicle was taken in to be diagnosed for bad strut. Turns out 3 of the 4 were bad and need replaced. The dealership would not replace the 4th strut even though she stated its been a big problem lately. Also the lift gate was inspected as it opens and closes on its own periodically. They could not get the lift gate to recreate the problem and since the vehicle didnt throw a code for it they cant do anything about it. I have an appointment for 6/19/19 to have the 3 struts replaced and the lift gate checked again.

- Clute, TX, USA

After calling 3 Ford dealers around Kansas City mo. They all told me that Ford does not have seat belt extension for 2018 Expedition.

- Kansas City, MO, USA