The contact owns a 2016 Ford Explorer. The contact stated that while at a complete stop, the vehicle was shifted into drive(D) and the brake pedal was released; however, the vehicle started shuddering and jerking significantly. Additionally, the contact stated that the vehicle hesitated to shift into the intended gear while driving. The contact stated that the failure had been recurring while driving. The check engine and the power train warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The contact stated that the insurance company later informed her of Ford Campaign Number: 20B27, which she related to the failure. The dealer was notified of the failure. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under the Campaign. The manufacturer referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 121,000.

- Sandy Springs, GA, USA

The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 70 MPH, the temperature gauge indicated that the engine was overheating. The check engine warning light was illuminated. The vehicle was towed to the dealer who determined that the water pump had failed and needed to be replaced. The vehicle was repaired. Approximately, a year and half later the failure reoccurred; however, the vehicle had not been repaired a second time. The manufacturer had not been made aware of the failure. The approximate failure mileage was 90,000.

- Pembroke, NC, USA

Hello, I have a 2016 Ford Explorer Limited with VIN [XXX]. I have 90k miles on it and my water pump failed like it did for many many people for this model. This is a systemic issue at this point and I don't understand how there is not a recall for this issue with Ford. The cost to repair this issue is at more than $4k. This is a basic design issue that must be addressed by Ford. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Mount Prospect, IL, USA

water pump blew up at 120k miles, motor locked up leaving me in the middle of the road

- Three Rivers, MI, USA

The contact owns a 2016 Ford Explorer. The contact stated while driving 2 MPH, the vehicle hesitated while accelerating and the engine was misfiring. The wrench warning light was illuminated. The vehicle had been diagnosed with transmission failure. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 108,000.

- Portland, OR, USA

Water pump is leaking. Since it-??s in the engine I can-??t find any mechanic to work on it. The dealership will be Atleast 3k to replace a water pump.

- Huntsville, AL, USA

3.5 Duratec 3.5 Water Pump has failed by leaking fluid. Fluid may have entered oil system. If this is not a design flaw, I don-??t know what is. Just stupid!

- Ocala, FL, USA

The water pump failed. The engine overheated and the coolant leaked, causing the engine to overheat. This resulted in the vehicle stalling out in traffic which could have led to an accident. Also, the AC was not working properly which might have caused overheating of passengers. The problem has been diagnosed by an independent service mechanic, they are replacing the water pump, which is an extensive and expensive repair. They informed me that Ford Explorers in this year are known to have this common defect. The engine overheating alert came on while driving. But at this point, this damage was already done.

- Midlothian, VA, USA

On 7/26/2023 the vehicle started a little rough in the morning. At start up the engine light came on. The vehicle was driving fine except for rough morning start. I took the vehicle to a Ford Dealer but was told I'd have to schedule appointment. At the time I was told that if the engine message wasn't flashing it wasn't too serious. After I left Ford I made a quick stop at Jiffy Lube just to get confirmation. They put the computer on the vehicle and spark plug #3 was misfiring and just needed a tune up. On 8/04/2023, a tune up was performed by a local mechanic. Vehicle seemed fine for the next day or two. On Monday 8/7/2023 the engine light came back on. The vehicle was taken back to mechanic on 8/8. The mechanic could not determine cause but believed it may be a fuel pump issue since the cold start seems to prompt engine light warning. I picked up the vehicle on 8/9/23, the mechanic told me to take it to a Ford dealer. On 8/10, I called Ford Dealership, they scheduled appointment for Monday 8/14/2023. Dealershiper called me and informed me I needed a new long block, fuel pump and pressure test. I did not approve the $15,000 repair. The dealership informed me coolant was leaking into engine.

- Drexel Hill, PA, USA

Water pump failure

- Sioux Falls , SD, USA

The contact owns a 2016 Ford Explorer. The contact stated there was an unknown fluid leaking underneath the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer and the contact was informed that the internal water pump was leaking and that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 12,000.

- Hudson, WI, USA

The contact owns a 2016 Ford Explorer. The contact stated while driving at approximately 50 MPH, there was a loud grinding sound coming from the engine compartment. The check engine warning light was illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the timing chain needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 108,000.

- Inver Grove Heights, MN, USA

The contact owns a 2016 Ford Explorer. The contact stated while cold starting the vehicle, the check engine warning light was illuminated. The contact stated that the vehicle seemed to be operating normally; however, the check engine warning light remained illuminated. The contact stated that after a week with the check engine light remaining illuminated, the vehicle was driven to a local dealer where it was diagnosed and determined that the long block needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21N12 - Short Block Replacement After Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 72,000.

- North Potomac, MD, USA

Coolant, water pump, and timing chamber. Last year I had it replaced for $1,800 not knowing this is a common issue for the make and model. Never received any info concerning a recall about this issue or other recalled issues. In 1yr the water pump has malfunctioned again causing the engine to overheat and oil leakage.

- Greenville, SC, USA

The contact owns a 2016 Ford Explorer. The contact stated that while attempting to shift the gear shifter into park(P), the transmission failed to shift as needed. The contact stated that the transmission would only shift into reverse(R). An independent mechanic flipped an unknown switch, and the contact was able to drive her vehicle to her residence; however, when the contact attempted to shift the transmission into park(P), the transmission would only shift into reverse(R). The contact's son flipped the switch, and the contact was able to shift the transmission into park(P). Additionally, the check engine warning light illuminated intermittently. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 152,000.

- Oconee, IL, USA

The waterpump of the vehicle causes excessive leaking which causes the vehicle to overheat.

- Sebring, FL, USA

I was driving my vehicle only a month after getting oil change and service. I was confident my vehicle was in good condition as it had passed the inspection. I suddenly noticed the temperature needle was rising. I immediately pulled over and asked for help and was told i needed water. My water pump was not working.

- Houston, TX, USA

Coolant leaking, could be water pump issues? Also foul order inside vehicle. I just bought this so I don't know when these problems started. I have not taken it to a shop yet

- Priest River , ID, USA

Everytime my ac/heat is on it affects my engine as I-??m driving. My speedometer fast jumps. As soon as I turn it off it seems to run better. I made a complaint a week ago about something going on with my fuel and fan running high speed. I have a foul smell in my car. I thought for awhile it was something outside but now I believe it-??s coming from my car. It smells like fuel/rubber/sewer if that makes sense.

- Youngstown , OH, USA

Took 2016 Ford Explorer in for an oil change. Was informed that there is an Engine Water Pump leak and needs replacement. There were no warning lights or notifications. Concerns are a malfunction of only vehicle available to me and my family.

- Naples, FL, USA