The contact owns a 2019 Ford Expedition. The contact stated that an abnormal rattling sound was coming from the engine. There was no warning light illuminated. The vehicle was taken to the dealer and the contact was informed that the cam phasers where defective and needed to be replaced. The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 58,000.

- Boynton Beach, FL, USA

The contact owns a 2019 Ford Expedition. The contact stated that the low oil pressure warning light was illuminated on the instrument panel. The vehicle was taken to the dealer where it was diagnosed with a defective oil pump. Additionally, the contact was also informed that the cam phasers were defective and needed to be replaced. The manufacturer was notified of the failure, and the contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 77,000.

- Baytown, TX, USA

The contact owns a 2019 Ford Expedition The contact stated while at a stop light, the vehicle started shaking and the contact heard a rattling sound coming from the vehicle. The check engine warning light illuminated. The vehicle was taken to the dealer and the contact was informed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted no assistance was provided. The contact was advised to contact the NHTSA Hotline. The failure mileage was 82,000.

- Jonesboro, AR, USA

The contact owns a 2019 Ford Expedition. The contact stated that upon cold starts, there was a loud rattling sound coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that the engine cam phasers had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the vehicle was previously service under a Manufacturer Extended Warranty Coverage for the failure. The failure mileage was 77,000.

- Saint Charles, MO, USA

This vehicle with 72,000 miles on it was experiencing a rattle upon start on cold mornings for about two months, it didn't happen every time and only on initial start. Mechanic couldn't get the incident to happen in his presence to diagnose and no codes reported from computer diagnostic equipment. In February 2023, the vehicle lost power while highway driving and seemed to having problems shifting. The check engine and powertrain malfunction indicator both came on. Drove the vehicle immediately to mechanic. Booster sensor replacement was indicated by computer diagnostic and was replaced. On 4/16/2023 the check engine light came on briefly while driving and then went out and did not come back on. On 4/18/2023 while driving on the highway the vehicle started making a loud clanking with black smoke from exhaust pipe. We had the vehicle towed to mechanic. Over 30 diagnostic codes reported and mechanic recommended we take the vehicle to a Ford dealership. We had the vehicle towed to the local Ford dealership and have been informed that this 4 year old, 72,000 mile vehicle needs a complete engine replacement for $18,222. They do not know what caused the problem without pulling the whole engine and opening it up, but recommend a full replacement. We have contacted Ford and opened a case with them, but since the vehicle had a 60,000 mile power train warranty there is nothing that Ford is willing to do.

- Brenham, TX, USA

The contact owns a 2019 Ford Expedition. The contact stated while driving into the driveway and shifting into park, the shift indicator message stated that the vehicle was not in park; however, the contact was still able to turn off the vehicle. On another occasion, while driving 15 MPH and entering the highway, the vehicle lost motive power with the check engine warning light illuminated. The warning light disappeared, and the vehicle operated as intended. The vehicle was taken to the dealer and the contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the contact was informed that the vehicle was not under recall. The manufacturer did not provide any further assistance. The failure mileage was 92,000.

- Rawlings, MD, USA

There is an issue with the 3.5L GTDI engine cam phasers, identical to known recall FSA 21N03. This vehicle was not included in the mentioned recall as the manufacture location was other than those listed in recall FSA 21N03.

- Bartlesville, OK, USA

The contact owns a 2019 Ford Expedition. The contact stated while his wife was starting the vehicle, she heard an abnormal sound coming from the vehicle. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the Variable Camshaft Timing (VCT) unit to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 52,000.

- Kaukauna, WI, USA

The contact owns a 2019 Ford Expedition. The contact stated that while driving at various speeds, the vehicle unexpectedly downshifted. There was no warning light illuminated. The vehicle was taken to an unknown dealer, where it was diagnosed that the solenoid valve was defective. The contact stated that the vehicle was returned to her a week later; however, the failure reoccurred while driving the vehicle to her residence. The dealer was notified, and a second appointment was scheduled. The manufacturer was notified of the failure, but no assistance was provided. The vehicle was not repaired. The failure mileage was approximately 43,000.

- Simsboro, LA, USA

My 2019 Ford Expedition is experiencing engine shudder. This started about 3 weeks ago and is starting to happen more and more.

- Adrian, MI, USA

The contact owns a 2019 Ford expedition. The contact stated that while starting the vehicle, the vehicle made an abnormal sound. The vehicle was taken to an independent mechanic, where it was diagnosed with faulty cam phasers. The vehicle was not repaired. The manufacturer was made aware of the failure and suggested that the contact file a complaint with the NHTSA Hotline. The failure mileage was approximately 50,000.

- Pride, LA, USA

The contact owns a 2019 Ford Expedition. The contact stated upon starting the vehicle, he heard an abnormal sound coming from the engine on several occasions. There was no warning light illuminated. The vehicle was taken to the local dealer who informed the contact that the VIN was not included in Customer Satisfaction Program Number: 21N03 (Cam Phaser Replacement). The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 61,900.

- Brandywine, MD, USA

The contact owns a 2019 Ford Expedition. The contact stated while starting the vehicle, the vehicle made abnormal rattling sounds. The vehicle was taken to the dealer where it was diagnosed that the failure was related to Customer Satisfaction Program: 21N03 (Cam Phaser Replacement) however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 62,000.

- Naples, FL, USA

Our SUV has had problems in trying pick up speed. It started a few years back when I was taking a right turn and as I pushed on the gas pedal the SUV would not take off. We took it into the dealership but they could not recreate this problem. Yet, the problem persisted for us so we took it again to a different dealership and again they could not recreate the problem. Now our check engine light is on and the problem is getting worse. I called the dealership last week to bring it in and they could not get me in until mid-Septmember. One major incident occured when we were merging on the highway with lots of traffic and the SUV would not pick up speed. Some warning lights came on our dashboard and we had to immediately pull over to the side because the SUV would not pick up speed and it starting puttering. We were almost hit from behind by another vehicle due to the SUV not picking up speed. This problem has progressively been getting worse and I am afraid to drive the vehicle anywhere. I could be driving as slow as 30mph and trying to speed up causes the SUV to shake and putter. Now, when this happens the A/C does not cool. It feels like the SUV will shut off while I am driving. Plus, now the Engine Start/Stop feature no longer works. We have 4 kids and I am scared to drive this SUV as I feel this may cause us to be in a car accident. This is a major safety issue that needs to be addressed.

- San Antonio, TX, USA

The contact owns a 2019 Ford Expedition. The contact stated that while starting the vehicle, there was an abnormal rattling sound detected. There were no warning lights illuminated. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but no additional assistance was provided. The approximate failure mileage was 65,000.

- Royse City, TX, USA

The contact owns a 2019 Ford Expedition. The contact stated that every time he started the vehicle, the engine would rattle and make a loud noise. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined there was manufacturer internal recall 21B10 that was to address a PCM Re-flash failure. The contact was advised by the dealer that his warranty did not cover the repair. The contact did not have the vehicle repaired. The manufacturer had been informed of the failure. The failure mileage was 70,236.

- Manteca, CA, USA

My family received a notice of Customer Satisfaction Program 21N08 -?" PCM Reprogram Due to Engine Shudder -?" 2017-2020 Ford F-150, 2018-2020 Expedition, & 2018-2020 Lincoln Navigator. We immediate began trying to locate an authorized repair facility. It took several months to get an appointment. During this time, our vehicle shuddered, stopped, and even turned off completely while driving. The problem continued to increase in intensity. When we were able to get the vehicle into a Ford dealership, they suggested that we contact Ford for the repairs that we needed. A private repair facility told us that now, because the shudder issue was not resolved right away, they discovered VCT phasers, VCT solenoids, timing chains and tensioners - failed setting code P0021 and causing engine to run rough. There was a loud rattle on startup which is related. P0018 stored in history. We have received a $4,000 repair estimate. I contacted Ford Customer service. They suggested I bring it into Ford Dealership. I explained that it had taken months to get in the first time. Customer service refused to provide me with additional authorized Ford repair (non dealers) in my location. Customer service refused to provide me with information on the error codes above. Customer service refused to provide me with more information concerning the PCMC reprogram and the known problems related to failing to obtain the reprograming. Customer service was not able to help me at all. I believe that the -??PCM reprogram due to engine sudder-?? should be investigated as a potential formal recall program. Ford should repair of known issues a priority for their customers, and should also repair issues caused by failing to allow their customers to receive a timely remedy of this problem. I would also like more information on known issues with the PCM reprogram and engine shudder. I would like to view the quarterly reports.

- New Brighton, MN, USA

The ecoboost 3.5 engine has a common issue with the cam phasers. My vehicle has had oil changes done, every 9,000 miles and now needs the cam phasers to be replaces. It has 83,000 miles. I believe this is a known defect that Ford is trying to remedy with customer satisfaction campaigns, rather than a recall. Had the 21b10 tsb performed and which is a requirement and the car shudders and the transmission shifts poorly. Also, the driver's side seat best will not retract fully.

- Katy, TX, USA

-??Vechicle is a lemon car by definition and needs to be replaced due to safety issues and the amount of calls in the short duration I have had it in my position -??My family and I have been leveraging other family vechicle along side putting the car dormant as much as we can to avoid further mechanical issues which is not acceptable -??The request to ask for 4 to 6 weeks on a car repair without loaner is unacceptable as the loan payments are still due by me to the lender and are unable to utilize the car in any capacity -??The issue has been open for about 10 months since reporting with NO resolution - unacceptable -??Dealership purposely delayed and provided incorrect information and allowed the warranty period to expire as it would provide revenue of service to the business (recalls are free) Please see the attachment for a detailed timeline and supporting documents

- Houston, TX, USA

On March 22, 2021, check engine light. Took vehicle to Ford dealer. Technician said cam phaser needed to be change. At around 72000 miles. Google search to find out, that is a common problem in the 3.5 eco boost engines. Vehicle was purchased certified used from Elder Ford Tampa, FL with about 33000 miles March 2020. Mall of George Ford, diagnose the check engine light.

- Miami, FL, USA