Back glass on lift gate exploded. Glass went every where. No one was in the thank goodness.vehicle was just sitting in driveway. It just exploded and shattered. There was nothing wrong with the glass. The only thing there was a crack on lower panel that had been there for about 3 years.

- Marquand, MO, USA

All 4 of the wheel bearings had to be replaces in a matter of 5 months the rear window has a crack in the fiberglass covering right down the middle said not covered not a health risk but the molding is still cracked from the bottom of window to the bottom of the molding piece brake lights stay on until U get back in and tap the brakes then the light shuts off.

- Plainville, MA, USA

My son went to leave in Explorer. Noticed hatch had popped open (has been doing this) and when he closed the two inch opening the glass exploded on him and all over driveway. Glass piece in eye which is ok and scrapes on arms and foot. This could have been so much worse and want answers to why this happened.

- Scottsboro, AL, USA

The contact owns a 2003 Ford Explorer. The contact confirmed there was a crack located on the panel of the rear window. The vehicle was not taken to the dealer to be repaired. The manufacturer was not notified of the failure. The vehicle was not repaired. The VIN was unknown. The failure mileage was 125,000 and the current mileage was 177,000.

- Roberta, GA, USA

The contact owns a 2003 Ford Explorer. The contact stated the vehicle was previously repaired under a recall associated with NHTSA campaign id number 07E104000 (visibility: Glass, side/rear). The repair was performed prior to the purchase of the vehicle. The remedy was insufficient, as a result to the rear liftgate hinge failing to secure the window glass properly. The vehicle had not been repaired. The manufacturer was notified of the malfunction. The approximate failure mileage was 109,000.

- Smithville Flats, NY, USA

Blend door actuator not working. Not able to defrost windows easily.

- Washington, DC, USA

Temperature blend door starts making a clicking noise and then the heater starts putting out cold air. The front window doesn't defrost. No heat in the front of the vehicle when temperatures outside can reach 0 degrees. The average cost to repair the part is $734.

- West Bountiful, UT, USA

I was driving my 2003 Ford Explorer at 70 mph in the fast lane of the freeway and decided to pull the driver's side visor down to cut down on the sun's glare. All of a sudden, the plastic mount that holds the visor metal stem in place shattered and the visor came loose dangling in front of my face by an electrical cable. The visor was severely obstructing my vision so I had to quickly grab the it and hold it out of the way with my left hand while steering with my right to negotiate across 4 lanes of freeway traffic until I could stop the vehicle on the freeway shoulder. The electrical cable does not have a connector so it is not possible to disconnect it from the vehicle. As a result, I had to drive the next 20 miles using my left had to hold the visor up with my left hand while driving with my right until I could reach home.

- La Habra, CA, USA

3 large cracks in plastic trim below glass on rear lift gate "appeared" after a cold/icy day.

- Pasadena, MD, USA

The contact owns a 2003 Ford Explorer. The contact stated that the plastic underneath the rear liftgate's glass door has begun to crack. The door still operates properly. The VIN was unavailable. The current mileage is 78,000 and failure mileage was 74,000.

- La Mesa, CA, USA

Numerous problem: Brakes, rear window opening, seat belt retraction, heater, rear defrost, body work, etc.. while braking the brake pedal went to the floor and caused extended stopping distance. The rear window hinge failed which caused the window to open while the consumer went through a car wash. The seat belt retracted slowly which caused the belt to become hooked onto the door lock system. As a result the passenger could not get out of the vehicle. The left wiper was not clearing the windshield. The left rear door would not close all the way unless it was slammed hard.

- Mountain Home, ID, USA