The contact owns a 2016 Ford Explorer. The contact stated while at a red light, the vehicle was shaking abnormally. No warning light was illuminated. The vehicle was drivable and was driven to a dealer. The dealer replaced the motor mounts and informed the contact that the torque converter and transmission needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The manufacturer was notified of the failure and informed the contact that the VIN was not under recall for the failure. No further assistance was provided. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 97,393.

- Toms River, NJ, USA

While driving vehicle down the road, steering locked up. Vehicle was taken to the dealer and diagnosed as a bad rack and pinion. This vehicle has 84,000 miles and should not already have issues with the rack and pinion. This incident, could have put my family and many other people's lives/vehicles at risk.

- Niles, MI, USA

The transmission suddenly downshifts causing rapid deceleration, if on the freeway could have caused an accident, the Ford garage could not duplicate the problem, there were no warning lights and no computer codes

- Savannah, GA, USA

The contact owns a 2016 Ford Explorer. The contact stated while driving 25 MPH, the vehicle failed to exceed 25 MPH or shift out of 1st gear. Additionally, the contact stated that while shifting to reverse(R), the vehicle failed to respond as needed. There was no warning light illuminated. The contact stated that the failure had been recurring. The vehicle was taken to the dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 56,000.

- Streetsboro, OH, USA

The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.

- Roach, MO, USA

The contact owns a 2016 Ford Explorer. The contact stated while driving 55 MPH, the contact heard a loud clanking noise coming from the transmission. There was no warning light illuminated. The vehicle was taken to an independent however, the vehicle was not diagnosed or repaired. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the flex plate was cracked, causing transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 90,060.

- Bausman, PA, USA

While driving on the interstate my transmission decided to stop working. I was not able to safely get off the interstate because this happened going up an incline. My explorer will not shift into any gear and the cost to replace the transmission is $5300. Ford stated that the recall #20B27 was completed on my car in 2020 but when I called after the transmission died they stated that my VIN was not eligible for the #20B27 recall. So, how was it completed if they are now saying the recall wasn-??t for my car? My explorer is a 2016/2.3L/6F35 Transmission code/built in Chicago. Ford needs to recall and replace every transmission in these explorers. With so many complaints and transmission failures/problems I-??m floored that nothing has been done to remedy this situation that many explorer owners are experiencing. Do better Ford.

- Norwich, CT, USA

The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 60 MPH and attempting to stop or decelerate, the rear tires were slippery and failed to stop as needed. No warning lights were illuminated. The vehicle was taken to an unknown local dealer however, no failure was found. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

- Santa Ana, CA, USA

The contact owns a 2016 Ford Explorer. The contact stated while driving 55 MPH, he was alerted to smoke emanating from underneath the vehicle by another driver. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the power transfer unit, after observing that the unit was leaking fluid onto the exhaust, resulting in a brief fire. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 98,000. The VIN was not available.

- Paoli, PA, USA

My car has 84000 miles on it. The car recently over heated, I checked the coolant level, and it was low. I filled it to the required level and the warning went away. 2 weeks later it came back, I brought it to the mechanic and was told that the engine needs to be replaced. That it is recycling exhaust from the engine back through the coolant system and that cylinder 3 is misfiring. I spent over an hour on the phone with Ford who repeatedly stiff armed me on any sort of assistance with the issue or information on expected or estimated failure rates for these issues. The car is currently at the mechanic where I have an estimate with a $12,000 price tag on it. To make this worse, in October of last year I was driving down [XXX] and when I went to exit the highway, there was a loud clunk and the car revved up real high before it started to move. This put me and all the drivers exiting this very busy off ramp in danger. At 74,000 miles I needed a new transmission because that loud clunk was me losing actual gears in the transmission. That repair cost right around $10,000 and again, Ford does not care. There were no warning lights with this issue, it just happened and left me in a very precarious predicament at a very busy intersection. The transmission has since been replaced for roughly a $10,000 price tag and now I am looking at another $12,000. All I want is Ford to do what is right. I could have been killed in that intersection or my car could have caught on fire recently with the engine issue. The financial strain of having to do 2 major repairs on a car that is relatively new and only had 74,000 for the transmission and 84,000 for the engine is unbelievable and unacceptable. Through research I feel that this transmission issue should be covered under an extension of the Customer Satisfaction Program #20B27 or #20N07 as the transmission issue fits the descriptions nearly perfectly. Built "Ford Tough" is apparently just a sales pitch. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S

- Fort Myers, FL, USA

I filed a complaint yesterday 5/4/24. The complaint number is #11586924. Yesterday I gave you the details of what happened with my transmission and when it happened. Today I want to give you the Manufacturer Comm. Number. From Ford Motor Co. the service number is SSM46069. It states that Ford knew there could be a problem with some 2015/2016 vehicles equipped with 6F50/6F55 transmissions built on 11/02/2015 and through 2/01 2016 may exhibit no reverse, 3rd and 5th gear. The service bulletin goes on to explain what would cause the transmission to fail and how to repair the damage. This tells me Ford should be responsible to the consumer. My safety concern is this; I was traveling at 30 - 35 mph when the tranny failed and, not knowing at the time, I lost 3rd, 5th and reverse gears. There was a noticeable decrease in my cars speed. At that speed, I was able to control my car and get stopped. Picture if I was on a 5 or 6 lane highway traveling at 60 - 65 mph and the tranny failed. The results could be deadly. I am sure I'm not the only owner that has had this safety issue. Kindly investigate this safety issue asap. Thank you.

- Williamsport, PA, USA

I own a 2016 Ford Explorer. My Wife and I bought the car In Jan. 2016. On April 20th 2024, I was on my way to work when a warning came on the dash that said "check manual" and displayed an open end wrench. The car hesitated and then continued on. I was not far from the Ford Dealership where I bought the car so I went there. The service writer was working that day so I left the car at the dealership and called for a ride. On 4/23/24, the service writer called me and said the transmission was shot and would need to be replaced. My bill would be approx $5954.81.

- Williamsport, PA, USA

I was driving and everything felt and looked normal. Out of the blue a pop noise, car was smoking. Had to have it towed. Mechanic said the transfer case blew like a grenade. It nicked my transmission as well. I was broke down in an intersection. No warning signs.

- Fillmore, UT, USA

While traveling at highway speed (55mph), the transfer case "exploded" resulting in catastrophic failure and fluctuating power and impaired driveability. Defect has been confrimed by independent local repair center.

- Tetonia, ID, USA

The transmission began slipping causing poor control at higher speeds using the cruise control or passing gear. Only about 42,000 miles on the vehicle and no financial help from Ford. Service for a new transmission was $7667.11at Dave Sinclair Ford, 7466 South Lindbergh, St. Louis Missouri, 63125. 314-892-2600

- Sunset Hills, MO, USA

I was driving and stopped in the left turn lane and the car wouldn't move. Had to have the vehicle towed and now I have to replace the transmission on a car that has 72,000 miles on it. There was no advance notice that there was a problem. I have the vehicle serviced regularly.

- Chicago, IL, USA

In August 2023, my vehicle began to make a popping noise and began to lose power when attempting to accelerate. It was diagnosed by the repair shop as a turbo going bad. I repaired the turbo. In December 2023, the check engine light came on. The repair shop indicated that the lifters and cam shafts were bad and caused scoring to the engine block, requiring the engine to be replaced. The repair shop asked if I had been changing the oil regularly. I indicated that I did change the oil per when the vehicle would notify me it was time. The repair shop noted that I changed the oil every 10k miles. Per the repair shop, not changing the oil regularly (because the Ford vehicle system designed to tell me when to change the oil) ultimately caused me to need to replace the turbo and the engine. All because the oil was not changed more frequently 3-5k miles per the repair shop. I've spent $15k in repair costs since August 2023 because I was relying on the Ford vehicle's notifications as to when it needed oil. The vehicle is not even worth this much blue book. For a 8.5 year old vehicle that has been well cared for, I do not think these parts should have failed and I think Ford should have set the timing for oil change notifications more frequently if this is what is needed by the engine to keep it in good repair. It literally indicates the % of time before the oil needs to be changed.

- Corona, CA, USA

The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as needed. The contact stated that when the accelerator pedal was depressed, the transmission started slipping. In addition, the vehicle was jerking abnormally. The vehicle was taken to the dealer several times and the contact was informed that the failure was due to transmission failure and the contact was informed that the repair had been completed; however, the contact was unaware of the diagnostic results. The vehicle was repaired. The failure reoccurred and became persistent. The contact stated that the failure had been ongoing since the purchase of the vehicle in 2017. The contact was informed after each failure that the vehicle had been repaired. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.

- Walnut Grove, MS, USA

The contact owns a 2016 Ford Explorer. The contact stated that when the vehicle was shifted into drive(D), the vehicle started shaking abnormally. The vehicle was taken to an independent mechanic where it was diagnosed with a failed transmission and that the transmission needed to be replaced. The contact was informed about TSB: [XXX]. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 110,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Everett, WA, USA

The explorer started having issues with the heater not working when stopped. After some research it recommended that we check the coolant level. The coolant was low. Then we refilled it and then it happened again 3 weeks later and the coolant was low. This made us believe there was a coolant leak. After removing the bottom cover under the car it was saturated with coolant with drops coming from various areas on the passenger side. We took it to a mechanic and then transferred to a dealer and both confirmed it was the water pump. Ford negligently designed the water pump within the engine with the timing chain. If enough of the coolant mixes with oil it will cause the engine to seize and the car to shut off. I have two little kids that are in the car with me. This negligent placement can lead to cars seizing in unsafe areas. It was confirmed by a private mechanic and a ford dealer and there were no warning lights. Other than the heat not functioning properly there we no other signs or lights of water pump failure.

- Las Vegas, NV, USA