10.0

really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
0 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2002 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

problem #1

May 202005

Explorer 4WD

  • miles
2002 Ford Explorer experiencing problems with the 4WD, the over drive light illuminates on the dashboard and the vehicle is giving off a rotten egg smell. There were front end problems. The 4WD module wasn't working. The driveshaft and both front wheel bearings were replaced. The rotors were out of round. The service engine light illuminated along with the over drive light. The transmission experienced the same problem on two occasions and possibly a third time. A large puddle of transmission was found under the vehicle. The torque converter was noisy. The acceleration pedal would pull back. When the vehicle was accelerated, it would whine. The left rear wheel bearing was gone and caused damage to the axle, brakes and the tire was barely holding on. The error code for the service engine soon light was due to the solenoid which had been changed before. The A/C was inoperative.

- Morris, PA, USA

Add Complaint