7.1
pretty bad- Typical Repair Cost:
- No data
- Average Mileage:
- 84,550 miles
- Total Complaints:
- 16 complaints
Most common solutions:
- not sure (9 reports)
- replace section above passenger rear tire (4 reports)
- do bodywork and repaint area (3 reports)
Body of SUV is bubbling and rusting behind back wheel wells. Had it fixed and it is doing it again. Foam noise-deadening foam is acting like a giant sponge.
- fordowner, Richmond, IL, US
Overall, a good SUV. One spot of rust has occurred on the right rear quarter panel, just below the gas cap access door. As I view the web site, it seems like I am not alone with this problem.
It seems my Explorer has all three of the common problems, rust, cracked rear panel, and of course the big one, a bad transmission.
- Ed H., Butler, MO, US
click to see larger images
Leading edge of hood started pitting several years ago. Started with blistering of paint. Now paint has completely peeled away and aluminum base is now showing. Hood latch is also "rusting" at the contact point with the iron fasteners to the hood. Appears that non-iron parts were not treated properly to prevent electrolysis. Repair shop said that the entire hood needs to be replaced. They also pointed out that other major metallic chassis parts are also rusting at a non-normal rate.
- sotomura, Honolulu, HI, US
Thought this one was my fault. Not the case. Paint bubbled up under gas cap, chipped off then rusted. NOW will not pass inspection.
When I saw another Ford same year with the same problem, I Knew it wasn't me.
- Thomas M., Quakertown, PA, US
Rusting above the gas tank spout. Paint is chipped off and rusting.
- Patrick P., Dearborn, MI, US
Front of hood is chipping paint and rusting. Dealer told me it's best to replace the whole hood, otherwise they're chasing the rust around inside and outside the front rim of the hood.
- Patrick P., Dearborn, MI, US
paint on roof peeling Had bumper repaired from accident years ago and paint now
bubbling up and peeling lousy paint job
They claim paint not under warranty.
- jdjams@aol.com, Danvers, MA, US
Paint slowly started to peel now the entire roof is rusting. The area around the front of the roof is especially rusted.
- roakley, Delmar, NY, US
When i bought this vehicle used, there was an area on the front of the hood that was blistered, and you don't have to be a genius to know that the metal underneath the blisters is rusting out. I told the dealer at purchase and was told they would take care of it. I was supposed to schedule it when i pick up my plates. When i went back i was told the dealer was no longer there, and that he had no right telling me that it would be fixed. Now the blisters are breaking open with rot under it. Ford says that type of problem is handled by the dealer. I fought for awhile, and then the dealership closed. Problem still unresolved and getting worse.
- adept, Belleville, NJ, US
my husband has tried to fix the rust but it returns the next day. to get it fix will cost 1500.00 ! we do not have the money and feel ford should fix it
- Kathy M., Glen Burnie, MD, US
My estimate to fix the rust is 1500 dollars and I just don't have that kind of money right now.
- belcher_ad304, Welch, WV, US
I do not understand how a vehicle which has been meticulously maintained, never wrecked, regularly washed and waxed (probably what caused it) could start rusting on the hood. The paint is terribly bubbled up. Not worth the time and money to fix since I know ford has no pride in their product and will not voluntarily fix it. I hope everybody sees how poor quality this vehicle is. Cant wait to unload this piece of crap.
- Kevin
- Kevin B., Bonney Lake, WA, US
Terrible surface rust popped up about 6 months ago and is only getting worse. Very annoying since this car is only 6 years old. You would think a paint job on a vehicle should be made to last, but apparently Ford chose to cut their cost in the paint department. I have had nothing but problems with the vehicle since I purchased it. The transmission went out after 80,000 miles and had to be rebuilt. I also have a mysterious crack down the middle of the back hatch (I have seen this same crack multiple times around town on similar Explorers that seemed to of been manufactered in the same year). I feel ripped off for this purchase and will never own another explorer.
- yorde, Columbus, OH, US
I was looking at the hood of my wife's Explorer and noticed the paint bubbling at the front lip of the hood. Opened the hood and see a bunch of bubbling on the edge. When I poke at it the paint flakes off and it is full of rust. I think this is ridiculous for a 4 year old car that is in San Diego where it barely rains and never snows. Just another issue in a long line... Wonderful "Made in America" products... Will definitely be looking for a Toyota or Nissan when it is time to replace this piece of cr@p.
- Eric L., San Diego, CA, US
One day while washing my car I noticed some bubbles on my hood. I thought it was just the paint. When my husband came home, we opened the hood and saw the problem, it was rusting under the hood and coming through the paint. I called the dealer to see if this would be covered and I was told that there had to be a hole in the body. Well at this point there is not, but I still have another 8 months for one to develop and I'm sure it will since it is already pretty bad. I just couldn't believe that they didn't want to fix it immediately since I will be driving around with this obvious defect on a brand new vehicle! What advertisement!!!
- Tracy C., Newell, WV, US
This vehicle has rusted worse than any vehicle I have owned in 50 years! Rust everywhere. We do not live in a big snow or beach area. I will never own another ford.
- jsirmg, Warrenton, VA, US