The contact owns a 2011 Ford F-150. The contact stated while driving 50 MPH, the vehicle inadvertently downshifted and the vehicle would stall with the wrench warning light illuminated. The contact restarted the vehicle, but the failure persisted. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 114,000.

- Parrish, FL, USA

The contact owns a 2011 Ford F-150. The contact stated that on two occasions while driving at approximately 45 MPH, there was a clunking sound, and the vehicle inadvertently downshifted into first gear. The transmission warning light was illuminated. The vehicle was taken to the residence where a hand-held diagnostic machine retrieved DTC code: P0722 (Output Shaft Speed Sensor Circuit no Signal). The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 194,285.

- Walsh, IL, USA

The contact owns a 2011 Ford F-150. The contact stated that while driving at an undisclosed speed, the maintenance warning light illuminated. The contact became aware that the transmission had independently shifted several times. In addition, all the instrument gauges had dropped to zero. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that an appointment was scheduled for the vehicle to be diagnosed. The manufacturer was made aware of the failure and a case was filed. The contact was informed of an unknown recall however, the contact was informed that the recall had expired. The failure mileage was approximately 77,000.

- Tacoma, WA, USA

My vehicle, a 2011 Ford F150 with a six cylinder engine and automatic transmission, recently began experiencing "UNEXPECTEDLY DOWNSHIFTING INTO 1ST GEAR WHILE IN MOTION" AND HAS ALREADY CAUSED A LOSS OF CONTROL IN HEAVY TRAFFIC. While I was able to avoid an accident, this is a serious safety issue. It is noted that NHTSA has recalled 1.3 million Ford F150 vehicles for the years 2011 - 2013. My particular VIN [XXX], was not included. How do I get a Recall letter to have my vehicle declared a recall and get it repaired. The vehicle is experiencing the same problem as those already recalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Rio Rancho, NM, USA

Was in 6th gear(on a 6speed transmission) and immediately my truck downshifted to 1st gear causing my back tires to lock up and almost crash into a median. This is due to a CSP that Ford no longer offers to fix because it "expired".

- Saint Charles, MO, USA

The contact owns a 2011 Ford F-150. The contact stated while driving at various speeds, the transmission was slipping between gears with an unknown warning light illuminated. The contact stated that when the failure occurred, the transmission intermittently became inoperable but then regained normal functionality. The vehicle was taken to a local dealer; however, the vehicle could not be repaired under Customer Satisfaction Program: 19N01 (Transmission Molded Leadframe Extended Coverage) because the campaign had expired. The manufacturer was made aware of the failure and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 199,000.

- Corbin, KY, USA

Unexpectedly downshifted to first gear from 4th gear.

- Lewiston, ID, USA

The contact owns a 2011 Ford F-150. The contact stated while her husband was driving approximately 60 MPH, the vehicle lost motive power. The contact stated that the vehicle decelerated to 20 MPH and the vehicle was driven to an independent mechanic. The contact stated that the independent mechanic diagnosed the vehicle and determined that the molded leadframe had failed. The contact's husband was advised by the mechanic that the manufacturer had a Customer Satisfaction Program: 16N02 - Molded Leadframe Extended Coverage (Power Train). The contact stated that the vehicle was not taken to a dealer. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 146,000.

- Benbrook, TX, USA

The contact owns a 2011 Ford F-150. The contact stated while driving at 55 MPH, the accelerator pedal was depressed; however, the vehicle did not accelerate as intended. In addition, the check engine warning light was illuminated. The contact turned off, restarted the vehicle and continued to drive. The contact noticed a loud sound coming from the vehicle. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The vehicle was then taken to an independent mechanic where it was diagnosed with a failure of the onboard speed sensor and the onboard speed sensor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 214,000.

- Trivoli, IL, USA

The contact owns a 2011 Ford F-150. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. Additionally, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a failed transmission module. The contact was informed that the transmission module needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the independent mechanic where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 129,000.

- Florissant, MO, USA

The contact owns a 2011 Ford F-150. The contact stated while driving 50 MPH, the speedometer became inoperable, the vehicle hesitated to respond while depressing the accelerator pedal, and the vehicle shifted sluggishly into gear. The check engine warning light was illuminated. Additionally, the contact stated while driving 40 MPH, the vehicle shifted into first gear unintendedly. The contact stated that the failure had been recurring increasingly, causing the vehicle to accelerate or decelerate unintendedly. The dealer and several independent mechanics were contacted and informed the contact that the failure could be related to the transmission leadframe and the valve body; however, the vehicle was not diagnosed or repaired. The dealer informed the contact that the vehicle was not covered under NHTSA Campaign Number: 19V075000 (Power Train). The manufacturer was not notified of the failure. The failure mileage was approximately 143,000. The VIN was not available.

- Bristow, VA, USA

[XXX] [XXX] Cedar Rapids IA 52402 April 27 2024 [XXX] PHONE: [XXX] Dear NHTSA I have a 2011 Ford F150 5.0 with a 6 speed transmission and within the last few weeks I have had serious transmission issues that have become so bad it is not safe to drive. At any time the transmission will down shift on its own causing my speed to be reduced dramatically and usually becomes stuck in third gear and lose power. When I come to a stop light it will lung forward until I can get it out of third gear into neutral also some times when I pull out from a stop light while making a left turn it will change gears and the power will drop making it very dangerous to make a left turn in oncoming traffic. I researched the internet trying to find what would cause this and it didn-??t take long for hundreds of articles to pop up. Many articles said there was a recall in (2019) for the 2011s with a 6 speed transmission made in Dearborn Michigan and that would be mine. I called the Ford Motor Company last week and explained the issue I was having and gave them my VIN [XXX]. They agreed there had been issues with that transmission but my VIN didn-??t match any recalls, they did say they have a review board that looks at these problems along with NHTSA and may cover the cost to fix it so I should save my receipts. I then went to my local Ford Dealer and gave them the VIN they said Ford had an extended warranty for that transmission but now it is outdated? I did more research and found the following (Ford is issuing a safety recall on select 2011-13 Ford F-150 vehicles with 6-speed automatic transmission that may experience an intermittent loss of the transmission output speed sensor signal to the powertrain control module, potentially resulting in a temporary, unintended downshift into first gear. Feb 13, 2019) (DEARBORN, Michigan -?" Ford is recalling 201,900 vehicles in North America, including the 2011-'12 Ford F-150 and 201 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Cedar Rapids, IA, USA

The contact owns a 2011 Ford 150. The contact stated that while pressing the accelerator pedal a thumping noise was present coming from the transmission and the vehicle had experienced jerking and loss of power along with reduced speeds while driving and the service wrench had displayed. After restarting the engine the vehicle operated as normal but the failure continued to intermittently occur. The cause of the failure was not determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 31,870.

- Hobe Sound, FL, USA

1.) P2112- Throttle Actuator Control System stuck in closed position, no as I was able to get it to work again but looking at replacing the throttle body, so in the future yes. 2.) My saftey was at risk as it failed going over 70+ mph and made my vehicle shake violently. 3.)No but this is the 2nd time in 6 months this has happened. 4.) No 5.)had a power train lamp come on (2011 ford f150 wrench light) right as I lost complete throttle response going 72 MPH

- Crete, NE, USA

The lead frame on my truck was experiencing issues. The truck would intermittently randomly downshift at high speeds or get stuck in one gear. I was going 65+ mph on the freeway and and my truck shifted to second gear with no warning causing me to swerve and slam on the brakes. Other times my truck did it on surface streets. There were no warning lights or anything to let me know it would happen. After it downshifted, the wrench popped up on the dash, my speedometer went to 0, and my odometer read blank. Forcing me to pull over, restart the truck, in order to get it out of limp mode to be able to make it home. I took my truck to Ford of Valencia California where they inspected the truck and confirmed it was the lead frame. The issue was that at the time the part was on an 8 month back order so my only option was to replace the entire Valve body instead of only the lead frame. My truck was no longer under the recall and I was forced to pay for this out of pocket less than a month of purchasing the truck from a used dealership. My truck was only inspected by Ford of Valencia and no other agencies. Since this truck was my only form on transportation, I could not wait the 8 months for the lead frame to come in and had to pay out of pocket for the new valve body.

- Simi Valley, CA, USA

Was traveling down highway pulled into a gas station to get gas. Left gas station headed down road. Went to go pass a car when truck started to shift down a gear to pass it shifted all the way to 1st gear at 55 mph. It locked back wheels up for a moment but then released. Check engine light come on and I still on. Haven't drove truck but a few times since that happen. The truck is doing the same thing the ford recall of 2019. So I took it to ford where they diagnosed that it needed a new transmission and it had nothing to do with the recall. So it just been mainly seating in the yard.

- Red Boiling Springs, TN, USA

Lead frame. Known issue and was never replaced. Putting families at risk on highways

- San Antonio , TX, USA

The contact owns a 2011 Ford F-150. The contact stated while driving at various speeds, the transmission erroneously downshifted to first gear causing the vehicle to abruptly decelerate. During the failure, the service vehicle warning light was illuminated. The vehicle was taken to the local mechanic who diagnosed that the transmission leadframe had failed. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V075000 (Power Train). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 144,000.

- Surfside Beach, SC, USA

The transmission downshifts un-expectantly intermittently. The transmission also downshifts on the highway and locks up the wheels. The dealership indicated the time to have the repair made pursuant to the recall has expired. This appears to be a Ford F-150 eco Transmission problem as I've communicated with others online who have the same issues.

- Lilburn, GA, USA

Over the last few months on at least 15 occasions my transmission has tried to downshift into 1st gear while traveling highway speeds (55-65). Causing the tires lock up but I have always caught it and shifted into neutral to not cause any problems. After researching it sounds like this is a VERY COMMON issue that apparently hasn't been resolved with Fords TSB and software reflash. Also, while this happens my speedometer goes to zero and a wrench screen come up on the instrument panel for a split second.

- Walla Walla, WA, USA