The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

- Corpus Christi, TX, USA

25,000 miles on it, transmission failed on my husband and I as we were pulling out onto a busy street. The car jerked forward and shot us out half way before locking completely as a semi truck was coming and almost smashed into the side of us. Luckily we were on a hill and were able to put the car into neutral & was able to roll back at the last second before we were severely injured. Car was towed to dealer as it would not drive at all. Dealer had for 3 weeks before coming back and saying the fluid was low and discolored and had several burnt clutches..again only has 25,000 miles on it..replaced the clutches and told me I was good to go. 7,000 miles later car AGAIN jerks me as im on a busy street and then completely loses all power and will not accelerate, I was barely able to pull over into a business parking lot before almost getting rear ended because I was going 30mph UNDER the speed limit!!! I didn-??t even have to exit my vehicle because I could smell the burnt trans fluid from inside the cabin! Getting towed to dealer in 2 days.. this is a MAJOR SAFETY CONCERN! I have almost gotten hurt TWICE by this defect with the 10r80 transmissions! This is serious and ford needs to start addressing this problem before someone seriously gets hurt!!!!

- Frankfort, IL, USA

When shifting from drive to reverse, there is a significant lag in shifting (3-5 seconds). This is especially dangerous when needing to back into a driveway from a busy road.

- Cedar Rapids, IA, USA

I hope this letter finds you well. I am writing to you regarding a persistent issue I have been experiencing with my 2021 Ford Explorer For some time now, I have noticed a loud sound when braking and when navigating obstacles such as speed bumps or when entering and exiting the ramp of my parking lot. Concerned about this situation, I took my vehicle to the service department at your dealership, where I was informed that there was a recall to replace a part related to this issue. I appreciate that you have identified and committed to addressing this problem through the recall. However, I am concerned that despite more than one or two months having passed since my initial visit, I have still not received any notification regarding the availability of the necessary part for the repair. This delay has been particularly frustrating as the problem persists and even seems to have worsened over time. The loud sound when braking and navigating obstacles is becoming increasingly pronounced, significantly affecting the driving experience and my safety on the road. I understand that manufacturing and distribution processes can be complicated, but I need an urgent solution to this problem. As a loyal customer of your dealership, I trust that you will take the necessary steps to resolve this situation quickly and effectively. Since my vehicle is my primary means of transportation, I strongly request that you expedite the repair process and keep me informed of any developments related to the recall and the availability of the necessary part. I look forward to receiving a prompt response and a satisfactory solution to this problem. I appreciate your attention and prompt action in addressing this matter.

- Kissimmee, FL, USA

My vehicle started to put up messages regarding going into power saver mode. The vehicle then said all wheel drive not available. After that electrical components started going unavailable such as power steering, brake assist, blind spot monitoring, cameras, and traction control. The vehicle then shut down while driving and all I could do was brake. When I attempted to restart the vehicle it did not restart. I jumped it and was able to safely pull it off the road. This is the 2nd time in three weeks this happened. Ford looked at the vehicle and tightened the battery cables. Then told me it was fine.

- Aliquippa , PA, USA

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time to for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

- Santa Ana, CA, USA

While making a left turn on a city street there was a loud bang noise and a sudden shift of the rear of the car. The bang noise was immediately followed by a loud grinding noise (sounded like metal on metal). There was a sudden loss in power, and I was only able to drive the car a short distance to get to the side of the street. When the car was put in park, the car rolled downhill without resistance. The car was towed to a Ford dealer for repairs. The dealer's repair shop drained the fluid from the rear differential and found "large chunks of metal." The repair required the replacement of the rear differential. Had this event occured on a busy street, it could have resulted in a vehicle accident. The loss of vehicle control when the vehicle was placed in "park" could have also been a safety risk. This event is similar to the Ford recall of the Explorer for a rear axel bolt fracture (NHTSA recall 23V-199 and 22V-255). My vehicle VIN # has not been added to the recall list, therefore, Ford has refused to consider reimbursement for the cost of the repairs. I would like the NHTSA to consider adding my VIN# to the recall for this design defect.

- Cottonwd Hgts, UT, USA

The startrover run clutch or whatever went out and they said it was bumper to bumper, not powertrain warranty! Don-??t make any sense to me, the starter has to dtart everthing for there to be power and it-??s attached to everything that-??s powertrain related!

- Brandenburg , KY, USA

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

- Loranger, LA, USA

P25B4- turbocharger/supercharger waste gate (a) stuck closed P0299- turbocharger/supercharger underboost powertrain and 4-wheel drive in-operable, turned on vehicle to drive and immediately threw the two codes above. Ford says this is not a covered issue.

- Kansas City, KS, USA

The contact owns a 2021 Ford Explorer. The contact stated that while reversing, the vehicle suddenly shifted into park, after which the vehicle went into LIMP mode. After restarting the vehicle, the vehicle was unable to shift out of park and displayed the "Automatic Emergency Braking Unavailable" message. The traction control, start-to-stop, and hill start assist warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 30,500.

- Clarksville, TN, USA

The contact owns a 2021 Ford Explorer. The contact stated that while attempting to accelerate after coming to a complete stop, the vehicle briefly lunged forward. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V675000 (Power Train) the VIN was included but parts were not yet available. The manufacturer was not notified of the failure. The failure mileage was 15,000.

- Port Hueneme, CA, USA

The contact's daughter owns a 2021 Ford Explorer. The contact stated that while his daughter was driving from a complete stop in a parking lot, the vehicle stalled. A message indicating a transmission failure was displayed. The vehicle failed to restart and was towed to an independent mechanic. The vehicle was not diagnosed and was towed to the dealer to be diagnosed. The dealer informed the contact's daughter that a diagnostic test cost would be charged because the vehicle was out of warranty. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 46,000.

- Stafford, VA, USA

A Police Officer's Ford Explorer Interceptor Hybrid SUV while driving had a vehicle malfunction where the rear wheels began to wobble/vibrate and while driving in a straight line with front wheels facing straight caused the vehicle to fishtail out of the control (loss of control to the rear wheels) and slam into a tree at approximately 50mph injuring the officer. Officer's injuries were broken left leg and two knee fractures. Upon further research, this incident may have been caused by the "rear bolt" fracture issue Ford is having with these specific Ford Explorers. This specific vehicle is under recall per the VIN. The Officer's safety was put at risk because the vehicle was most likely not recalled and fixed per the recall. The vehicle has not been inspected by manufacturer or any qualified/certified individual. No other issues or symptoms were present prior to this incident. The vehicle is available for inspection upon request with the BART Police Department in Oakland, CA.

- Antioch, CA, USA

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

- Palm Springs, CA, USA

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V735000 (Back Over Prevention), 22V255000 (Power Train), and 23V675000 (Power Train) however, the parts to do the recall repairs were not yet available. The local dealer was contacted and determined that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

- Elkmont, AL, USA

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

- Naples, FL, USA

UNKNOWN My rear axle bolt may fracture. and this repair still has not been done. and Ford doesn't know. when the part will be in, I'm in fear. for my safety.

- Bedford Hts, OH, USA

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V635000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

- Mint Hill, NC, USA

The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving approximately 60 MPH, the vehicle started to vibrate. The contact stated that there were no warning lights illuminated. The contact stated that she drove the vehicle to a dealer and was informed that the failure could not duplicated. The vehicle had not been repaired. Additionally, the contact stated that when the vehicle was shifted into park(P), the parking brake automatically activated, and the contact did not manually set the parking brake. The failure mileage was approximately 28,000. VIN tool confirms parts not available. The contact took the vehicle to recall repaired and adjustments needed from the previous recall. The dealer stated the recall repair could not be done because they did not have the tool to perform the repairs. When the vehicle was delivered, it was detached from the part of the third row seats.

- San Juan, TX, USA