10.0

really awful
Crashes / Fires:
6 / 4
Injuries / Deaths:
0 / 0
Average Mileage:
34,065 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2016 Ford Explorer:

Unsubscribe any time. We don't sell/share your email.

problem #193

Sep 212024

Explorer

  • miles
Transmission slips in and out of gear while driving causing loss of power. Many complaints online about this same issue from others.

- Laurel, MD, USA

problem #192

May 052025

Explorer

  • miles
I experienced two failures associated with other model years. The first was the right side A-pillar trim. It pulled free on the highway. I noticed it fly off and was able to recover the majority of it. It smashed on impact and there is a large piece missing. The remaining piece is available for inspection upon request. The A-pillar exterior trim flew off on a one-lane section of divided highway, there would have been no place for anyone to go if it flew back and there was a car behind me. This problem is a known issue I found out about on this (NHTSA) website. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others" No, it flew off on the highway and has not been reported yet. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear" No warning at all that this was going to break loose. I also have an issue with the PTU. I was driving home from the airport and at a a stoplight, I noticed a ticking noise when I stopped at the exit of the parking lot. I noticed it again closer to home, after a fifty mile drive. When I stopped on the off ramp from the highway, I noticed smoke coming from under/behind my explorer. It smelled like antifreeze, but when I arrived home, and checked under the vehicle, I found black residue on the PTU and what looked like leaks from the axle seals that were not there for the last five months I've owned the vehicle. The vehicle smoked heavily when I stopped on the exit ramp, and when I went to accelerate into the traffic round-about, the vehicle lagged before moving, with an audible clunk and a lurch when it finally moved. Any reasonably hard acceleration produces a noise and will usually lag before moving. It may make a ticking noise when at idle cold, but is more pronounced the hotter the drivetrain gets. I had an OBD II scan done with no codes produced.

- New Salem, MA, USA

problem #191

Mar 302025

Explorer

  • 168,000 miles
The contact owns a 2016 Ford Explorer. The contact stated that while attempting to reverse, the accelerator pedal was depressed; however, the vehicle hesitated while responding. The contact stated that after several attempts to depress the accelerator pedal, the vehicle responded as intended. The contact stated that a dealer was not contacted. The vehicle was not taken to be diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The contact related the failure to NHTSA Campaign Number: 20V692000 (POWER TRAIN); however, the VIN was not included in the recall. The approximate failure mileage was 168,000.

- Betsy Layne, KY, USA

problem #190

Oct 152024

Explorer

  • miles
Transfer case replacement. Open recall on 2016 4x2 ford explorera for faulty transfer case but not recalled on 4x4 models. This is BS as the transfer case used for both models are the exact same. Should be covered under already open recall for transfer case.

- Gilbert, AZ, USA

problem #189

Mar 182025

Explorer

  • miles
I have already filed a complaint about the transmission issues of my vehicle a few months ago. Ford will not take credit and help me so we had to keep driving it. Hard shifting, slipping, losing reverse, losing power and jerking into gear. Now not only has it nearly killed us twice when we went to pull into traffic, it has jerked into gear and locked up throwing the car into a guardrail and causing an accident while my fiancée was driving it. I reported it was unsafe and no one did anything, now I have a wreck vehicle, fighting with insurance about the safety of it and it-??s sitting at a body shop. We are all afraid to drive it. It nearly killed my family and no one cared to help us. Plus we have no vehicle to drive now. Thank you FORD for nearly killing my family and making us feel unimportant in every way possible. Plus NHTSA did nothing when I filed my first complaint!

- Doswell, VA, USA

problem #188

Nov 192024

Explorer

  • miles
My vehicles wrench sign would turn on do a little jerk then I would lose power to my car. Showed malfunction to power train. Took it to mechanic said there was a Crack in the valve gasket and they fixed that and changed spark plugs. A month later car did the same thing. Has done it a total for 4 times very scary when on a high way and it does it and I have to pull over with traffic coming. Took it to another mechanic and he couldn't figure it out either because there are no codes but said he seem something similar and I needed to change all my coils. So I did that. Thousands of dollars later and no one can still figure out the problem. I don't know if it's some safety issue with the engine or transmission. But 3 certified mechanics can not figure out why my car continues to lose power.

- Hammonton , NJ, USA

problem #187

Mar 072025

Explorer

  • miles
The second time my water pump has gone out in this vehicle. Causing over heating of the car and unrepairable wiring. Ford needs to get it right for us 2016 Ford Explorer owners. They [XXX] when it came to this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Tuscaloosa, AL, USA

problem #186

Mar 052025

Explorer

  • 57,770 miles
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact heard a loud sound coming from the engine compartment. There was no warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed that the lower transmission and bolts had failed and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 57,770.

- Evergreen Park, IL, USA

problem #185

Oct 012023

Explorer

  • 102,000 miles
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, the engine overheated with the temperature gauge indicating that the engine was hot(H). The vehicle was taken to an independent mechanic where the water pump was replaced. The contact stated that several months later while in reverse(R), the vehicle failed to accelerate while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was towed to the dealer for a diagnostic test and remained with the dealer for months. The contact was informed that the vehicle had failed to accelerate while in drive(D) or reverse(R). The dealer later diagnosed the vehicle with transmission failure and the contact was provided an estimate for the repair. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle was towed to an independent mechanic where it remained unrepaired. The failure mileage was approximately 102,000.

- Queensbury, NY, USA

problem #184

Feb 252025

Explorer

  • miles
Ptu burnt out less than 53k miles. Molding on passenger side broke off while driving 60mph struck another vehicle causing to other vehicle to leave road. Thank God no one was injured. This thing could have killed a motorcycle driver. Checked online and there are thousands of reports of same molding breaking off while driving.ford tn# does not recognize and disconnects call.

- Ellensburg, WA, USA

problem #183

Jan 312025

Explorer

  • 108,000 miles
The contact owns a 2016 Ford Explorer. The contact stated while driving 10 MPH, the message to service the vehicle was displayed. The contact pulled over and turned off the vehicle, and waited for several minutes before restarting the vehicle and the message was no longer displayed. The contact stated that while depressing accelerator pedal, the vehicle failed to respond as needed. A dealer was contacted. The vehicle was taken to an independent mechanic where it was inspected to see if there were any leaks coming from the transmission. The contact called the Bob Johnson Auto Group to schedule an appointment for a diagnostic test. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 108,000.

- Conesus, NY, USA

problem #182

Dec 202024

Explorer

  • 50,000 miles
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle jerked while shifting into gear. The contact stated that upon shifting to drive(D) on several occasions, the vehicle failed to respond. There was no warning light illuminated. The vehicle was taken to the dealer, where the transmission was replaced. Additionally, the contact stated while driving 25 MPH, the vehicle shuddered, overheated, and stalled. There was no warning light illuminated. The contact was able to pull to the side of the road. The vehicle failed to restart and was towed to the residence, where a mobile independent mechanic diagnosed that the head gasket was blown. The vehicle was not repaired. The dealer was notified of the failure, but no assistance was provided. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 50,000.

- Baltimore, MD, USA

problem #181

Dec 162024

Explorer

  • 157,627 miles
The contact owns a 2016 Ford Explorer. The contact-??s spouse stated that while driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was not able to be restarted. The vehicle was towed to an independent mechanic where it was diagnosed that the link shaft bracket had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in NHTSA Campaign Number: 20V692000 (Power Train). The manufacturer referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 157,627.

- Ozark, AR, USA

problem #180

Aug 292023

Explorer

  • miles
There has been an ongoing issue with my vehicle since it was last taken to service for a recall. The transmission has premature failure. I have had the entire vehicle powertrain fluids changed and nothing has helped. My boyfriend has been driving the vehicle and will not let me drive it anymore because it is unsafe. The transmission has torque converter issues. It has got stuck in second gear and when we went to pull out into traffic it would not move and we nearly got T-Boned. That happened while I was with him and I'm afraid to use it. He has to drive it to work because I have his vehicle and he wants me and my daughter to be safe. He says its downshifting hard when slowing down. It will downshift hard and loose power when trying to speed up on the interstate or while trying to get on the interstate. It shifts hard into reverse and is delayed shifting. Its lost power due to the transmission slipping. There has never been any check engine lights come on. Ford will do absolutely nothing about it. The vehicle has around 62,000 miles on it now and its gotten worse and is going to cause an accident or kill someone. I have called ford several times and they don't seem to care. They want me to go have it fixed and pay for it. I don't have that kind of money and I should not have to pay for there problem. Its a known issue I found out by searching online, even lawsuits. They need to recall these transmissions and fix the issue with them before someone is killed. If there hasn't already been deaths. Its unsafe. It has put me and my daughter at risk. Other drivers at risk and now with him having to drive it, his life is at risk everyday! Ford does not care about people or their family. They know they put a bad transmission in these vehicles and it cause premature wear. The transmission fluid is black, smells burnt and even metal shavings in it. Its a ticking bomb and its unfair they want me to pay for their mistakes!

- Doswell, VA, USA

problem #179

Apr 152024

Explorer

  • 85,000 miles
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, the check engine warning light illuminated, and the vehicle failed to properly accelerate while depressing the accelerator pedal. The vehicle was taken to the local mechanic who diagnosed that oil from the turbo booster had leaked onto the catalytic converter and both the turbo booster and catalytic converter needed to be replaced. The vehicle was not yet repaired. The contact indicated that previously the power transfer off unit was faulty, causing the vehicle to suddenly lose accelerating power; and the front control arms and ball joints were replaced. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 85,000.

- New Albany, OH, USA

problem #178

Jun 262024

Explorer

  • 156,000 miles
The contact owns a 2016 Ford Explorer. The contact stated while driving 50 MPH, the vehicle made an abnormally loud grinding sound. The contact stated that the front end of the vehicle seized, and the vehicle started rolling. The contact was able to pull to the side of the road and noticed that the gear box had blown out. The vehicle was towed to the dealer, where it was diagnosed that the gear box had fractured and damaged the transmission front assembly. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 156,000.

- Columbia City, IN, USA

problem #177

Aug 262024

Explorer

  • miles
Randomly whilst driving, my dash had multiple error messages pop up and my power steering went out completely. The error messages were as follows: Service AdvanceTrac, Terrain Management System Fault, Hill Start Assist Not Available, & Power Steering Assit Fault. This keeps happening intermittently, while I am driving. This causes a serious safety issue, for my steering wheel to lock up while I am driving! I did get the codes for the errors and they are as follows: U0420-41, C0051-67, U0151-00, U0131-00. My ABS system failed check, as well. This is a known issue with Ford vehicles, as there have already been recalls for previous models. According to [XXX]: "Ford has recalled earlier model year Explorers with power steering problems before. In 2014, Ford recalled certain model year 2011-2013 Ford Explorers, saying these vehicles -??may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting a shut down of the power steering assist.-?? According to Ford, this issue -??may increase the risk of a accident.-?? In 2015, Ford recalled certain model year Ford Fusion, Ford Taurus, Ford Flex, Mercury Milan, Lincoln MKS, Lincoln MKT, and Lincoln MKZ vehicles. According to Ford, these vehicles had -??electric power steering assist systems that may shut down as a result of a steering motor sensor fault.-?? As a result, -??[i]f the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash-??. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Warren, MI, USA

problem #176

Aug 262024

Explorer

  • 102,000 miles
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle was experiencing significantly rough idling while in drive(D) or while in reverse(R). Additionally, the contact stated that while accelerating from a complete stop, the vehicle jolted and hesitated to respond. The contact also stated that the vehicle shuddered while driving at various speeds. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the failure was related to TSB Number: 20-2271. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the TSB was superseded and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 102,000.

- Locust Grove, GA, USA

problem #175

Aug 232022

Explorer

  • miles
My car started shaking while i stopped (like at a red light, stop or traffic) I had it diagnosed ($175) and was told it needed to have the transmission changed, my explorer was 6 yrs old with less than 50k miles. I have never hear of that happening as the car well kept. New transmission cost me $5585.40, it seems that every year this car has a new problem. I feel so ripped off this shouldn't happen on a $50k car.

- Annandale, VA, USA

problem #174

Jul 152024

Explorer

  • miles
The torque converter failed in my explorer while driving, making it act like it was in neutral. Luckily I was on a small road with little traffic, and able to pull over to a side street before my car was complete undrivable. If this happened on the highway or while turning, it probably would have cause a major issue or accident. NO warning lights on my dash and NO problem codes reported on OBD scanner tool. Ford has put out their own CSP for this issue a while ago and when I asked about it they told me it was expired. How can something they know is an issue expire? Dealership repair confirmed it was the torque converter and has to rebuild the transmission. I even found a service bulletin ford release about this problem, so they know about it.

- Kennesaw, GA, USA

Read the next 20 complaints »