While driving on the NYS Thruway my brake light came on and when I tried to engage my brakes it was difficult to push the pedal and the brakes were barely responsive. Now the brake pedal is difficult to push each time I start the vehicle and it barely stops when I begin moving. The rotors and pads are fine. My mechanic diagnosed the problem and it's a failed vacuum pump.

- Lockport, NY, USA

Ecoboost engine shut down on highway in rush hour traffic. Had my truck in the shop after $9526 in repairs and new engine it happened again this week. 1 year later. My truck was under 2 warranty extensions. And was in the Ford dealership at those times. I mentioned to service manager that it seems that possible could be the problem. Now I'm stuck with this mess. And it took 18 months for them to fix/ not fix it. Ford dealership

- Kankakee, IL, USA

Truck made rumbling/grinding noise from rear-right bedside area, then while approaching a stop sign, an attempt to slow+stop the truck was made, but the pedal went straight to the floor and vehicle proceded through intersection, after pulling into safe spot, brakes started functioning correctly again. A few hours later braking completely failed. Truck is currently sitting until we can have a diagnosis (and repair) done...

- Hazel Park, MI, USA

Service Advance Trac warning light comes on when backing while steering wheel turned. Multiple instances. Clears after a few minutes, but researching issue seems to be widespread across the Ford community, and has resulted in steering locking up while vehicle is in motion. Scheduled for maintenance visit to local dealership to diagnose. Codes read were C1963 & U0428

- Choctaw, OK, USA

Brakes seem to go in and out from time to time. I keep getting the service brake system light on and will turn itself off after next key cycle. Dealer advised vacuum pump issues this should be a full blown recall

- Cicero, IL, USA

Turning right the vehicle's steering and brakes locked up. The traction control system warning indicator illuminated. Rac and pinion unit replaced by Ford Dealer. Same problem occurred within 50 miles. Returned to Dealer. Dealer is unable to reproduce problem.

- Denham Springs, LA, USA

It appears the master cylinder is leaking into the large black vacuum piece. Parked and went into shop in Safeway. Then came out and loaded kids, wife and groceries. Started truck, started to back out of spot, then tried to stop and no brakes, low brake fluid then comes up. I threw it into park and tried to think what is going on. Check the brake fluid and it is empty. Then go to gas station and add 2.5 pints. Start truck and wife pulls brakes and gets back to working, but notice the brake fluid is decreasing from resivior but seemed to stop. I topped it off and started to drive because brakes were working. After driving about 10 blockes, the low brake fluid alarm comes up again and I pull over and no brakes. Finally investigate and still no leaks anywhere. Finally look up online and find this is a common problem and you have recalled 2014 through 2017, but not 2012 or 2013, but seems to be a problem with this year as well.

- Butte, MT, USA

On 22MAY2022 I started my vehicle and started pulling out of a parking space when I lost braking power. The failure resembled a similar issue I had in the past when the electronic vacuum pump failed and the brake pedal felt hard and required significant additional effort to bring the vehicle to a stop. The electronic vacuum pump and fuse has been replaced by the dealership previously. The unexpected brake failure caused me to roll farther than I wanted and hit the rock on my passenger side, rear door, causing minor body damage. Ford Customer Service said Customer Satisfaction Program 15N05 is a one time replacement and this vehicle is no longer eligible for the program since it has already been serviced. Additionally, they said any repair associated with this event is limited to 15N05 so body damage would not ne covered.

- Williston, VT, USA

The contact owns a 2012 Ford F-150. The contact stated that the brakes failed to function as needed at the initial start-up of the vehicle. After shifting to neutral(N) and waiting for a while, the brakes would function as needed. The contact stated that the previous owner had stated that the vehicle was included in a previous recall for the brake module. The vehicle had not been taken to the dealer by the contact nor had the vehicle been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 96,000.

- Portage, OH, USA

Brake Failure: The brake Vacuum Boost pump is failing which causes a loss of power assist brakes. This is a massive safety issue and can cause serious accidents. Oddly Fors no longer manufactures the Bracket to be able to replace the pump and there is no aftermarket alternative. My Dealer tells me their notes from ford say obtains from aftermarket but I have scoured the internet and nobody makes the bracket. IT's a terrible design and a huge safety issue that should be recalled completely. Ford watts to charge over $900 to fix it but cant even get the parts as described above. Transmission Lead Rail: Recently had the Transmission Lead rail fail whcih casued sudden downshiting at highway speeds and the shift indicator to not illuinate. THis again is a massive safetey issue that Ford issued sevral TSB on but never recalled. This almost got me killed on thehighway a few times. They charged me over $1500 to replace the LEAD rail when again this defcetive design and craftsmenship that is a massive safetey issue and should be fully recalled. Engine Stutter: My truck has almost always stuttered anytime you wne tover hal throtle, There are sveral TSB on this but FORD has not stepped up and taken care o fht eissue via recall. Apprnetly moisture build up in the inercooler and gets sucked into the intake due to poor design. Timing Chain Stretch: I now have Timing chain stretch, this also seems ot be quite common due to poor design. Rear Door Failure: I can no longer open my rear half door due to failure of internal plastic door components. You can research any o fhtese issues and find that htey are very common pronlems in F150 and other Ford vehicles due to their negligence in design and engineering and some are huge safetey issues that FORD has somehow been alloweed to ignore or issue insufficinet TSB instead of Recall.

- Wynantskill, NY, USA

Vacuum pump is bad again. This was previously recalled. The part has failed now for the third time. Only once was I reimbursed due to recall, but it has since failed twice more. Currently at 98,000 miles.

- Oak Ridge, NJ, USA

Vehicle sat idle in garage for two months. Started vehicle and brake pedal went to floor and was very soft. A warning was displayed on the instrument panel showing low brake fluid. Noting that master cylinder reservoir was almost empty I purchased a pint of DOT 3 brake fluid which I added to reservoir to "MAx" fill line. Started vehicle, brakes pumped up to a normal pedal pressure, took for a short test drive slowly testing brakes. All seemed normal at that time. Approximately 3 hours later I started vehicle, again noting that the brake pedal went to the floor. Checked the reservoir and found it almost empty again. Looked under vehicle and found no indication of fluid in any of the four corners by the wheels nor under the master cylinder. It is my belief that the fluid is leaking into the brake booster a problem which was addressed in a Safety Recall 20S31 issued by Ford Motor Company for a series of vehicles which although does not include my vehicle I believe that this issue is directly related and could also cause serious injury and/or damage if not repaired. I will have this issue fixed at my expense, however, I would be interested to learn if any other 2012 vehicles have experienced this problem.

- New Smyrna Beach, FL, USA

I have a 2012 f150 platinum eco boost When starting vehicle in morning I would here a strange noise coming from the front driver side, now I leave out of driveway after starting and when I apply brakes the truck will not stop like there is no brake pressure and feels like anti locks are on, I have to sit for a couple minutes and then they work but they only appear to work manually I have to push brake pedal hard, I tried diagnosing like the forum says I put my foot on brake and start vehicle, the brake pedal stays hard and does not move, they say if this happens it is the brake vacuum pump. There is a recall 15N05 on my year vehicle but Ford says my vehicle isn-??t covered it-??s under the mileage and the correct year, I have to buy the pump myself, why isn-??t Ford honoring the recall I just ordered part and if needed will upload the invoice later

- Dover, DE, USA

2012 Ford F-150. Consumer writes in regards to electric vacuum pump safety recall.

- Gardner, MA, USA

There is an issue with the electric brake vacuum pump. It males a loud noise when brakes are used and makes the brake pedal difficult to press down on and have a positive brake reaction. The first distance traveled after initial startup has very little brake activity due to the pump not creating brake pressure. It appears that it is a known issue by Ford as some trucks have been recalled based on their manufacture location, my truck was not made at the location needed to qualify for the recall and fix of the problem, however the same issue exists as those that do qualify.

- Boscobel, WI, USA

The electric vacuum pump for the brakes is making a loud buzzing noise. Ford says that this is a known issue and it isn't a problem. After doing some research I found out that this is just the beginning of the brakes going out. Although, there is not a recall for this issue. I'm not sure how there can't be a recall if this is a known issue in all 2011 and 2012 Ford F150S.

- Colorado Springs, CO, USA

I have had to replace front rotors and all pads at 8000 miles, replaced all 4 rotors and pads at 22,000 miles. I am now at 30,000 miles and now have no power assist. This year and model is know to have issues with the vacuum assist pump, which Ford is not willing to replace. When backing down the driveway I lost braking and hit a sign on the other side of street opposite my driveway.

- Beaver, PA, USA

Brakes make scrapping noise wiper motor. Speed of wipers does not change after 2nd advance

- Jackson, MI, USA

While coming to stop my brakes failed and went to the floor. On exit 32 eastbound I-90. Thank god there were no other cars in front of me. After looking online there is a recall for 2013 -2014 Ford 150 that were manufactured at the same plant as my truck. In our research it takes the same master brake cylinder as the recalled trucks. Our truck only has 78,000 miles on it.

- North Bend, WA, USA

Brake vacuum pump failure on residential city street, heard the pump running, then a gush of air resulting in extended stopping distance due to soft brake pedal. This part has been recalled in Canada.

- Kansas City, MO, USA