10.0
really awful- Crashes / Fires:
- 1 / 5
- Injuries / Deaths:
- 2 / 0
- Average Mileage:
- 106,026 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
Hello: My Ford 150 extended cab rear door do not open. I took it to a Ford dealership and they told me the latches are broken. I did not have it fixed due to a possible recall issue. Thank you.
- Fair Oaks, CA, USA
Dear NHTSA: Re: VIN# [xxx] my Ford 150 extended cab back doors latches have failed. The two back doors do not open. At first, I thought the rubber that runs along side the trim was caught, but when the second door stopped opening I took it to a Ford dealership and he said there are two latches on each door, a bottom latch and a top latch. Both top latches have failed and now I cannot open the two back doors to my Ford truck. The first door(driver side door) went out in November of 2019, and the second door stopped opening last week. Who is responsible for this? I am sure it will be expensive to take the doors off and replace the latches. Thank you for your time and help. Sincerely, [xxx] information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).
- Fair Oaks, CA, USA
Frame bent due to unseen corrosion. This happen when truck was on a lift for repairs to the transmission lines. Mechanic had no way of knowing. Vehicle spent half its life in Arizona where no salt is used on the roads
- Chesterland, OH, USA
On 9/4/2018 I bought 4 brand new destination LE2 P-metric OWL P265/75R16 tires with a 60000 warranty from Firestone in hesperia ca. My daughter just bought the truck and I wanted her to be safe with new tires.on November 14, 2018 on her way to work at 5:00 a.M she had a terrible roll over. She is currently in icu. She just had a cranioplasty 15 days ago. She has a severe tbi. She hasn't walked since the day of rollover. She was on life support. Still on tracheostomy. She will be disabled all if her life. She is 22 years old. She was driving approx. 55 mph. She was out of control when all three witnesses saw her coming at them. This happened on summit valley rd in hesperia ca. It is one lane each direction. She was approaching th top of a hill. When she got over the hill she was out of control and the vehicle rolled and she was ejected. She was found under the truck. The tires had less than 5,000 miles on them. Please don't buy these tires. I am still not sure if she will survive this. I am so heartbroken I can barely move.
- Hesperia, CA, USA
Gas tank fell out of vehicle, tearing filler hose. Tank straps and supporting structures rust thru, failure. Drivers' side rear shock dropped from vehicle because metal bracket it was attached to rotted thru. Bed rails completely rusted thru. Frame has rusted thru holes. Complete rust failure. Vehicle has only 90K miles always maintained, washed underneath weekly in winter. Vehicle in motion when parts fell on rte 58 and the shock on town street..$900 to repair gas tank. Shock incident happened today 11/26/2017, gas tank 9/12/2016
- Brockton, MA, USA
Paint is peeling off of the roof, the rear of the cab, the passenger rear door, and from the fuel door.
- Kennewick, WA, USA
There has been no incident as yet but the frame of this vehicle has such extreme corrosion that certified mechanics are reluctant to work on this vehicle since they are concerned about a failure occurring at connection point where the steering and suspension connects to the frame of the vehicle. Their concern is a loss of control of the vehicle if any of the steering or suspension connection points fail due to the severely corroded frame. This is not surface corrosion, the metal is flaked and separated and it is the entire frame of the vehicle. I had just spent $4,000 to replace the entire exhaust system from the exhaust manifold back to the tail pipe and the mechanic is warning me about the safety of the suspension and steering components because of the extreme corrosion. The vehicle only has 77, 000 original miles and has never been in severe weather conditions.
- Washingtonville, NY, USA
The frame rails just in front of the rear wheels rust/rotted and the vehicle snapped in two pieces. Similar to the failures covered by Toyota recall for the Tundra of the same model year. The vehicle was being raised on a lift for an oil change. Not a spec of rust on the body anywhere.
- Mason City, IA, USA
I have a 2001 Ford F-150 that I purchased brand new in 2001. I have noticed that the entire frame is rusted and I am concerned about the structural integrity of the truck. It has already had the gas tank strap recall fixed. I found several spots that look as if the frame is deteriorating from rust.
- Kearney , MO, USA
The contact owns a 2001 Ford F-150. While driving at any speed, the vehicle made an abnormal noise. The vehicle was taken to a mechanic where it was diagnosed that the panel radiator support was rusted and fractured. The dealer was not able to repair the vehicle and recommended it be taken to a body shop. The contact took the vehicle to the body shop, but the vehicle was not repaired. The failure mileage was approximately 133,000.
- Bellvelleville, WI, USA
Door release handles on both rear doors failed to open within a month apart which would have trapped the rear seat passengers. The cable and latch assemblies had to be replaced.
- Crossville, TN, USA
I parked, walked inside...moments later the truck was on fire..
- New Orleans, LA, USA
Woke up this morning to a couple of loud "booms". my husband went to check it out and discovered his truck (which we just purchased in may) was on fire. The fire destroyed the truck, melted the siding on our house and garage, and even cracked three of our neighbor's windows. We are so grateful the firefighters arrived when they did or this fire would've kept burning our house. The truck hadn't moved since last night...don't know what happened but we will not be purchasing a Ford again.
- North Platte, NE, USA
Severe corrosion issues.
- Parkersburg, WV, USA
I was driving northbound on I-95 when the driver of an adjacent vehicle alerted me that there was fire shooting out from the area of the fuel filler door. I immediately pulled over onto the highway median and jumped out. The truck was engulfed in flames, and the cab was on fire. I burned myself on the melting steering wheel and was singed by melting plastic.
- Tamarac, FL, USA
The contact owns a 2001 Ford F-150. The contact stated that the instrument panel lighting and headlights would not illuminate. The vehicle was taken to the dealer for diagnosis where the technician stated that water was entering the vehicle through the A-piller and was leaking onto the ECM. The manufacturer was not made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 59,900.
- Iron Station, NC, USA
The contact owns a 2001 Ford F-150. The contact stated that the rocker panel was severely rusted. The vehicle was not repaired. The manufacturer was not notified of the defect. The approximate failure mileage was 86,000.
- Cleveland , OH, USA
The contact owns a 2001 Ford F-150. The contact stated that when driving at various speeds, attempting a turn or traveling over a road bump, the vehicle would sporadically emit a metal-to-metal dragging noise. The contact inspected the vehicle and found that the support for the radiator was fractured, causing the radiator to sway while driving. The vehicle was taken to an independent mechanic who confirmed the diagnosis. The manufacturer was made aware of the failure. The vehicle had not been repaired. The failure and current mileage was 201,000. Updated 07/23/13
- Noblesville, IN, USA
At approximately 50+ mph the front of the car shakes. This has been going on for almost over an year. I took it to the dealership, said nothing is wrong. It starts to shake so bad that you have to let up on the accelerator and almost stop, before you feel safe enough to continue on. Shaking is the worse for the first 3 miles at the start of the day but never seems to completely goes away.
- Cromwell, CT, USA
- Sharpsburg, GA, USA