On Monday, December 16, 2024 I brought my vehicle in for diagnostic services due to a 'metal on metal' noise causing a vibration in the gas pedal, and loss of power when vehicle reached 2000 rpms. This vehicle is hazardous to drive and leaves the vehicle behind me without any indication that my vehicle is experiencing a loss of power and is slowing down abruptly. The vehicle began hard shifting at approximately 30-40k miles, and the dealership stated they were unable to duplicate the problem and did not document my complaint during my inquiry at oil changes. Although there is a technical service bulletin to address this concern, as an individual with Master of Science in Engineering Management educated in Safety, and currently serving as a volunteer of the Federal Aviation Administration Safety Team, I am requesting a thorough investigation of the vehicle's performance in this current condition as well as any other previous vehicle crashes that may have occurred as a result of this issue.

- Youngsville, LA, USA

Frequently when driving my 2020 Ford Expedition max the transmission slips out of gear causing it to go into neutral and put me in a position when i am unable to accelerate my vehicle. This happens mostly on the freeway when we are driving 65 MPH and greatly endangers the safety of my family. Reading several on-line forums indicates this is a common problem and should be fixed via a recall. Also, my dashboard viewing screen often turns black for no reason when using or simply does not turn on.

- Newbury Park, CA, USA

The contact owns a 2020 Ford Expedition. The contact stated while driving 70-75 MPH, the transmission was shifting hard and unintendedly shifted to various gears continuously. The power train warning light was illuminated. The message "Power Train - Engine Failure - See Owner-??s Manual" was displayed. Additionally, there was an abnormally loud sound coming from the transmission assembly. The message "Reduced Engine Power-?? was displayed, and the vehicle failed to respond upon depressing the accelerator pedal. The temperature gauge displayed 285 degrees. The contact was able to veer to the side of the road and allowed the vehicle to cool down. The contact was able to continue driving. The vehicle was taken to the dealer, where the transmission yoke was replaced; however, the failure recurred several times while driving. The vehicle was taken to Red McCombs Ford (8333 I-10, San Antonio, TX 78230) and to Griffith Ford Seguin (1880 I-10, Seguin, TX 78155); where the transmission was replaced and rebuilt several times; however, the failure persisted. The contact stated while driving 75 MPH, the transmission was shifting hard and was continuously shifting from high gear to low gear. The check engine warning light and several unknown warning lights were illuminated. Another driver honked and drew the contact's attention. The contact noticed a trail of white smoke and that there was smoke coming from the engine bay. The contact was able to veer to the side of the road and allowed the vehicle to cool down. The vehicle was taken back to the first dealer to be diagnosed. The vehicle was not yet diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that they could no longer assist in covering the cost of the repair. The failure mileage was approximately 20,000.

- Marion, TX, USA

I was driving 70mph when suddenly a red alert on the dashboard said coolant alert 402 degrees the car was not heating up at all before that. I pulled to the side of the road right away. Smoke started coming out trunk ran and in less than 2 minutes the car was on fire.

- New Braunfels, TX, USA

I read that there is a recall on 2021/2022 Fords with Eco Boost but not the 2020. I have had my vehicle into the dealership multiple times due to misfires and loss of all power which has almost caused multiple accidents on the interstate. I accelerate to get into the left lane and lose all power and do not get power back until my vehicle decelerates down to around 40 mph/or a lower gear, causing semi-??s and other vehicles to have to slam on their brakes so that they do no run into the back of me. It idles very roughly and overall has been the worst vehicle mechanically that I have ever owned. The dealerships always say they cannot find anything wrong with it or cannot reproduce it but it happens on a daily basis and keeps getting worse. I have had the transmission updated, changed the cool packs, and changed the plugs which has not helped at all. I want to know why the 2020 Expedition is not included in this recall? This is the most expensive vehicle I have ever purchased and I would expect it to run smoothly with no issues and I am very disappointed. Not only disappointed in the vehicle, but in Ford itself for not acknowledging this issue. I have read many complaints from other customers experiencing the same issues and unable to find a fix for it. I would like some answers and for Ford to make things right with my Expedition. I am not able to trade it in or sell it due to having all the issues that it has and frankly I-??m not sure I trust Ford anymore or if I-??ll ever buy a Ford product again and we have been faithful Ford owners for years. Thank you for your time and I-??ll be looking forward to hearing back from you soon regarding this issue. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Vicksburg, MS, USA

On multiple occasions, our car has lurched out of gear going at fast speeds on the highway. It slips out of gear and the car shakes and then it lunges back into gear. On a few occasions, the gas pedal was also inoperable while the car was "finding the right gear". This has been extremely scary for my family when this has happened. The first time we took it to the dealership and they reprogrammed the transmission. Then, it happened again about 6 weeks after the fix, and this time the transmission valve had to be replaced.

- Derwood, MD, USA

The contact owns a 2020 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle briefly jerked and hesitated, prompting thee contact to pull over to the shoulder of the roadway to turn off the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The service engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 105,000.

- Austin, TX, USA

Less than 74,000 miles and coolant hoses split. According to service department they have had an increase in hoses rupturing indicating a fault in the hoses.

- Petal, MS, USA

Hard shifting, and loss of sudden power while traveling. Recently purchased. No recalls yet. But having same issue's stayed on law site filed. vehicle lost power while accelerating to merge onto freeways or cross busy intersections.

- Lubbock, TX, USA

Incident happens every 1k miles or more. Car is in motion driving. Press down on throttle and transmission drops to 1st gear. A bunch clicking and thumping sounds are heard. Car doesnt accelerate(can be at 70mph), starts to slow quickly until gears change. Also 4H is jerky as well as sport mode. Very unsafe to be traveling on the highway trying to overtake a vehicle and then your car fails.

- Cleveland, GA, USA

I've taken my car in for over a year multiple times for the same issue. When driving the car will jerk almost as if I've hit a car and power goes down. Many times it fails to go when accelerating after this has happened. The movement of the car is worrisome and the loud noise made can be heard out the car. When this happens the steering locks up and makes it hard to turn along with the power going out. I've been told on each occasion that nothing can be found. It never throws a code, this past weekend while traveling it threw a code TSB #23-2249

- Thomasville, GA, USA

The vehicle jerks when you accelerate and begins driving.

- Terry, MS, USA

The contact owns a 2020 Ford Expedition. The contact stated while driving at an undisclosed speed, the low oil pressure warning light illuminated. Additionally, the vehicle lost motive power. The vehicle was taken to the dealer where it was diagnosed with failed front cover seals and an oil leak with metal shavings in the cylinder. The contact stated that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the failure occurred in July 2023 and the front cover seals failed and were replaced under warranty. The contact stated that the vehicle then had a coolant leak, and the coolant hose was replaced. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 110,000.

- Charleston, WV, USA

Already submitted 2 prior complaints regrading Transmission/Engine NHTSA ID 11583360. Vehicle transmission failure. Vehicle is at Ford Dealership for repairs. Safety risk involved risk of accident. Problem has been reproduced and confirmed by Ford service advisor. Vehicle is currently at dealership waiting on repairs to be made. It has been inspected by extended warranty advisors and approved for repair. Vehicle does give any warning when engine/transmission failure occurs. This has been documented since I bought the vehicle in Sept. 2022 with the dealership. This is the 3rd or 4th time it has gone into be checked finally when it happened and dealership was able to reproduce they stated that transmission needs to be rebuilt or new one needs to be installed. Since warranty did not want to cover new transmission they are going to rebuilt it. Before this instance they said it was because transmission failure due to having some sensor reset which did not work.

- San Antonio, TX, USA

Timeline of Recent Issues and Service Dates: Date Repair Order Date Invoiced and Picked Up Mileage Issues [XXX] [XXX] 21,735 Oil Change; Transmission; Sunroof; Gas Gauge; Door Seal; Power Running Boards; Park Assist [XXX] [XXX] 30,081 Safety Recall; Power Running Boards; Transmission [XXX] [XXX] 33,909 Wipers, Power Running Boards; Transmission [XXX] [XXX] 35,695 Internal Vent and Control Module; Rear Wiper Blade [XXX] [XXX] 43,912 Transmission [XXX] [XXX] 49,144 Oil Change; Check Up Transmission; Rear Brakes [XXX] Present 49,371 Emergency Break Down Mountains- Powertrain and Electrical Issues [XXX] Routine maintenance service at Mark Ficken Ford, including an oil change, tire rotation, and rear brake work. Video documentation confirming the vehicle's good working order post-service. [XXX]: Vehicle experiences severe issues while on a family trip, including shaking, flashing check engine light, and loss of power in the gas. Attempted restart at BP Station after a 20-minute break; vehicle runs smoothly. Decided to drive to the nearest Ford Dealer for further inspection. Recurrence of issues, leading to the vehicle shaking, stalling, and eventually dying [XXX]. [XXX] Vehicle towed to Asheville Ford for repairs. Contradictory issues identified by Asheville Ford, with additional services recommended. Repairs completed on [XXX]. [XXX]: Vehicle retrieved from Asheville Ford, exhibiting new issues such as delayed engine start, increased engine noise, rough running, and sporadic electronic malfunctions. Video evidence documenting the observed issues. Due to the ongoing and unresolved nature of the issues, the vehicle was dropped off at the Mark Ficken Ford dealership after hours on the [XXX], and keys were securely deposited in the night box, and I Ubered home. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Waxhaw, NC, USA

What component or system failed or malfunctioned, and is it available for inspection upon request" NOT SURE. THERE IS ISSUES WITH THE AUTO STOP/START WHILE VEHICLE IS STOPPED. How was your safety or the safety of others put at risk? THE ISSUE HAS CAUSED THE VEHILE ENGINE TO SHUT OFF COMPLETELY. THIS HAS OCCURED WHILE STOPPED AT A STOP SIGN, BUT ALSO WHILE TAKING OFF FROM A STOP LIGHT THAT HAD TURNED GREEN. Has the problem been reproduced or confirmed by a dealer or independent service center? YES Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear" AUTO STOP/START LIGHT, BATTERY LIGHT, ENGINE LIGHT ALL ILLUMINATE WHEN THIS OCCURS

- Llano, TX, USA

Traveling on the highway I lost all acceleration, the gas pedal wasn-??t functional and the vehicle begins to quickly decelerate, then it corrects itself and accelerates quickly. It has done this a few times already.

- Coral Springs , FL, USA

Transmission is slipping & failing. Why is this happening on a vehicle that is 4 years old

- Ravenna, OH, USA

While I am driving, or stopping to turn or at the red light the engine turned off completely, and a warning signs will display telling me to restart my car again, it is very scary abd dangerous. It happens 3 times so far where I have to turn on my warning flash lights, so cars behind me could pass me or wait until I restart and drive again. It happens with no warning

- Wamego , KS, USA

The transmission jumps when putting it in park or reverse or when driving and switching gears. This is a well known issue with this vehicle. Ford has done nothing to correct it. It-??s a safety issue as I went to Pass and my car stalled on the highway and did not switch gears. I do not feel to be responsible for paying for a repair that is happening everywhere.

- Cooper, TX, USA